A biodegradable semi-interpenetrating hydrogel network (semi-IPN) of polyacrylamide and gelatin was prepared using polycaprolactone diacrylate (mol. wt ∼ 640) as a crosslinker. The drug-polymer interaction and IPN formation were investigated by attenuated total reflectance-Fourier transform infrared (ATR-FTIR) and thermal gravimetric analysis (TGA). Scanning electron micrographs of lyophilized matrices revealed porous internal structure with varying pore sizes under equilibrium hydrated conditions, depending upon formulation composition. pH-dependent swelling and degradation was enhanced with increasing gelatin content and decreasing crosslinker concentration (Cs). Compression modulus (CM) (at 20% strain) increased significantly from 23 ± 1.4 to 75 ± 2.7 kPa (p < 0.02) with increasing Cs (from 0.5 to 2.0 mol%), while it decreased from 162 ± 6.4 to 23 ± 1.4 kPa (p < 0.05) with decreasing PAm/G ratio. Cell viability studies by MTT assay showed excellent cytocompatibility of matrices with fibroblast L929 cells. Curcumin, a hydrophobic phytochemical, was loaded by a diffusion method and its release profile was investigated in 4% w/v aqueous BSA solution at 75 rpm (at 37 ± 0.2 °C). Fitting of drug release data in the Korsmeyer-Peppas model suggested sustained release behavior up to 10 days with a combination of diffusion and erosion mechanism (0.5 < n < 1.0; M(t)/M(∞) ≤ 0.6). The newly developed porous, biodegradable and elastic semi-IPNs may serve as an ideal matrix for controlled drug release and wound healing applications. The possibilities can be explored for pharmaceutical and tissue engineering applications.

The article describes the design of the multicomponent hydrogel system of poly(acrylic acid-HEMA)/gelatin for tissue engineering application. Derivative of polycaprolactone-diol (polycaprolactone diacrylate (PCL-DAr)) was used to cross-link acrylate monomers whereas gelatin was kept free for cell proliferation. Epigallocatechin gallate (EGCG), an anti-oxidant phytochemical, was loaded by diffusion method. Its in vitro release study in PBS (pH 6.5) at 37 ± 0.2°C (75 rpm) revealed a sustained release profile upto 20 days. Fitting of drug release data in Korsmeyer-Peppas model equation revealed probable release mechanism through the value of release coefficient (n), which was found to depend on formulations composition. Drug-polymer interaction, thermal behavior, and surface morphology were investigated by attenuated total reflectance-Fourier transform infrared (ATR-FTIR) spectroscopy, thermogravimetric analysis (TGA), and scanning electron microscopic (SEM). Swelling behavior of hydrogel in PBS (pH 6.5 and 7.4, 0.2 M) and in distilled water was found to increase with increasing AAc/HEMA ratio. Compression modulus decreased from 203 ± 3.7 KPa to 11.6 ± 1.1KPa, at 30% strain, whereas displacement values significantly increased from 3.2 ± 0.2 to 4.7 ± 0.6 mm at 20 N force (p < 0.05), with increasing AAc/HEMA ratio. Percentage cell viability was analyzed using indirect 3-[4, 5-dimethylthiazolyl-2]-2,5-diphenyltetrazo-liumbromide (MTT) assay with fibroblast L929 cells; showed ≥92.3% cell viability after 24 h incubation. Cell proliferation on the scaffold surface was found to increase with incorporation of HEMA in P(AAc)/G cross-linked hydrogel matrix upto a certain extent. These biocompatible, elastic, and swellable hydrogels can serve as a matrix for drug delivery and tissue engineering applications.

Present investigation involves the development of a bi-layer dressing of gelatin nanofibrous mat loaded with epigallocatechin gallate (EGCG)/poly vinyl alcohol (PVA) hydrogel and its in-vivo evaluation on full-thickness excision wounds in experimental Wistar rats. Nanomorphological observation, porosity, effect of crosslinking on tensile strength, physical stability and drug release profile in phosphate buffer and biocompatibility aspects of electrospun nanomat were investigated by various physico-chemical tools. EGCGa release profile was found to increase from 2-4 days with decreasing crosslinking time from 15 to 5 min. PVA hydrogels were prepared by freeze-thaw method and has been utilized as a protective and hydrating outer layer of the bi-layer dressing. Topical application of bi-layer composite dressing loaded with EGCG improve the healing rate in experimental rats as acute wounds model which was evidenced by significant increase in DNA (approximately 42%), total protein (approximately 32%), hydroxyproline (approximately 26%) and hexosamine approximately 24%) contents. A faster wound contraction was observed in wounds treated with composite dressing from approximately 14% to 47%. Histopathological examination revealed significant improvement in angiogenesis, re-epithelialization and less inflammatory response in comparison to control. Van-Gieson's collagen stains revealed matured, compact and parallel deposition of collagen fibrils on day 12. These results were supported by up-regulated expressions of matrix metalloproteinase (MMPs-2 and 9) by gelatin zymography. Control release of EGCG, 3D porous architecture of nanofibrous scaffolds as well as moist microenvironment provides ideal conditions for uninterrupted wound healing.

In this study, the effect of feed composition, degree of hydrophilicity, and internal morphology has been investigated for cell proliferation potential of the polyacrylamide/gelatin (PAm/G) semi-interpenetrating polymeric network (semi-IPNs). Polycaprolactone diacrylate was used to cross-link polyacrylamide chains. Scanning electron microscopy (SEM) micrographs demonstrate uniformly distributed porous structure with internal diameter in the range of 75-175 μm, dependent on matrix compositions. Water-air contact angle was found in the range of 49° ± 0.22 to 89° ± 0.14 (p < 0.02) suggesting varying degree of hydrophilicity of the hydrogel surface. In addition, protein adsorption study showed 45 ± 0.14 μg to 64 ± 0.12 μg (p < 0.01) of protein adsorbed per cm² of hydrogel. Quantitative estimation of cell adhesion and proliferation was carried out by DNA quantification using fluorimetric assay method (p < 0.02). Microscopic images of proliferative cells on semi-IPNs by fluorescent and inverted phase contrast supported the findings of DNA quantification. Contact angle in the range of 63-69° in association with 52-59 μg/cm² protein absorption and 115-150 μm pore size was found optimum for fibroblast proliferation on PAm/G semi-IPN scaffolds. The newly developed semi-interpenetrating network may serve as a potential scaffold for soft tissue-engineering applications.

A nanocomposite reservoir-type hydrogel dressing of poly vinyl alcohol (PVA) was fabricated by a freeze-thaw method and loaded with silver-nanoparticle-coated chitosan wafers (Ag-CHWs). The Ag-CHWs were synthesized by a sonication technique with silver nitrate (AgNO 3 ) and chitosan powder. Scanning electron microscopy images showed silver nanoparticles (AgNPs) with a size range of 10 6 4 nm on the surface of the chitosan wafers, and the antibacterial efficacy (minimum inhibitory concentration) of the Ag-CHWs was measured against Pseudomonas aeruginosa (32 mg/mL), Staphylococcus aureus, (30 mg/mL) and Escherichia coli (32 mg/mL). The antimicrobial PVA hydrogel showed an improved tensile strength ($0.28 MPa) and gel content ($92%) in comparison with the blank hydrogels. Full-thickness-excision wound studies of the nanocomposite dressing on Wistar rats revealed enhanced wound contraction, improved inflammation response, re-epithelization rate, neoangiogenesis, and granulation tissue formation in comparison to the control group. A flexible, biocompatible, nanocomposite reservoir dressing not only established the chitosan as a stabilizer but also proved the efficacious and safe utility of AgNPs toward chronic wound management. V C 2016 Wiley Periodicals, Inc. J.Appl. Polym. Sci. 2016, 133, 43472.

An innovative concept of spontaneous film dressing has been designed as sprayed hydrogel dressings (SHD) using a blend of polyvinyl alcohol (PVA) and sodium alginate (SA) as synthetic and natural polymeric components and, were crosslinked with boric acid and calcium chloride, respectively. Silver nanoparticles (AgNPs) are synthesized by green chemistry using Ficus benghalensis extract (FB) and were characterized by SEM and zeta sizer. FTIR spectra show polymeric interaction with AgNP s , while SEM images show outer surface of the SHD film. Equilibrium swelling and degradation in aqueous media (distilled water and buffers) are found to be dependent upon PVA/SA ratio. Polymeric combination exhibit pseudoplastic behavior with Farrow's constant >1. Uniformly distributed AgNPs (particle size 27.55 6 2.01 nm), high water retention (13 fold), and biodegradable (5 days) nature of dressing along with sustained release profile of both AgNPs and extract with concentration-dependent antimicrobial activity have been observed for 24 h. Self shaped, biodegradable, aseptic, prolong anti-oxidative, non-hemolytic, blood compatible, and hemostatic properties of SHD film appears as promising dressing for superficial wounds.

No abstract

No abstract