Response surface methodology was used to optimize starter culture concentration (3–7%), pigeon pea–soy solids ratio (1 : 0.3–1 : 1.1), pigeon pea–water ratio (1 : 12–1 : 9), incubation temperature (37–45C) and coagulation temperature (75–95C) in the development of a cheese analogue from pigeon pea and soy milk. Pigeon pea milk and soy milk were prepared by a hot water grinding method, followed by filtration and inoculation. Cheese analogue was obtained through coagulation of the fermented milk by boiling for 15 min, followed by filtration using double‐layered muslin cloth and pressing at 1 kg/cm 2 pressure for 1 h. The results showed that the total solids recovery (TSR), protein content, fat content and pH varied from 51.09–62.61%, 40.04–55.93%, 9.35–15.36% and 4.48–4.9, respectively, depending on the experimental conditions. The optimum conditions of process parameters for maximum total solids recovery were 6.0% starter culture concentration, 1 : 0.4 pigeon pea–soy solids ratio, 1 : 11 pigeon pea–water ratio, 40.5C incubation temperature and 88.5C coagulation temperature.

Enzymatic treatment process for starch extraction from potato was investigated using cellulase enzyme and compared with conventional process. The effects of three parameters, cellulase enzyme concentration, incubation time and addition of water were evaluated for increase in starch yield as compared to the conventional process i.e., without using enzyme. A two-level full factorial design was used to study the process. The results indicated that all the main parameters and their interactions are statistically significant. Enzyme concentration and incubation time had a positive effect on the increase in starch yield while addition of water had a negative effect. The increase in starch yield ranged from 1.9% at low enzyme concentration and incubation time and high addition of water to a maximum of 70% increase from conventional process in starch yield was achieved when enzyme concentration and incubation time were high and addition of water was low suggesting water present in the ground potato meal is sufficient for access to the enzyme with in the slurry ensuring adequate contact with the substrate.