This study aimed to determine the in vitro degradability of dry matter and the total gas production of oil seed press cake from biodiesel production (Gossypium hirsutum L., Helianthus annuus L., Ricinus communis, Moringa oleífera L. and Pinhão manso curcas L.) at four different levels of replacement (0, 30, 50, and 70%) for cane sugar (Saccharum officinarum RB.) in ruminant feed. Inocula were prepared using the ruminal fluid of three Holstein cows, and data were collected after 48 hours of incubation. The byproducts of Moringa had the highest degradability, and castor presented the lowest values at all evaluated levels of replacement. Castor bean byproduct showed the highest total gas production, cotton showed the lowest production, and the byproduct of Moringa at the 70% level showed the best ruminal fermentation results. These results demonstrate that the use of oil seed press cake from biodiesel production (Helianthus annuus L. and Ricinus communis) can replace cane sugar in ruminant feed.
ABSTRACT. This study aimed to evaluate the in vitro degradation and total gas production of different oil seed press cakes from a biodiesel production chain gas through the use of a semi-automatic technique of gas production in vitro. The treatments consisted of substituting elephant grass in increasing levels, 0%, 30, 50 and 70%, with the byproducts of Gossyypium hirsutum, Ricinus communis, Moringa oleifeira, Jatropha curcas and Helianthus annus. The oil seed press cakes of Moringa oleifeira had the highest rate of in vitro degradation of dry matter compared with other foods but did not result in a higher final volume of gases production. Gossyypium hirsutum, Pinhão manso curcas and Ricinus communis showed a higher in vitro degradability of similar dry matter. The highest total gas production was obtained by the oil seed press cakes of Helianthus annus. The oil seed press cakes of Moringa oleifeira can replace elephant grass up to 70% and therefore reduce both greenhouse gas emissions and energy loss for the animal.
RESUMOObjetivou-se avaliar a degradação e a produção de gás de diferentes fontes proteicas geradas na cadeia produtiva do biodiesel em substituição à silagem de milho. Os tratamentos foram: coprodutos de Gossyypium hirsutum, Ricinus communis, Moringa oleifera, Jatropha curcas, Helianthus annus. Os produtos foram analisados mediante a técnica semiautomática de produção de gases in vitro. O coproduto da moringa apresentou maior taxa de degradação, quando comparado aos demais alimentos, porém apresentou baixa produção de gás e se tornou mais eficiente, sendo, portanto, indicado como o melhor nível (27,06%) de substituição à silagem de milho. O coproduto da mamona e o do algodão produziram a maior quantidade de gás em 48h de incubação. Todos os coprodutos estudados podem ser utilizados na dieta de ruminantes como alimento proteico até 30% de substituição à silagem de milho.Palavras-chave: coprodutos do biodiesel, produção de gás, rúmen, taxa de degradação ABSTRACTThis study aimed to assess the degradation and gas production of different protein sources generated in the biodiesel production chain replacing corn silage. The treatments were byproducts Gossyypium hirsutum, Ricinus communis, Moringa oleifeira, Jatrophacurcas, and Helianthusannus. The products were analyzed by semi-automated technique of gas production in vitro. The coproduct moringa showed higher degradation rate compared to other foods, but showed low gas production, making it more efficient, being nominated as the best level of 27.06% by replacing corn silage. The byproducts of castor oil and cottonseed produced the largest amount of gas in 48 h of incubation. All studied byproducts can be used in the diet of ruminants as a protein food up to 30% by substitution of corn silage.
SUMMARY The aim of the study was evaluate the production potential for methane (CH4) and carbon dioxide (CO2), short-chain fatty acids, ammonia nitrogen (N-NH3) and pH by semi-automated techniquein vitro from biodiesel byproducts cottonseed cake (Gossypium hirsutum), castor bean (Ricinus communis), moringa cake (Moringa oleifera), jatropha cake (Jatropha curcas) and sunflower cake (Helianthus annuus) substituting corn silage in increasing levels, 0, 30, 50 and 70%. The experimental design used was completely randomized in a 5 x 4 factorial arrangement (byproducts and substitution levels). The inoculum for the in vitro incubations was obtained from three Holstein cows with rumen fistulas. In the experiment, the conditions were verified for the differences in potential gas production among the ingredients. The byproduct of cotton was the ingredient with the greatest potential to produce acetate, butyrate, CO2 and CH4. The byproduct of moringa had the lowest potential for the production of acetate, butyrate, CO2 and CH4 from in vitro degraded dry matter and a greater potential for the production of propionate. Among the byproducts studied, moringa was distinguished for promoting mitigation of CH4 and obtaining levels of pH and N-NH3 satisfactory for maximum rumen fermentation; thus, it is recommended the byproduct of moringa to replace corn silage because reduces environmental impact without impairingin vitro rumen fermentation.
scite is a Brooklyn-based organization that helps researchers better discover and understand research articles through Smart Citations–citations that display the context of the citation and describe whether the article provides supporting or contrasting evidence. scite is used by students and researchers from around the world and is funded in part by the National Science Foundation and the National Institute on Drug Abuse of the National Institutes of Health.
hi@scite.ai
10624 S. Eastern Ave., Ste. A-614
Henderson, NV 89052, USA
Copyright © 2024 scite LLC. All rights reserved.
Made with 💙 for researchers
Part of the Research Solutions Family.