No abstract

Traditionally, safety and impact of failure concerns of lithium ion batteries have dealt with the field failure of single cells. However, large and complex battery systems require the consideration of how a single cell failure will impact the system as a whole. Initial failure that leads to the thermal runaway of other cells within the system creates a much more serious condition than the failure of a single cell. This work examines the behavior of small modules of cylindrical and stacked pouch cells after thermal runaway is induced in a single cell. Cylindrical cells are observed to be less prone to propagate owing to the limited contact between neighboring cells. The electrical connectivity is found to be impactful as the 10S1P cylindrical cell module did not show failure propagation through the module, while the 1S10P module had an energetic thermal runaway consuming the module minutes after the initiation failure trigger. Modules built using pouch cells conversely showed the impact of strong heat transfer between cells. In this case, a large surface area of the cells was in direct contact with its neighbors, allowing failure to propagate through the entire battery within 60-80 seconds for all configurations (parallel or series) tested.

Wear debris-induced osteolysis is a major cause of orthopaedic implant aseptic loosening, and various cell types, including macrophages, monocytes, osteoblasts, and osteoclasts, are involved. We recently showed that mesenchymal stem/osteoprogenitor cells (MSCs) are another target, and that endocytosis of titanium (Ti) particles causes reduced MSC proliferation and osteogenic differentiation. Here we investigated the mechanistic aspects of the endocytosis-mediated responses of MSCs to Ti particulates. Dose-dependent effects were observed on cell viability, with doses >300 Ti particles/cell resulting in drastic cell death. To maintain cell viability and analyze particle-induced effects, doses <300 particles/cell were used. Increased production of IL- 8, but not IL-6, was observed in treated MSCs, while levels of TGF-β, IL-1β, and TNF-α were undetectable in treated or control cells, suggesting MSCs as a likely major producer of IL-8 in the periprosthetic zone. Disruptions in cytoskeletal and adherens junction organization were also observed in Ti particles-treated MSCs. However, neither IL-8 and IL-6 treatment nor conditioned medium from Ti particle-treated MSCs failed to affect MSC osteogenic differentiation. Among other Ti particle-induced cytokines, only GM-CSF appeared to mimic the effects of reduced cell viability and osteogenesis. Taken together, these results strongly suggest that MSCs play both responder and initiator roles in mediating the osteolytic effects of the presence of wear debris particles in periprosthetic zones.