Effective new therapies and mechanisms have been developed for the targeting and prevention of iron overload and toxicity in thalassaemia and idiopathic haemochromatosis patients. A new era in the development of chelating drugs began with the introduction of deferiprone or L1, which as a monotherapy or in combination with deferoxamine can be used universally for effective chelation treatments, rapid iron removal, maintenance of low iron stores and prevention of heart and other organ damage caused by iron overload. Several experimental iron chelators such as deferasirox (4-[3,5-bis (2-hydroxyphenyl)-1,2,4-triazol-1-yl]-benzoic acid) or ICL670, deferitrin (4,5-dihydro-2- (2,4-dihydroxyphenyl)-4-methylthiazole-4 (S)-carboxylic acid) or GT56-252, 1-allyl-2-methyl-3-hydroxypyrid-4-one or L1NAll and starch deferoxamine polymers have reached different stages of clinical development. The lipophilic ICL670, which can only be administered once daily is generally ineffective in causing negative iron balance but is effective in reducing liver iron. It is suspected that it may increase iron absorption and the redistribution of iron from the liver to the heart and other organs. The experimental iron chelators do not appear to have significant advantages in efficacy and toxicity by comparison to deferiprone, deferoxamine or their combination. However, the prospect of combination therapies using deferiprone, deferoxamine and new chelators will provide new mechanisms of chelator interactions, which may lead to higher efficacy and lower toxicity by comparison to monotherapies. A major disadvantage of the experimental chelators is that even if they are approved for clinical use, they are unlikely to be as inexpensive as deferiprone and become available to the vast majority of thalassaemia patients, who live in developing countries.

The prevalence rate of thalassemia, which is endemic in Southeast Asia, the Middle East, and the Mediterranean, exceeds 100,000 live births per year. There are many genetic variants in thalassemia with different pathological severity, ranging from a mild and asymptomatic anemia to life-threatening clinical effects, requiring lifelong treatment, such as regular transfusions in thalassemia major (TM). Some of the thalassemias are non-transfusion-dependent, including many thalassemia intermedia (TI) variants, where iron overload is caused by chronic increase in iron absorption due to ineffective erythropoiesis. Many TI patients receive occasional transfusions. The rate of iron overloading in TI is much slower in comparison to TM patients. Iron toxicity in TI is usually manifested by the age of 30–40 years, and in TM by the age of 10 years. Subcutaneous deferoxamine (DFO), oral deferiprone (L1), and DFO–L1 combinations have been effectively used for more than 20 years for the treatment of iron overload in TM and TI patients, causing a significant reduction in morbidity and mortality. Selected protocols using DFO, L1, and their combination can be designed for personalized chelation therapy in TI, which can effectively and safely remove all the excess toxic iron and prevent cardiac, liver, and other organ damage. Both L1 and DF could also prevent iron absorption. The new oral chelator deferasirox (DFX) increases iron excretion and decreases liver iron in TM and TI. There are drawbacks in the use of DFX in TI, such as limitations related to dose, toxicity, and cost, iron load of the patients, and ineffective removal of excess iron from the heart. Furthermore, DFX appears to increase iron and other toxic metal absorption. Future treatments of TI and related iron-loading conditions could involve the use of the iron-chelating drugs and other drug combinations not only for increasing iron excretion but also for preventing iron absorption.

Iron is essential for all human cells as well as neoplastic cells and invading microbes. Natural and synthetic iron chelators could affect biological processes involving iron and other metal ions in health and disease states. Iron overload is the most common metal toxicity condition worldwide. There are currently two iron chelating drugs, which are mostly used for the treatment of thalassaemia and other conditions of transfusional iron overload. Deferoxamine was until recently the only approved iron chelating drug, which is effective but very expensive and administered parenterally resulting in low compliance. Deferiprone (L1 or 1,2-dimethyl-3-hydroxypyrid-4-one) is the world's first and only orally active iron chelating drug, which is effective and inexpensive to synthesise thus increasing the prospects of making it available to most thalassaemia patients in third world countries who are not currently receiving any form of chelation therapy. Deferiprone has equivalent iron removal efficacy and comparable toxicity to deferoxamine. There are at least four other known iron chelators, which are currently being developed. Even if successful, these are not expected to become available for clinical use in the next five years and to be as inexpensive as deferiprone. The variation in the chemical, biological, pharmacological, toxicological and other properties of the chelating drugs and experimental chelators provide evidence of the difference in the mode of action of chelators and the need to identify and select molecular structures and substituents based on structure/activity correlations for specific pharmacological activity. Such information may increase the prospects of designing new chelating drugs, which could be targeted and act on different tissues, organs, proteins and iron pools that play important role not only in the treatment of iron overload but also in other diseases of iron and other metal imbalace and toxicity including free radical damage. Chelating drugs could also be designed, which could modify the enzymatic activity of iron and other metal containing enzymes, some of which play a key role in many diseases such as cancer, inflammation and atherosclerosis. Other applications of iron chelating drugs could involve the detoxification of toxic metals with similar metabolic pathways to iron such as Al, Cu, Ga, In, U and Pu.

Deferiprone is the only orally active iron-chelating drug to be used therapeutically in conditions of transfusional iron overload. It is an orphan drug designed and developed primarily by academic initiatives for the treatment of iron overload in thalassaemia, which is endemic in the Mediterranean, Middle East and South East Asia and is considered an orphan disease in the European Union and North America. Deferiprone has been used in several other iron or other metal imbalance conditions and has prospects of wider clinical applications. Deferiprone has high affinity for iron and interacts with almost all the iron pools at the molecular, cellular, tissue and organ levels. Doses of 50-120 mg/kg/day appear to be effective in bringing patients to negative iron balance. It increases urinary iron excretion, which mainly depends on the iron load of patients and the dose of the drug. It decreases serum ferritin levels and reduces the liver and heart iron content in the majority of chronically transfused iron loaded patients at doses >80 mg/kg/day. It is metabolised to a glucuronide conjugate and cleared through the urine in the metabolised and a non-metabolised form, usually of a 3 deferiprone: 1 iron complex, which gives the characteristic red colour urine. Peak serum levels of deferiprone are observed within 1 hour of its oral administration and clearance from blood is within 6 hours. There is variation among patients in iron excretion, the metabolism and pharmacokinetics of deferiprone. Deferiprone has been used in more than 7500 patients aged from 2-85 years in >50 countries, in some cases daily for >14 years. All the adverse effects of deferiprone are considered reversible, controllable and manageable. These include agranulocytosis with frequency of about 0.6%, neutropenia 6%, musculoskeletal and joint pains 15%, gastrointestinal complains 6% and zinc deficiency 1%. Discontinuation of the drug is recommended for patients developing agranulocytosis. Deferiprone is of similar therapeutic index to subcutaneous deferoxamine but is more effective in iron removal from the heart, which is the target organ of iron toxicity and mortality in iron-loaded thalassaemia patients. Deferiprone is much less expensive to produce than deferoxamine. Combination therapy of deferoxamine and deferiprone has been used in patients not complying with subcutaneous deferoxamine or experiencing toxicity or not excreting sufficient amounts of iron with use of either drug alone. New oral iron-chelating drugs are being developed, but even if successful these are likely to be more expensive than deferiprone and are not likely to become available in the next 5-8 years. About 25% of treated thalassaemia patients in Europe and more than 50% in India are using deferiprone. For most thalassaemia patients worldwide who are not at present receiving any form of chelation therapy the choice is between deferiprone and fatal iron toxicity.

Iron is essential for all living organisms. Many iron-containing proteins and metabolic pathways play a key role in almost all cellular and physiological functions. The diversity of the activity and function of iron and its associated pathologies is based on bond formation with adjacent ligands and the overall structure of the iron complex in proteins or with other biomolecules. The control of the metabolic pathways of iron absorption, utilization, recycling and excretion by iron-containing proteins ensures normal biologic and physiological activity. Abnormalities in iron-containing proteins, iron metabolic pathways and also other associated processes can lead to an array of diseases. These include iron deficiency, which affects more than a quarter of the world’s population; hemoglobinopathies, which are the most common of the genetic disorders and idiopathic hemochromatosis. Iron is the most common catalyst of free radical production and oxidative stress which are implicated in tissue damage in most pathologic conditions, cancer initiation and progression, neurodegeneration and many other diseases. The interaction of iron and iron-containing proteins with dietary and xenobiotic molecules, including drugs, may affect iron metabolic and disease processes. Deferiprone, deferoxamine, deferasirox and other chelating drugs can offer therapeutic solutions for most diseases associated with iron metabolism including iron overload and deficiency, neurodegeneration and cancer, the detoxification of xenobiotic metals and most diseases associated with free radical pathology.

Pharmacokinetic studies have been carried out with the oral iron chelator 1,2-dimethyl-3-hydroxypyrid-4-one (L1). HPLC analysis of serum of a normal volunteer and seven transfusional iron loaded patients who ingested a 3 gm dose of L1 revealed that L1 was most probably absorbed from the stomach and was transferred to the blood with a half-life of 0.7 to 32 minutes. L1 reached maximum concentration in the serum 12 to 120 minutes after administration with 85% to 90% elimination within the first 5 to 6 hours, with a half-life of 47 to 134 minutes. L1 and its glucuronide metabolite were identified in serum and urine but not in feces. In most cases hydrolysis of 24-hour urine samples with use of beta-glucuronidase resulted in almost complete recovery of the administered dose. Urinary iron excretion was proportional to the iron load but not to the serum or urine concentration of L1. The therapeutic efficiency of L1 can therefore be improved by repeated administration of 2 to 3 gm doses at least every 6 hours.

Iron chelating drugs are primarily and widely used in the treatment of transfusional iron overload in thalassaemia and similar conditions. Recent in vivo and clinical studies have also shown that chelators, and in particular deferiprone, can be used effectively in many conditions involving free radical damage and pathology including neurodegenerative, renal, hepatic, cardiac conditions and cancer. Many classes of phytochelators (Greek: phyto (φυτó)-plant, chele (χηλή)-claw of the crab) with differing chelating properties, including plant polyphenols resembling chelating drugs, can be developed for clinical use. The phytochelators mimosine and tropolone have been identified to be orally active and effective in animal models for the treatment of iron overload and maltol for the treatment of iron deficiency anaemia. Many critical parameters are required for the development of phytochelators for clinical use including the characterization of the therapeutic targets, ADMET, identification of the therapeutic index and risk/benefit assessment by comparison to existing therapies. Phytochelators can be developed and used as main, alternative or adjuvant therapies including combination therapies with synthetic chelators for synergistic and or complimentary therapeutic effects. The development of phytochelators is a challenging area for the introduction of new pharmaceuticals which can be used in many diseases and also in ageing. The commercial and other considerations for such development have great advantages in comparison to synthetic drugs and could also benefit millions of patients in developing countries.

No abstract