BackgroundSimultaneous wastewater treatment and lipid production by oleaginous microalgae show great potential to alleviate energy shortage and environmental pollution, because they exhibit tremendous advantages over traditional activated sludge. Currently, most research on wastewater treatment by microalgal are carried out at optimized temperature conditions (25–35 °C), but no information about simultaneous wastewater treatment and lipid production by microalgae at low temperatures has been reported. Microalgal growth and metabolism will be inhibited at low temperature conditions, and satisfactory wastewater treatment performance will be not obtained. Therefore, it is critical to domesticate and screen superior microalgal strains with low temperature adaptability, which is of great importance for wastewater treatment and biodiesel production.ResultsIn this work, simultaneous wastewater treatment and lipid production were achieved by a microalgal mutant Scenedesmus sp. Z-4 at the low temperature conditions (4, 10, and 15 °C). The results showed that algal growth was inhibited at 4, 10, and 15 °C compared to that at the optimal temperature of 25 °C. However, decreased temperature had no significant effect on the total cellular lipid content of algae. Importantly, lipid productivity at 10 °C was compromised by more net energy output relevant to biodiesel production, which demonstrated that the low temperature of 10 °C was favorable to wastewater treatment and energy recovery by Scenedesmus sp. Z-4. When molasses wastewater with optimal COD concentration of 8000 mg L−1, initial inoculation ratio of 15%, and C/N ratio of 15 was used to cultivate microalgae, the maximum removal rate of COD, TN, and TP at 10 °C reached 87.2, 90.5, and 88.6%, respectively. In addition, lipid content of 28.9% and lipid productivity of 94.4 mg L−1 day−1 were obtained.Conclusions Scenedesmus sp. Z-4 had good adaptability to low temperature conditions, and showed great potential to realize simultaneous wastewater treatment and lipid production at low temperatures. The proposed approach in the study was simple compared to other wastewater treatment methods, and this potential novel process was still efficient to remove COD, N, and P at low temperatures. Thus, it had a vital significance for the wastewater treatment in low temperature regions.Electronic supplementary materialThe online version of this article (doi:10.1186/s13068-017-0797-x) contains supplementary material, which is available to authorized users.

No abstract

Background: Microalgae as a viable biodiesel feedstock show great potential to approach the challenges of energy shortage and environment pollution, but their economic feasibility was seriously hampered by high production cost. Thus, it is in urgent need to reduce the cost of cultivation and improve the biomass and lipid production of microalgae. In this work, anaerobic digestion effluent from cattle manure combined with municipal wastewater was used as a cost-effective medium for cultivating microalgae and expected to obtain high biomass. The pretreatment of anaerobic digested effluent containing dilution rate, sterilization and nutrient optimization was investigated. Then, initial pH and light intensity for algal growth, lipid production and wastewater purification were optimized in this study. Results: Scenedesmus sp. could grow rapidly in 10% anaerobic digestion effluent from cattle manure combined with secondary sedimentation tank effluent without sterilization. Optimum nutrient additives for higher biomass were as follows: glucose 10 g/L, NaNO 3 0.3 g/L, K 2 HPO 4 •3H 2 O 0.01 g/L, MgSO 4 •7H 2 O 0.075 g/L and trace element A5 solution 1 mL/L. Biomass of 4.65 g/L and lipid productivity of 81.90 mg/L/day were achieved during 7-day cultivation accompanying over 90% of COD, NO 3 −-N, NH 4 +-N, and 79-88% of PO 4 3−-P removal with optimized initial pH of 7.0 and light intensity of 5000 l×. The FAME profile in ADEC growth medium consisted in saturated (39.48%) and monounsaturated (60.52%) fatty acids with the 16-to 18-chain-length fatty acids constituting over 98% of total FAME. Conclusions: This study proves the potential of anaerobic digested effluent combined with municipal wastewater for microalgae culture, and provides an effective avenue for simultaneous microalgal lipid production and treatment of two kinds of wastewater.

No abstract

The exploration of efficient and economical persulfate activators in persulfate-based advanced oxidation process for wastewater treatment is in urgent need. In this work, sewage sludge from wastewater treatment plant was...