Разработана технология экструдированных безглютеновых снеков с использованием в качестве частичной замены безглютенового сырья - рисовой муки ферментализатом пшеницы, глютен которой предварительно прогидролизован комплексом протеолитических и амилолитических ферментных препаратов. Иммуноферментным методом анализа подтверждено соответствие содержания глютена в сырье и гидролизате требованиям Технического регламента Таможенного союза 027/12, предъявляемым к безглютеновой продукции. Полученный гидролизат насосом-дозатором подавался в камеру экструдера в количестве до 35 % к массе перерабатываемой сухой смеси на основе рисовой муки. Было изучено влияние дозировки ферментолизата пшеницы на режимные параметры экструзии, изменение структурно-механических, цветовых и органолептических характеристик полученных образцов снеков. Установлено, что с увеличением содержания гидролизата в перерабатываемой смеси возрастает влажность экструдата, отобранного после режущего устройства, в процессе экструдирования снижаются значения момента сдвига, давления, температуры экструзии, а также удельного расхода. Изменение количества вносимого ферментолизата пшеницы значимо изменяло структурно-механические показатели экструдатов. В снеках без гидролизата значение твердости составляло 6,7 Н, а с добавлением ферментолизата отмечалось увеличение до 14,6 Н. Обратная тенденция установлена для показателей коэффициента взрыва и количества микроразломов, значения которых с ростом дозировки гидролизата снижались с 8,6 до 4,1 и с 14,3 до 6,0 соответственно. Отмечено увеличение значений хроматических составляющих цвета снеков при добавлении ферментолизата в экструдируемую смесь, при этом варьирование его дозировкой не оказывало значимого влияния на изменение цветовых характеристик. По результатам дегустации более высокие оценки получили образцы снеков с добавлением 15-20 % гидролизата пшеницы. Whole wheat flour has been hydrolyzed by a complex of proteolytic and amylolytic enzymes in order to eliminate gluten and allergenic peptides. The resulting hydrolysate was tested in gluten-free snack extrusion technology as a substitute for rice flour. The enzyme-linked immunosorbent assay confirmed the compliance of the gluten content in raw materials and hydrolysate with the requirements of the Technical Regulations of the Customs Union 027/12 for gluten-free products. The resulting hydrolysate was fed by a metering pump into the extruder chamber in an amount up to 35 % by weight of the processed dry mixture based on rice flour. The effect of the dosage of wheat hydrolysate on the operating parameters of extrusion, the changes in the structural, color and organoleptic characteristics of the snacks was studied. It has been established that the moisture content of the extrudate taken out after the cutting device increases with an increase in the content of hydrolysate in the processed mixture. At the same time, the values of torque, pressure, extrusion temperature, as well as specific mechanical energy decreased. The content of hydrolysate in the mixture significantly influenced the structural properties of snacks. The hardness value of the snacks without hydrolysate was 6.7 N. It increased to 14.6 N with the addition of hydrolysate up to 35 %. The opposite trend was established for sectional expansion index and the number of fractures, the values of which decreased from 8.6 to 4.1 and from 14.3 to 6.0, respectively. Adding wheat hydrolysate was significant in changing the color characteristics of the extrudates, while the dosage value did not have a significant effect on the color of snacks. According to the results of sensory analysis, samples of the extruded snacks with the addition of 15-20 % wheat hydrolysate received higher scores.
Рассмотрены основные аспекты использования экструзии крахмалсодержащего сырья как стадии его подготовки к биоконверсии. Показана возможность получения гидролизатов с концентрацией сухих веществ до 50-60 %, декстрозным эквивалентом мальтодекстринов 20-40, глюкозных сиропов - до 95 ДЭ. The main aspects of using starch extrusion as a pretreatment stage for subsequent bioconversion are discussed. The possibility of obtaining hydrolysates with solids up to 50-60% is shown. The dextrose equivalent of maltodextrins obtained after the extrusion pretreatment step was 20-40. DE of glucose syrups reached 95.
В данной работе исследована возможность кон центрирования ингредиентов различного состава, полученных с применением ферментативных систем целевого назначения, на современных мембранных установках. Наработаны опытные образцы товарных форм ингредиентов из рябины сушеной. In this work, we investigated the possibility of concentrating ingredients of various compositions, obtained with the use of targeted enzymatic systems, in modern membrane installations. Prototypes of commercial forms of ingredients from dried mountain ash have been developed.
scite is a Brooklyn-based organization that helps researchers better discover and understand research articles through Smart Citations–citations that display the context of the citation and describe whether the article provides supporting or contrasting evidence. scite is used by students and researchers from around the world and is funded in part by the National Science Foundation and the National Institute on Drug Abuse of the National Institutes of Health.
hi@scite.ai
10624 S. Eastern Ave., Ste. A-614
Henderson, NV 89052, USA
Copyright © 2024 scite LLC. All rights reserved.
Made with 💙 for researchers
Part of the Research Solutions Family.