The aim of this study was to analyze the effect of pork backfat (PB) substitution in a meat burger with a gelled emulsion (GE) elaborated with maca flour, soybean oil, and chincho essential oil (CEO). Lipid profile (gas chromatography—GC), health indices, physicochemical properties (CIELAB color, pH, texture profile—TPA), and cooking and sensory characteristics of meat burgers were analyzed. Five formulations were evaluated: control (BC) (80% beef meat and 20% PB); BSM (10% PB + 10% GE); BSMC0.25 (BSM + 0.25% CEO); BSMC0.5 (BSM + 0.5% CEO), and BSMC1.0 (BSM + 1.0% CEO). GE substitution in meat burgers provided a healthier lipid profile; the amount of SFA was reduced (p < 0.05), while PUFA content was significantly increased (p < 0.05). Furthermore, the use of GE resulted in healthier PUFA/SFA ratios and lower atherogenic and thrombogenic indices. The addition of GE increased moisture content and decreased fat and protein contents. Color parameters (L*, b*, and C*) decreased after cooking. Hardness (p < 0.05), cooking losses, and shrinkage changes decreased with GE addition. Lipid oxidation levels were significantly (p < 0.05) affected by GE substitution. Therefore, the substitution of PB by GE can be considered as an effective strategy to produce healthier meat burgers without negatively affecting their physicochemical and technological properties.

The aim of this work was to obtain chitosan nanoparticles (<1000 nm) with chincho (Tagetes elliptica Sp.) essential oil (CEO-CSNPs) using the ionic gelation method. A Box–Behnken design (BBD) was applied, using chitosan solution (CS) pH (4.0, 4.4, 4.8); the mass ratio of CS/CEO (1:0.7, 1:0.85, 1:1.0) and the mass ratio of CS/CS-tripolyphosphate (1:0.46, 1:0.58, 1:0.7) as independent variables. The formulation-dependent variables, encapsulation efficiency (EE) and loading capacity (LC) of the CEO-CSNPs were evaluated. BBD determined that optimal conditions for CEO-CSNPs were pH: 4.4, CS/CEO mass ratio 1:0.7 and CS/TPP mass ratio 1:0.46. Once the optimization was defined, particle size (PS), zeta potential (ZP), polydispersity index (PDI), CEO-CSNPs morphological studies, in vitro CEO release, and antibacterial activity were determined. The CEO-CSNPs showed an EE of 52.64% and a LC of 11.56%, with a diameter of 458.5 nm, with a ZP of 23.30mV, and a PDI of 0.418. The SEM studies showed that the nanoparticles were rounded and had uniform shapes. In addition, CEO-CSNPs showed a minimum inhibitory concentration against Staphylococcus aureus, Salmonella infantis and Escherichia coli of 5.29, 10.57 and 10.57 µg/mL, respectively. These results could be very useful for the stabilization of chincho essential oil for food industry purposes. However, several studies about the release, as well as interaction with food matrices, will be necessary.

The chemical composition, antioxidant, and antibacterial properties of the essential oil from the leaves of Tagetes elliptica Sm., grown in Peru, were studied. The EO was extracted using steam distillation, and its chemical composition was analyzed using GC-MS, while the antioxidant activity was evaluated using the radical, scavenging capacity (DPPH and ABTS assays), and ferric reducing antioxidant power (FRAP) assays, ferrous ion chelating (FIC) activity, and the Rancimat test. The antibacterial activity against Staphylococcus aureus, Escherichia coli, and Salmonella infantis was studied using the agar well diffusion method. Twenty-seven compounds were identified in the essential oil, and the major components were cis-tagetenone (37.27%), trans-tagetenone (18.84%), dihydrotagetone (14.38%), and trans-tagetone (5.15%). With regard to antioxidant properties, the IC50 values obtained for the DPPH, ABTS, and FIC assays were 53.37, 46.38, and 22.65 mg/mL, respectively. These values were lower than those obtained for standard butylated hydroxytoluene and ascorbic acid. In the Rancimat test, antioxidant activity was achieved only at high concentration. T. elliptica essential oil showed a marked antibacterial activity against all bacterial strains at all concentrations assayed. This study demonstrated that T. elliptica essential oil could be considered as an alternative to synthetic antioxidants and antimicrobial agents in the food industry.