In this study, three epigallocatechin gallate glycosides were synthesized by the acceptor reaction of a glucansucrase produced by Leuconostoc mesenteroides B-1299CB with epigallocatechin gallate (EGCG) and sucrose. Each of these glycosides was then purified, and the structures were assigned as follows: epigallocatechin gallate 7-O-alpha-D-glucopyranoside (EGCG-G1); epigallocatechin gallate 4'-O-alpha-D-glucopyranoside (EGCG-G1'); and epigallocatechin gallate 7,4'-O-alpha-D-glucopyranoside (EGCG-G2). One of these compounds (EGCG-G1) was a novel compound. The EGCG glycosides exhibited similar or slower antioxidant effects, depending on their structures (EGCG > or = EGCG-G1 > EGCG-G1' > EGCG-G2), and also manifested a higher degree of browning resistance than was previously noted in EGCG. Also, EGCG-G1, EGCG-G1', and EGCG-G2 were 49, 55, and 114 times as water soluble, respectively, as EGCG.

Alkyl glucosides were synthesized by the reaction of Leuconostoc mesenteroides dextransucrase with sucrose and various alcohols. Alkyl alpha-D-glucosides were obtained with a yield of 30% (mol/mol) with primary alcohols, but secondary alcohols or tertiary alcohols gave yields below 5%. The optimal yield was 50% using 1-butyl alpha-D-glucoside with 0.9 M 1-butanol. The acceptor products of methanol or ethanol were confirmed as methyl alpha-D-glucopyranoside and ethyl alpha-D: -glucopyranoside via MALDI-TOF MS and NMR analysis. Thus, methyl or ethyl alpha-D-glucoside constituted half the emulsification activities of Triton X-100 as commercially available surfactants.

No abstract

A gene (lsd1) encoding dextranase from Lipomyces starkeyi KSM22 has been previously cloned, sequenced, and expressed in Saccharomyces cerevisiae. The gene consisting of 1,824 base pairs and encoding a protein of 608 amino acids was then cloned into and secretively expressed in Pichia pastoris under the control of the AOX1 promoter. The dextranase productivity of the P. pastoris transformant (pPIC9K-LSD1, 134,000 U/l) was approximately 4.2-fold higher than that of the S. cerevisiae transformant (pYLSD1, 32,000 U/l) cultured in an 8-l fermentor. Over 0.63 g/l of active dextranase was secreted into the medium after methanol induction. The dextranase of the P. pastoris transformant, as analyzed by SDS-PAGE and Western blotting, showed only one homogeneous band. This dextranase of the P. pastoris transformant showed a broad band near 73 kDa. Rabbit monoclonal antibodies against a synthetic LSD1 peptide mix also recognized approximately 73 kDa.