No abstract

The amount of nutrients that can be released from food products (i.e., nutrient in vitro bioaccessibility) is often studied as it is a starting point for investigating nutrient bioavailability, an indicator for the nutritional value of food products. However, the importance of mastication as a particle size reduction technique is poorly understood and is often neglected during in vitro procedures determining bioaccessibility. Therefore, the aim of the present work was to study the effect of mechanical breakdown on the β-carotene bioaccessibility of carrot samples, having different textural/structural characteristics (as a result of thermal processing). In the first part of this study, the all-E-β-carotene bioaccessibility of carrot particles of different sizes (ranging from cell fragments up to large cell clusters), generated from raw as well as from gently and intensely cooked carrot samples, was determined. In the second part of the study, the effect of human mastication on the particle size reduction of raw as well as of gently and intensely cooked carrot samples was investigated in order to allow identification and validation of a technique that could mimic mastication during in vitro procedures. Results showed a strong dependency of the all-E-β-carotene bioaccessibility on the particle size for raw and gently cooked carrots. After intense cooking, on the other hand, a considerable amount of all-E-β-carotene could be released from cell fragments (smaller than a cell) as well as from small and large cell clusters. Hence, the importance of mechanical breakdown, and thus also of (in vitro) mastication, is dependent on the carrot sample that is considered (i.e., the extent to which the carrot sample has been thermally processed prior to the particle size reduction). Structural changes occurring during mechanical and thermal processing are hereby key factors determining the all-E-β-carotene bioaccessibility. The average particle size distribution curves of raw and cooked carrots, which were chewed by 15 persons, could be mimicked by mixing 50 g of carrots using a Grindomix (Retsch) at 2500 rpm during 5 s. Based on this scientific knowledge, the identified in vitro mastication technique was successfully integrated in the in vitro digestion procedure determining the all-E-β-carotene bioaccessibility of carrot samples.

The effect of thermal processing (85-130 °C) on the stability and isomerization of β-carotene in both an olive oil/carrot emulsion and an olive oil phase enriched with carrot β-carotene was studied. During processing, degradation of total β-carotene took place. Initially, total β-carotene concentration decreased quickly, after which a plateau value was reached, which was dependent on the applied temperature. In the oil/carrot emulsion, the total β-carotene concentration could be modeled by a fractional conversion model. The temperature dependence of the degradation rate constants was described by the activation energy and was estimated to be 45.0 kJ/mol. In the enriched oil phase, less degradation took place and the results could not be modeled. Besides degradation, β-carotene isomerization was studied. In both matrices, a fractional conversion model could be used to model total isomerization and formation of 13-Z- and 15-Z-β-carotene. β-Carotene isomerization was similar in both the oil/carrot emulsion and enriched oil phase as the simultaneously estimated kinetic parameters (isomerization reaction rate constant and activation energy) of both matrices did not differ significantly. The activation energies of isomerization were estimated to be 70.5 and 75.0 kJ/mol in the oil/carrot emulsion and enriched oil phase, respectively.

Thermal processing affects the nutritional value of food products. The nutritional value is not only determined by the content but also by the bioaccessibility of nutrients. The present study was performed to gain detailed insight into the influence of thermal processing on the degradation, isomerization, and bioaccessibility of lycopene isomers in tomato pulp, without adding any other ingredient. The bioaccessibility, which is defined as the fraction of the nutrient that can be released from the food matrix, was measured using an in vitro method. The results demonstrated the rather high thermal stability of lycopene. Although a treatment at 140 °C induced isomerization, the contribution of cis-lycopene to the total lycopene content remained small. Results also confirmed that thermal processing as such can improve the in vitro bioaccessibility of lycopene in tomato pulp, but the improvement was only significant upon treatments at temperatures of 130 and 140 °C. At such intense process conditions, one should be aware of the negative effect on other quality and nutrient parameters. Possibilities of thermal processing as such to improve the nutritional value of tomato pulp (without the addition of other ingredients) thus looks rather limited.

No abstract

The effect of thermal processing on the stability of beta-carotene in carrot puree was investigated in a broad temperature range (80-150 degrees C). Heat induced changes in the stability of beta-carotene resulting in the conversion into its cis-isomers until an equilibrium state was reached after prolonged heating. By using nonlinear one-step regression analysis, the overall isomerization of all-trans-beta-carotene and the formation of individual cis-isomers could be modeled with a fractional conversion model. The Arrhenius equation was used to describe the temperature dependence of the reaction rate constants. As indicated by the low activation energies for all compounds (11 kJ mol(-1)), the isomerization rate constants showed little sensitivity toward the treatment temperature. The temperature dependence of the equilibrium concentration values after prolonged heating (C(f)) varied for the different compounds, but in all cases, a linear relation between the C(f) values and the treatment temperature could be noted. Although isomerization was observed as a result of thermal processing, it could be concluded that during industrially relevant heating processes, the retention of all-trans-beta-carotene in plain carrot puree was relatively high, which is most likely due to the presence of the protecting food matrix.

No abstract

No abstract