The presence of leachable alkali ions, or their hydrated sites in the glass, is believed to be a determining factor for the interfacial water structure at the glass surface, influencing the surface properties of glass. The interfacial water structure on soda‐lime silicate glass in humid ambience at room temperature was analyzed with sum‐frequency‐generation (SFG) vibration spectroscopy, which can probe the interfacial water layer without spectral interferences from the gas phase water. The soda‐lime glass surface exposed to water vapor shows three sharp SFG peaks at 3200, 3430, and 3670 cm−1 in SFG, which is drastically different from the SFG spectra of the water layers on the fused quartz glass surface and the liquid water/air interface. The sharp peak at 3200 cm−1 is believed to be associated with the hydronium ions in the Na+‐leached silicate glass surface. The 3200 cm−1 peak intensity varies with the relative humidity, indicating its equilibrium with the gas phase water. It is proposed that the hydronium ions in the Na+‐leached sites produce compressive stress in the silicate glass surface; thus the growth of hydronium ions with increasing humidity might be responsible for the increased wear resistance of soda‐lime glass surfaces in near‐saturation humidity conditions.

No abstract

This paper describes the direct deposition of hydrocarbon coatings with a static water contact angle higher than 150 using simple C6 hydrocarbons as a reactive gas in helium plasma generated in ambient air without any preroughening of the silicon (100) substrate. The film morphology and hydrophobicity are found to strongly depend on the structure of the reagent hydrocarbon. The films deposited with n-hexane and cyclohexane exhibited relatively smooth morphology and the water contact angle was only ∼95°, similar to polypropylene. When benzene was used as a main reactive gas, the deposited film surface showed nanoscale textured morphology and superhydrophobicity with a water contact angle as high as 167°. Because the plasma is generated in air, all films show some degree of oxygen incorporation. These results imply that the incorporation of a small amount of oxygenated species in hydrocarbon films due to excitation of ambient air is not detrimental for superhydrophobicity, which allows the atmospheric rf plasma with the benzene precursor to produce rough surface topography needed for superhydrophobicity.