Transient chlorine concentration profiles were measured in biofilms during disinfection by use of a microelectrode developed for this investigation. The electrode had a tip diameter of ca. 10 microm and was sensitive to chlorine in the micromolar range. The biofilms contained Pseudomonas aeruginosa and Klebsiella pneumoniae. Chlorine concentrations measured in biofilms were typically only 20% or less of the concentration in the bulk liquid. Complete equilibration with the bulk liquid did not occur during the incubation time of 1 to 2 h. The penetration depth of chlorine into the biofilm and rate of penetration varied depending on the measurement location, reflecting heterogeneity in the distribution of biomass and in local hydrodynamics. The shape of the chlorine profiles, the long equilibration times, and the dependence on the bulk chlorine concentration showed that the penetration was a function of simultaneous reaction and diffusion of chlorine in the biofilm matrix. Frozen cross sections of biofilms, stained with a redox dye and a DNA stain, showed that the area of chlorine penetration overlapped with nonrespiring zones near the biofilm-bulk fluid interface. These data indicate that the limited penetration of chlorine into the biofilm matrix is likely to be an important factor influencing the reduced efficacy of this biocide against biofilms as compared with its action against planktonic cells.

No abstract

Biofilm bacteria challenged with monochloramine retained significant respiratory activity, even though they could not be cultured on agar plates. Microbial colony counts on agar media declined by approximately 99.9% after 1 h of disinfection, whereas the number of bacteria stained by a fluorescent redox dye experienced a 93% reduction. Integrated measures of biofilm respiratory activity, including net oxygen and glucose utilization rates, showed only a 10 to 15% reduction. In this biofilm system, measures of microbial respiratory activity and

The influence of biofilm areal cell density, species composition, and the presence of abiotic particles on the disinfection and removal of bacterial biofilms by monochloramine was investigated. Mono- and binary population biofilms of Pseudomonas aeruginosa and Klebsiella pneumoniae were grown on stainless-steel slides in a continuous flow annular reactor. Biofilms were treated in the reactor with a pulse/step dose of 4 mg/L monochloramine for 2 h. Biofilm samples were disaggregated and assayed for colony formation on R2A agar and for total cell numbers by acridine orange direct counts. These data were used to determine apparent first order rate coefficients for the processes of disinfection and detachment. Disinfection rate coefficients exceeded detachment rate coefficients by as much as an order of magnitude and the two coefficients were poorly correlated (r = 0.272). The overall decay rate coefficient (disinfection plus detachment) depended strongly on the initial biofilm areal cell density. It displayed a parabolic dependence on cell density with a maximum near 10(8) cfu/cm(2). This result points to multiple factors influencing biofilm susceptibility to antimicrobial challenge. Decay rates of K. pneumoniae measured in binary population biofilms were comparable with those measured in monopopulation biofilms (p = 0.61). P. aeruginosa decayed more slowly in biofilm dominated by K. pneumoniae (p = 0.028), indicating some interaction between species. The presence of kaolin and calcium carbonate particles in the biofilm reduced disinfection efficacy.

No abstract