Most studies evaluating the use of essential oils (EO) as antibacterial agents focus mainly on minimal inhibitory concentrations (MIC) rather than minimal bactericidal concentrations (MBC). In this work, we compared MICs and MBCs of EO from condiment plants commonly used in Mediterranean Europe, namely ,, , and , aiming to evaluate their application as disinfecting agents in minimally processed produce. Outbreaks-related pathogens such as, and were used. Results showed that all EO were able to reduce bacterial growth in all bacterial strains tested, particularly . However, fewer EO exhibited bactericidal activities, and were only effective against one or two bacterial strains, hence eliminating the possibility to use them as broad range disinfectants. Furthermore, the necessary concentrations were too high for food application. Hence, our work suggests the need to evaluate MBC rather than MIC and questions EO usefulness in controlling undesired microorganisms. Overall, and despite the large volume of data published on EO, results obtained were not very encouraging for a realistic application on produce and question the viability of EOs as disinfecting agents in food.

Consumption of vegetables is increasing due to demand for healthy products in peoples' diets. To reduce microbial contamination and maintain freshness, industrial processes in Portugal rely on minimally processing of vegetables with hypochlorite as sanitizer. Formation of toxic chlorine derivatives has raised concern restrictions to its use and alternatives with whey permeate as a disinfection agent has been attempted. The aim of this work was to evaluate the bio potential of fermented cheese whey, for use on disinfection of minimally processed lettuce organically grown. Assays were made with whey obtained from inoculated milk during cheese processing, fermented for 120 h at 37 C, after which, among other carbohydrates, lactic acid was measured by HPLC, giving average yields of 18 g L À1. The sanitizing effect of whey, undiluted, 75 and 50% solutions, was compared with 110 ppm sodium hypochlorite, after rinsing. Aerobic Microorganisms (AM), Psychrotrophic Microorganisms (PM) and Enterobacteriaceae (ENT), were used as indicators for hygiene quality. For a level of significance of P < 0.05, the hygiene quality standards of lettuce samples, were better using 75% whey solution (AM 6.62, PM 7.48 cfu g À1), than using sodium hypochlorite (AM 7.48, PM 8.15 cfu g À1), for the 7 days of shelf life studied. Evaluation of Enterobacteriaceae showed significant differences after 3 days, between water (ENT 4.98 cfu g À1) sodium hypochlorite (ENT 4.81 cfu g À1) and 75% solution of whey (ENT 4.63 cfu g À1). Considering the actual limitations imposed to chlorine sanitation, these results point a good alternative to the food industry, especially for organic fresh vegetables, which are chemical free brands.

Cheese whey has been described as an environmental hazard due to its high organic content. Although it has been suggested that whey can be used as food disinfectant, it continues to pose an environmental problem because it still contains a high organic load. Here, we aimed to develop a low-cost, scalable fermentation protocol to produce a disinfectant from dairy waste that has very little organic content and high levels of lactic acid. Fermentation was achieved with industrial whey from ewe, goat, and cow’s milk, using a specific mesophilic-lactic acid bacteria starter mix over 120 h, which yielded the highest lactic acid production and the lowest lactose content. Antibacterial activity was observed against Listeria monocytogenes, Salmonella enterica, and Escherichia coli O157:H7, plus a total of thirteen other food pathogenic and spoilage strains, and antibacterial activities were determined to be highest after 120 h. We further validated this whey’s application as a disinfectant in shredded lettuce and compared its efficacy to that of chlorine, evaluating microbial quality, texture, color, and sensory perception, pH, and O2 and CO2 determinations. Results showed that not only was microbial quality better when using our whey solution (p < 0.05), but also the quality indicators for whey were statistically similar to those treated with chlorine. Hence, our work validates the use of an industrial waste whey as a low-cost, efficient, and environmentally safe disinfectant, with potential applications for minimally processed foodstuffs as an alternative to chlorine.