Glycerol is a by-product generated in large amounts during the production of biofuels. This study presents an alternative means of crude glycerol valorization through the production of erythritol and mannitol. In a shake-flasks experiment in a buffered medium, nine
Yarrowia lipolytica
strains were examined for polyols production. Three strains (A UV’1, A-15 and Wratislavia K1) were selected as promising producers of erythritol or/and mannitol and used in bioreactor batch cultures and fed-batch mode. Pure and biodiesel-derived crude glycerol media both supplemented (to 2.5 and 3.25 %) and not-supplemented with NaCl were applied. The best results for erythritol biosynthesis were achieved in medium with crude glycerol supplemented with 2.5 % NaCl. Wratislavia K1 strain produced up to 80.0 g l
−1
erythritol with 0.49 g g
−1
yield and productivity of 1.0 g l
−1
h
−1
. Erythritol biosynthesis by A UV’1 and A-15 strains was accompanied by the simultaneous production of mannitol (up to 27.6 g l
−1
). Extracellular as well as intracellular erythritol and mannitol ratios depended on the glycerol used and the presence of NaCl in the medium. The results from this study indicate that NaCl addition to the medium improves erythritol biosynthesis, and simultaneously inhibits mannitol formation.
An acetate-negative mutant of Yarrowia lipolytica Wratislavia K1 was selected that, when grown with 300 g raw glycerol l(-1) at pH 3, produced 170 g erythritol l(-1) after 7 days, corresponding to a 56% yield and a productivity of 1 g l(-1) h(-1). The Wratislavia K1 strain did not produce citric acid.
Yarrowia lipolytica A-101-1.22 produces high citric acid (112 g l(-1)) with a yield of 0.6 g g(-1) and a productivity of 0.71 g l(-1) h(-1) during batch cultivation in the medium with glycerol-containing waste of biodiesel industry. However, it was observed that the specific citric acid production rate, which was maximal at the beginning of the biosynthesis, gradually decreases in the late production phase and it makes continuation of the process over 100 h pointless. The cell recycle and the repeated batch regimes were performed as ways for prolongation of citric acid synthesis by yeast. Using cell recycle, the active citric acid biosynthesis (96-107 g l(-1)) with a yield of 0.64 g g(-1) and a productivity of 1.42 g l(-1) h(-1) was prolongated up to 300 h. Repeated batch culture remained stable for over 1000 h; the RB variant of 30% feed every 3 days showed the best results: 124.2 g l(-1) citric acid with a yield of 0.77 g g(-1) and a productivity of 0.85 g l(-1) h(-1).
Three acetate mutants of the yeast species Yarrowia lipolytica were screened using batch cultivation. The strain Y. lipolytica 1.31 was found to be the most suitable for citric acid production from raw glycerol, a by-product of biodiesel production from rapeseed oil. At the initial concentration of glycerol of 200 g dm−3, the citric acid production of 124.5 g dm−3, yield of 0.62 g g−1, and productivity of 0.88 g dm−3 h−1 were achieved.
This study shows a possible microbial process for utilization of crude glycerol generated by the biodiesel industry for citric acid and erythritol production. Simultaneous production of citric acid and erythritol under nitrogen-limited conditions with glycerol as the carbon source was achieved with an acetate negative mutant of Y. lipolytica Wratislavia K1 in fed-batch cultivations. The effect of the initial glycerol concentration (from 30–180 g dm−3) on the citrate and erythritol production was investigated. As a result of the experiments, maximum citric acid production (110 g dm−3) and a very high amount of erythritol (81 g dm−3) were determined after 168 h of fed-batch cultivation with the initial glycerol concentration of 150 g dm−3 and the total glycerol concentration of 250 g dm−3. In addition, the citric acid to isocitric acid ratio of the products from this strain was 35.5:1.
Citric acid and erythritol biosynthesis from pure and crude glycerol by three acetate-negative mutants of Yarrowia lipolytica yeast was investigated in batch cultures in a wide pH range (3.0-6.5). Citric acid biosynthesis was the most effective at pH 5.0-5.5 in the case of Wratislavia 1.31 and Wratislavia AWG7. With a decreasing pH value, the direction of biosynthesis changed into erythritol synthesis accompanied by low production of citric acid. Pathways of glycerol conversion into erythritol and citric acid were investigated in Wratislavia K1 cells. Enzymatic activity was compared in cultures run at pH 3.0 and 4.5, that is, under conditions promoting the production of erythritol and citric acid, respectively. The effect of pH value (3.0 and 4.5) and NaCl presence on the extracellular production and intracellular accumulation of citric acid and erythritol was compared as well. Low pH and NaCl resulted in diminished activity of glycerol kinase, whereas such conditions stimulated the activity of glycerol-3-phosphate dehydrogenase. The presence of NaCl strongly influenced enzymes activity - the effective erythritol production was correlated with a high activity of transketolase and erythrose reductase. Therefore, presented results confirmed that transketolase and erythrose reductase are involved in the overproduction of erythritol in the cells of Y. lipolytica yeast.
scite is a Brooklyn-based organization that helps researchers better discover and understand research articles through Smart Citations–citations that display the context of the citation and describe whether the article provides supporting or contrasting evidence. scite is used by students and researchers from around the world and is funded in part by the National Science Foundation and the National Institute on Drug Abuse of the National Institutes of Health.