Развитие собственной сырьевой базы, полностью обеспечивающей потребности коньячного производства в высококачественном сырье, является одной из приоритетных задач в решении проблемы импортозамещения. Перспективным направлением в расширении сортовой структуры виноградарства является увеличение посадок лучших сортов винограда различного происхождения (интродуцированных, аборигенных и селекционных). Однако потенциальные возможности этих сортов винограда изучены недостаточно. В статье представлены результаты исследования физико-химических и биохимических показателей интродуцированных, селекционных и аборигенных сортов винограда. Изучен состав ароматобразующих компонентов полученных из них коньячных виноматериалов и дистиллятов, установлена их взаимосвязь с показателями винограда. Обоснованы значимые для формирования ароматического комплекса коньячных виноматериалов и дистиллятов показатели технологической оценки винограда: массовая концентрация сахаров, титруемых кислот, фенольных веществ в сусле после прессования целых ягод винограда, показатель технологического запаса фенольных веществ, величина рН и МФМО-активность. Установлены их параметры для коньячного производства. Предложенные показатели могут быть использованы при оценке технологических свойств новых сортов винограда для коньячного производства, а также для регулирования уровня ароматобразующих компонентов в коньячных виноматериалах и дистиллятах. The development of indigenous base of raw materials, meeting needs of brandy production in high-quality raw materials, is one of top tasks in solving the problem of import substitution. Promising direction in extension of the varietal structure of viticulture is to increase the planting of the best grape varieties of different origin (alien, native and breeding). However, the capabilities of these grape varieties are not well studied. The article presents the results of research of the physical-chemical and biochemical parameters of alien, breeding and native grape varieties. We studied the content of aroma-producing components, brandy wine materials and distillates obtained; established the relationship with grape parameters; substantiated technological evaluation parameters of grapes, relevant for the formation of the aromatic complex of brandy wine materials and distillates: mass concentration of sugars, titratable acids, phenolic substances in the must after grapes crushing, the parameter of technological stock of phenolic substances, the pH value and MPhMO-activity. The parameters of technological assessment for brandy production were established. The proposed values can be used to assess the technological properties of new grape varieties for brandy production, as well as to regulate the level of aroma-producing components in brandy wine materials and distillates.
Сложные эфиры являются важной составляющей в сложении букета коньяков, в количественном отношении уступая только высшим спиртам. Уровень их содержания в коньячных виноматериалах и дистиллятах зависит от многих факторов (сорта винограда, агроэкологических условий его произрастания, технологии получения виноматериалов и дистиллятов и др.). В связи с этим исследования, направленные на регулирование комплекса ароматических веществ коньячных виноматериалов и дистиллятов с целью повышения их качества являются актуальными. Представленные в статье результаты исследований позволили оценить влияние некоторых физико-химических и технологических факторов на ароматобразующий состав коньячных виноматериалов и дистиллятов. Установлено, что с повышением степени зрелости винограда в коньячных виноматериалах образуется больше средних эфиров. Наиболее существенный их прирост в виноматериалах установлен при массовой концентрации сахаров в винограде 162-175 г/дм3. Выявлено, что технологические обработки сусла оказывают положительное влияние на состав ароматобразующих веществ виноматериалов. Эффективность обработок возрастает при содержании фенольных веществ в сусле более 400 мг/дм3. Изучено влияние 12 рас дрожжей из КМВ ФГБУН «ВННИИВиВ «Магарач» и установлена целесообразность использования рас дрожжей вида Saccharomyces oviformis, обладающих повышенной способностью к синтезу эфиров. Показано, что брожение сусла без доступа кислорода воздуха способствует повышению содержания в виноматериалах и коньячных дистиллятах суммы летучих компонентов, в т.ч. средних эфиров. Результаты исследований могут быть использованы для оптимизации технологических режимов и параметров производства коньячных виноматериалов и дистиллятов с целью повышения их качества. Esters are the essential components in the composition of brandy bouquet, in terms of quantity giving place only to higher alcohols. Their level of content in brandy base wines and distillates depends on many factors (grape variety, agroecological conditions of growing, production technology of base wines and distillates, etc.). In this regard, the studies aimed at regulating the complex of aromatic substances of brandy base wines and distillates in order to improve their quality are relevant now. The research results presented in the article made it possible to assess the effect of some physicochemical and technological factors on the aroma-producing composition of brandy base wines and distillates. It was found that increasing of the degree of grape maturity raises the formation of medium-chain esters in brandy base wines. The most significant increase of esters in base wines was established at mass concentration of sugars in grapes - 162-175 g/dm3. It was revealed that technological processing of the must positively effects the composition of aroma-producing substances of base wines. The effectiveness of the processing increases when the content of phenolic substances in the must is more than 400 mg/dm3. The influence of 12 yeast races from the Collection of Microorganisms of Winemaking of the FSBSI Institute Magarach was studied, the expediency of using yeast races of the Saccharomyces oviformis species, possessing an increased ability to synthesize esters, was established. It was shown that must fermentation without the access of air oxygen contributes to an increase in the content of the sum of volatile components, including medium-chain esters, in base wines and brandy distillates. The research results can be used to optimize the technological modes and parameters of production of brandy base wines and distillates in order to improve their quality.
В работе представлены результаты исследований влияния эндополигалактуроназы дрожжей рода Kluyveromyces marxianus на процессы отделения и осветления сусла, а также качество коньячных виноматериалов и дистиллятов. Проблемой виноделия является высокое содержание полисахаридов в виноградной ягоде, что снижает выход сусла, затрудняет процессы его осветления, способствует окислению и обогащению нежелательными компонентами, ухудшающими качество готового продукта. Использование ферментных препаратов пектолитического действия в коньячном производстве ограничено из-за риска увеличения содержания метанола, который образуется при действии на пектины винограда пектинэстеразы. Перспективным направлением является использование в коньячном производстве эндополигалактуроназы, продуцируемой дрожжами вида Kluyveromyces marxianus . Установлено, что обработка сусла и мезги опытным ферментным препаратом, полученном при культивировании штамма дрожжей вида Kluyveromyces marxianus , способствует увеличению выхода сусла, снижению содержания взвесей и объема образующегося осадка при осветлении сусла, повышению его качества. Показано, что физико-химический состав виноматериалов и дистиллятов, полученных из обработанного сусла, практически не изменяется. Массовая концентрация метанола в опытных коньячных виноматериалах и дистиллятах не превышала уровня контрольных образцов. Установлена эффективность использования препарата в коньячном производстве с целью повышения выхода и качества сусла. The article presents the results of study on the influence of endopolygalacturonase yeast species Kluyveromyces marxianus on the processes of separation and clarification of must, as well as the quality of brandy wine materials and distillates. The problem of winemaking is the high content of polysaccharides in grape berries, which reduces the yield of must, complicates the process of clarification, contributes to the oxidation and enrichment with undesirable components degrading the quality of the finished product. Use of pectolytic enzymes in brandy production is limited due to the risk of increase in the content of methanol, appearing when pectin esterase acts on grape pectins. Use of endopoligalacturonase rendered by the yeast species Kluyveromyces marxianus is a promising direction in brandy production. It was found that treatment of the must and pulp with experimental enzyme preparation obtained by culturing a yeast strain of the species Kluyveromyces marxianus contributes to an increase in the yield of the must and a decrease in the content of suspensions and volume of the sediment formed in the process of must clarification, and quality improving. It was shown that the physicochemical composition of wine materials and distillates obtained from the treated must remained permanent. Mass concentration of methanol in the experimental brandy wine materials and distillates did not exceed the level of control samples. The effectiveness of use of the preparation in brandy production was established in order to increase the product yield and quality of the must.
scite is a Brooklyn-based organization that helps researchers better discover and understand research articles through Smart Citations–citations that display the context of the citation and describe whether the article provides supporting or contrasting evidence. scite is used by students and researchers from around the world and is funded in part by the National Science Foundation and the National Institute on Drug Abuse of the National Institutes of Health.
customersupport@researchsolutions.com
10624 S. Eastern Ave., Ste. A-614
Henderson, NV 89052, USA
Copyright © 2024 scite LLC. All rights reserved.
Made with 💙 for researchers
Part of the Research Solutions Family.