A total of 1,112 pigs (initial BW of 49.8 kg) were used in a 78-d study to evaluate the effects of 0, 5, 10, 15, or 20% dried distillers grains with solubles (DDGS) and sex on carcass fat quality of finishing pigs. All diets contained 6% choice white grease and were fed in 4 finishing phases (50 to 59, 59 to 82, 82 to 105, and 105 to 123 kg, respectively). The experiment was conducted in a commercial research finishing barn in southwestern Minnesota. There were 9 replicates of each dietary treatment, with 25 to 28 pigs per pen, and barrows and gilts were distributed equally in each pen. On d 57, the 3 heaviest barrows from each pen were visually selected, removed, and marketed, and a total of 6 pigs per treatment were selected randomly for fatty acid analysis. On d 78, the remaining pigs from each pen were individually tattooed and shipped to a pork processing plant. Jowl fat, backfat, and belly fat samples were collected from 1 barrow and 1 gilt chosen randomly from each pen and analyzed for fatty acid composition. Iodine value (IV) was calculated for diets and fat samples. Fat quality data were analyzed as a split plot with DDGS treatment as the whole plot and sex as the subplot. Concentrations of C18:2n-6, PUFA, and IV increased (linear, P = 0.02) with increasing DDGS in backfat, jowl fat, and belly fat in pigs marketed on d 57 and 78. In contrast, C18:1 cis-9 and MUFA concentrations decreased linearly (P = 0.05) in all 3 fat depots with increasing DDGS. For every 10% DDGS included in the diet, IV of backfat, jowl fat, and belly fat increased by 2.3, 1.6, and 2.2 g/100 g, respectively. In pigs slaughtered on d 78, there were no (P ≥ 0.10) sex × dietary DDGS interactions observed. Compared with barrows, gilts had greater (P < 0.05) C18:2n-6, PUFA, and PUFA:SFA ratio and lesser (P < 0.03) C14:0 concentrations in backfat and belly fat but not jowl fat. Gilts had greater (P = 0.03) belly fat IV than barrows, but there were no (P > 0.25) differences between gilts and barrows in backfat and jowl fat IV. In summary, feeding increasing amounts of DDGS linearly increased the IV of backfat, jowl fat, and belly fat in pigs. Although jowl fat was less responsive to increased DDGS than backfat and belly fat, pigs fed diets with 20% DDGS and 6% choice white grease exceeded the maximum jowl IV of 73 g/100 g set by some packing plants.

A total of 144 barrows and gilts (initial BW = 44 kg) were used in an 82-d experiment to evaluate the effects of dietary fat source and duration of feeding fat on growth performance, carcass characteristics, and carcass fat quality. Dietary treatments were a corn-soybean meal control diet with no added fat and a 2 × 4 factorial arrangement of treatments with 5% choice white grease (CWG) or soybean oil (SBO) fed from d 0 to 26, 54, 68, or 82. At the conclusion of the study (d 82), pigs were slaughtered, carcass characteristics were measured, and backfat and jowl fat samples were collected. Fatty acid analysis was performed, and iodine value (IV) was calculated for all backfat and jowl fat samples. Pigs fed SBO tended to have increased (P = 0.07) ADG compared with pigs fed CWG. For pigs fed SBO, increasing feeding duration increased (quadratic, P < 0.01) ADG and G:F. For pigs fed CWG, increasing feeding duration improved (quadratic, P < 0.01) G:F. For pigs fed SBO or CWG, increasing feeding duration increased carcass yield (quadratic, P < 0.04) and HCW (quadratic, P < 0.02). Dietary fat source and feeding duration did not affect backfat depth, loin depth, or lean percentage. As expected, barrows had greater ADG and ADFI (P < 0.01) and poorer G:F (P = 0.03) than gilts. Barrows also had greater last-rib (P = 0.04) and 10th-rib backfat (P < 0.01) and reduced loin depth and lean percentage (P < 0.01) compared with gilts. Increasing feeding duration of CWG or SBO increased (P < 0.10) C18:2n-6, PUFA, PUFA:SFA ratio, and IV in jowl fat and backfat. Pigs fed SBO had greater (P < 0.01) C18:2n-6, PUFA, PUFA:SFA ratio, and IV but decreased (P < 0.01) C18:1 cis-9, C16:0, SFA, and MUFA concentrations compared with pigs fed CWG in jowl fat and backfat. Barrows had decreased (P = 0.03) IV in jowl fat and backfat compared with gilts. In summary, adding SBO or CWG increased the amount of unsaturated fat deposited. Increasing feeding duration of dietary fat increases the amount of unsaturated fatty acids, which leads to softer carcass fat.

A total of 120 pigs (60 barrows and 60 gilts; TR4 × PIC 1050; 54.4 kg initial BW) were used in an 83-d study to evaluate the effects of added fat in corn- and sorghum-based diets on growth performance, carcass characteristics, and carcass fat quality. Treatments were arranged in a 2 × 3 factorial with grain source (corn or sorghum) and added fat (0, 2.5, or 5% choice white grease; CWG) as factors. There were 2 pigs (1 barrow and 1 gilt) per pen and 10 replicate pens per treatment. Pigs and feeders were weighed on d 14, 22, 39, 53, 67, and 83 to calculate ADG, ADFI, and G:F. At the end of the trial, pigs were slaughtered and jowl fat and backfat samples were collected and analyzed for fatty acid profile. No interactions were observed for growth performance. Pigs fed sorghum-based diets had greater (P < 0.01) ADG than pigs fed corn-based diets. Adding CWG improved (linear, P < 0.01) ADG. Pigs fed corn-based diets tended to have greater (P < 0.09) carcass yield, 10th-rib backfat, and percentage lean than pigs fed sorghum-based diets. Adding CWG increased (linear, P = 0.02) 10th-rib backfat, tended to increase (linear, P = 0.08) HCW, and tended to decrease (linear, P = 0.07) percentage lean. There was no grain source × fat level interaction for iodine value (IV) in backfat, but an interaction (P = 0.03) was observed for IV in jowl fat. Adding CWG increased (P < 0.01) IV in jowl fat for pigs fed sorghum- and corn-based diets; however, the greatest increase was between 0 and 2.5% CWG in sorghum-based diets and between 2.5 and 5% CWG in corn-based diets. Pigs fed corn-based diets had less (P = 0.01) C18:1 cis-9 and MUFA but greater (P = 0.01) C18:2n-6, PUFA, and backfat IV than pigs fed sorghum-based diets. Increasing CWG in the diet increased (linear, P = 0.01) backfat IV. Of the 2 fat depots, backfat generally had a reduced IV than jowl fat. In summary, feeding sorghum-based diets reduced carcass fat IV and unsaturated fats compared with corn-based diets. As expected, adding CWG increased carcass fat IV regardless of the cereal grain in the diet.

Effects of increasing glycerol and dried distillers grains with solubles on the Effects of increasing glycerol and dried distillers grains with solubles on the growth performance and carcass characteristics of finishing pigs growth performance and carcass characteristics of finishing pigs

Brand names appearing in this publication are for product identification purposes only. No endorsement is intended, nor is criticism implied of similar products not mentioned. K-State Research and Extension is an equal opportunity provider and employer. Follow this and additional works at: https://newprairiepress.org/kaesrr Part of the Other Animal Sciences Commons Recommended Citation Recommended Citation Jacela, J Y.; Benz, J M.; Prusa, K J.; Tokach, Michael D.; DeRouchey, Joel M.; Goodband, Robert D.; Nelssen, Jim L.; and Dritz, Steven S. (2009) "Effect of dried distillers grains with solubles withdrawal regimens on finishing pig performance and carcass characteristics," Kansas Agricultural Experiment Station Research Reports: Vol. 0: Iss Abstract AbstractA total of 962 pigs (PIC L337 Ã-1050, initial BW = 86.1 lb) were used to determine the effect of dried distillers grains with solubles (DDGS) withdrawal regimens on growth performance and carcass traits. Pigs were randomly assigned to 1 of 6 treatments (6 pens per treatment) balanced by average BW within gender. Treatments were: (1) a corn-soybean meal-based diet without DDGS fed for 89 d (control), (2) 30% DDGS fed from d 0 to 48 and 0% DDGS fed from d 48 to 89, (3) 30% DDGS fed from d 0 to 69 and 0% DDGS fed from d 69 to 89, (4) 30% DDGS fed from d 0 to 48 and 15% DDGS fed from d 48 to 89, (5) 30% DDGS fed from d 0 to 69 and 15% DDGS fed from d 69 to 89, and (6) 30% DDGS diet fed from d 0 to 89. All diets contained 3% added fat. Pig BW, ADG, ADFI, and F/G were determined every 14 d. At the end of the trial, carcass fat quality was evaluated. There were no treatment Ã-gender interactions (P > 0.21) for any criteria evaluated. Although there were some differences in F/G within phases, there were no overall differences (P > 0.35) in growth performance among treatments. Final weight numerically decreased as total DDGS level increased. Feeding continuously or withdrawing DDGS from the diet, regardless of the amount or duration, had no significant effect (P > 0.39) on any of the carcass criteria measured. Pigs fed DDGS had increased (P < 0.01) iodine value of fat depots compared with control pigs. When the DDGS withdrawal duration increased (Treatments 6, 3, 2, and 1), iodine values for all fat depots decreased (linear; P < 0.01). Feed cost per pig was highest (P < 0.05) when 0% DDGS was fed or withdrawn 6 wk before marketing (Treatments 1 and 2) and lowest when DDGS was added in the diets until at least 3 wk before marketing (Treatments 3, 4, 5, and 6). However, the reduction in feed cost did not significantly improve (P > 0.57) revenue or income over feed cost. In summary, DDGS reduction or withdrawal 3 or 6 wk before market did not affect growth performance or totally alleviate its negative effect on carcass fat iodine value.; Swine Day, Manhattan, KS, Summary A total of 962 pigs (PIC L337 × 1050, initial BW = 86.1 lb) were used to determine the effect of dried distillers grains with solubles (DDGS) withdrawal regimens on growth performance and carcass traits....