Polyvinylidene fluoride (PVDF) membranes were exposed vertically to a high energy electron beam (EB) in air, at room temperature. The chemical changes were examined by Fourier Transform Infrared Spectroscopy (FTIR). The surface morphologies were studied by Scanning Electron Microscopy (SEM) and showed some changes in the pore size. Thermogravimetric (TGA) analysis represented an increase in the thermal stability of PVDF due to irradiation. Electron paramagnetic resonance (EPR) showed the presence of free radicals in the irradiated PVDF. The effect of EB irradiation on the electrical properties of the membranes was analyzed in order to determine the dielectric constant, and an increase in the dielectric constant was found on increasing the dose. The surface hydrophilicity of the modified membrane was characterized by water contact angle measurement. The contact angle decreased compared to the original angle, indicating an improvement of surface hydrophilicity. Filtration results also showed that the pure water flux (PWF) of the modified membrane was lower than that of the unirradiated membrane.
International audienceNonpercolated composites based on polyurethane (PU) filled with low concentrations copper (Cu) powders of varying sizes were studied as electrostrictive materials for mechanical energy harvesting. The dispersion of the fillers within the polymeric matrix was investigated by scanning electron microscopy, and results showed a relatively homogeneous dispersion for the microsized fillers and the existence of agglomerates for their nanosized counterparts. Differential scanning calorimetry measurements displayed that there occurred no interaction between the polymeric matrix and the microsized fillers whereas the nanosized fillers slightly enhanced the glass transition of the soft segments of PU and significantly affected the recrystallization temperature. The dependence of the dielectric properties of the composites as a function of the filler volume fraction and filler size was investigated over a broad range of frequencies, showing an increase in the permittivity when fillers were used. This increase was more pronounced for the composites containing nanosized fillers. The measurement of the harvested current and of the harvested power also demonstrated an enhancement of the energy harvesting capability when nanofillers were employed. From the experimental data, it appeared that the electrostrictive coefficient Q was not proportional to the inverse ratio of the permittivity and the Young modulus for the studied composites. Finally, analytical modeling of the harvested current and of the harvested energy offered an accurate description of the experimental data
The poly(vinylidene fluoride-hexafluoropropylene) (P(VDF-HFP)) polymer based on electrostrictive polymers is essential in smart materials applications such as actuators, transducers, microelectromechanical systems, storage memory devices, energy harvesting, and biomedical sensors. The key factors for increasing the capability of electrostrictive materials are stronger dielectric properties and an increased electroactive β-phase and crystallinity of the material. In this work, the dielectric properties and microstructural β-phase in the P(VDF-HFP) polymer were improved by electrospinning conditions and thermal compression. The P(VDF-HFP) fibers from the single-step electrospinning process had a self-induced orientation and electrical poling which increased both the electroactive β-crystal phase and the spontaneous dipolar orientation simultaneously. Moreover, the P(VDF-HFP) fibers from the combined electrospinning and thermal compression achieved significantly enhanced dielectric properties and microstructural β-phase. Thermal compression clearly induced interfacial polarization by the accumulation of interfacial surface charges among two β-phase regions in the P(VDF-HFP) fibers. The grain boundaries of nanofibers frequently have high interfacial polarization, as they can trap charges migrating in an applied field. This work showed that the combination of electrospinning and thermal compression for electrostrictive P(VDF-HFP) polymers can potentially offer improved electrostriction behavior based on the dielectric permittivity and interfacial surface charge distributions for application in actuator devices, textile sensors, and nanogenerators.
scite is a Brooklyn-based organization that helps researchers better discover and understand research articles through Smart Citations–citations that display the context of the citation and describe whether the article provides supporting or contrasting evidence. scite is used by students and researchers from around the world and is funded in part by the National Science Foundation and the National Institute on Drug Abuse of the National Institutes of Health.