a b s t r a c tSintering of nanoparticles is an important contributor to loss of activity in heterogeneous catalysts, such as those used for controlling harmful emissions from automobiles. But mechanistic details, such as the rates of atom emission or the nature of the mobile species, remain poorly understood. Herein we report a novel approach that allows direct measurement of atom emission from nanoparticles. We use model catalyst samples and a novel reactor that allows the same region of the sample to be observed after short-term heat treatments (seconds) under conditions relevant to diesel oxidation catalysts (DOCs). Monometallic Pd is very stable and does not sinter when heated in air (T 6 800°C). Pt sinters readily in air, and at high temperatures (P800°C) mobile Pt species emitted to the vapor phase cause the formation of large, faceted particles. In Pt-Pd nanoparticles, Pd slows the rate of emission of atoms to the vapor phase due to the formation of an alloy. However, the role of Pd in Pt DOCs in air is quite complex: at low temperatures, Pt enhances the rate of Pd sintering (which otherwise would be stable as an oxide), while at higher temperature Pd helps to slow the rate of Pt sintering. DFT calculations show that the barrier for atom emission to the vapor phase is much greater than the barrier for emitting atoms to the support. Hence, vapor-phase transport becomes significant only at high temperatures while diffusion of adatoms on the support dominates at lower temperatures.
The effect of Zn on the CO adsorption and oxidation reaction is examined experimentally and theoretically on two PdZn catalysts with different compositions, namely the intermetallic 1:1 β-PdZn and α-PdZn as a solid solution of 9 at% Zn in Pd. These bimetallic catalysts, made using an aerosol derived method, are homogeneous in phase and composition so that the measured reactivity excludes support effects. Both specific reactivities for CO oxidation on these two PdZn catalysts were measured. It was found that the initial rates are high and different between these catalysts, presumably due to the weakening of the CO adsorption and easier binding of oxygen to Pd sites modified by Zn. However, the rates decrease with time and become comparable to that on Pd at the steady state. With the help of density functional theory, it was suggested that the transient kinetics are due to the oxidation of Zn during the catalysis, which yields pure Pd where the reaction takes place.
scite is a Brooklyn-based organization that helps researchers better discover and understand research articles through Smart Citations–citations that display the context of the citation and describe whether the article provides supporting or contrasting evidence. scite is used by students and researchers from around the world and is funded in part by the National Science Foundation and the National Institute on Drug Abuse of the National Institutes of Health.
hi@scite.ai
10624 S. Eastern Ave., Ste. A-614
Henderson, NV 89052, USA
Copyright © 2024 scite LLC. All rights reserved.
Made with 💙 for researchers
Part of the Research Solutions Family.