The aim of this work was to evaluate the effects on the chemical, physic-chemical, technological, and sensory properties of beef burger when replacing different quantities of fat (50 and 100%) with different levels of oil-in-water-gelled emulsion elaborated with walnut oil and cocoa bean shell flour (GECW). The chemical composition of the samples was affected by the fat replacement. The reformulation increased the moisture and ash content while the fat and protein content decreased with respect to the control sample. The linolenic and linolenic acid content of the beef burgers increased as the GECW replacement was augmented. The polyunsaturated fatty/saturated fatty acid ratio increased in both raw and cooked burgers, whereas the atherogenicity index and thrombogenicity index were reduced in both raw and cooked burgers with respect to the control sample. The use of GECW as a fat replacer was found to be effective in improving the cooking loss. Similarly, there were positive effects on reductions in the diameter and the increases in the thickness of the beef burgers. Regarding lipid stability, in both the raw and cooked burgers, the reformulation increased the 2-thiobarbituric acid reactive substance (TBARs) values with respect to the control sample. In both types of reformulated burgers, three bound polyphenols (mainly catechin and epicatechin) and two free polyphenols were identified, as were methylxanthines theobromine and caffeine. The sensory properties for the control and partial pork backfat replacement treatments were similar, while the sample with the total pork backfat replacement treatment showed the lowest scores. The blend of cocoa bean shell flour and walnut oil could be used as new ingredients for the development of beef burgers with a healthier nutritional profile without demeriting their sensory or cooking characteristics and physic-chemical properties.

The worldwide cocoa bean shell (CBS) generation is estimated at around 900,000 tons. In their composition, this coproduct showed several bioactive compounds like methylxanthines or polyphenolic compounds. Thus, the aim of this work was to investigate the effects of different particle sizes on the chemical composition, physico-chemical, bioactive compounds content, and antioxidant properties of flours obtained from cocoa (Theobroma cacao L.) bean shells. The flours obtained from CBS with different particle sizes had high content of dietary fiber (61.18–65.58 g/100 g). The polyphenolic profile identified seven compounds being epicatechin and catechin (values ranged 4.56–6.33 and 2.11–4.56 mg/g, respectively) as the most abundant compounds. Additionally, the methylxanthines theobromine and caffeine were quantified with values ranging from 7.12 to 12.77 and 4.02 to 6.13 mg/g, respectively. For the fatty acid profile, the principal compounds identified were oleic, stearic and palmitic acids. CBS had antioxidant capacity with all methods assayed. For DPPH, ABTS and FRAP assays values ranged between 2.35–5.53, 3.39–11.55, and 3.84–7.62 mg Trolox equivalents/g sample, respectively. This study suggests that cocoa bean shells may constitute a valuable coproduct for the food industry due to its high content in valuable bioactive compounds.

No abstract

Gelled emulsion (GE) systems are one of the novel proposals for the reformulation of meat products with healthier profiles. The aims of this research were (i) to develop gelled emulsions using pseudocereal flours (amaranth, buckwheat, teff, and quinoa) and vegetable oils (chia oil, hemp oil, and their combination), (ii) to determine their chemical composition, physicochemical properties, and lipid stability, and (iii) to evaluate their stability during frozen storage. The results showed that GEs are technologically viable except for the sample elaborated with teff flour and a mix of oils. The lipid oxidation was not greater than 2.5 mg malonaldehyde/kg of sample for any of the samples analyzed. The physicochemical properties analyzed showed both the pH and color values of the GEs within the range of values obtained for the fat of animal origin. The texture properties were affected by the type of oil added; in general, the firmness and the work of shear increased with the addition of the mixture of both oils. The samples elaborated with buckwheat and chia oil and quinoa and chia oil had the highest emulsion stability values, which remained among the highest after freezing. The results showed that gelled emulsions, based on chia oil, hemp, and their mixture with pseudocereal flours, are a viable alternative as a possible substitute of saturated fat in the development of novel foods.

The aims of this study were determined the chemical composition and the antioxidant properties of defatted flours obtained from several commercially available edible insects such as Acheta dosmesticus, Tenebrio molitor, Zophobas morio, and Rhynchophorus ferrugineus to establish their utilization as ingredient in the development of new food products. The proximate composition of flour was determined using AOAC methods while for antioxidant capacity, four different methodologies were employed (DPPH, ABTS, FIC, and FRAP). The total phenolic content and the tannin content were also determined. All flours analyzed had a high protein content with values ranging between 64.17 and 72.55 g/100 g flour. With regard to the antioxidant activity, R. ferrugineus showed the highest values for DPPH, ABTS, and FRAP assays with values of 2.03, 4.93, and 8.46 mg Trolox equivalent/g flour, respectively. For FIC assay, A. dosmesticus and T. molitor had the highest values 0.47 and 0.48 mg EDTA equivalent/g flour. Defatted flours obtained from edible insects analyzed could have several applications as ingredients to the development new foods due to its good nutrient content and as a functional food for the prevention of oxidation.

Vegetable soups and creams have gained popularity among consumers worldwide due to the wide variety of raw materials (vegetable fruits, tubers, bulbs, leafy vegetables, and legumes) that can be used in their formulation which has been recognized as a healthy source of nutrients (mainly proteins, dietary fiber, other carbohydrates, vitamins, and minerals) and bioactive compounds that could help maintain the body’s health and wellbeing. In addition, they are cheap and easy to preserve and prepare at home, ready to eat, so in consequence they are very useful in the modern life rhythms that modify the habits of current consumption and that reclaim foods elaborated with natural ingredients, ecologic, vegans, less invasive production processes, agroindustry coproducts valorization, and exploring new flavors and textures. This review focuses on the nutritional and healthy properties of vegetable soups and creams (depending on the raw materials used in their production) highlighting their content in bioactive compounds and their antioxidant properties. Apart from the effect that some processing steps could have on these compounds, innovation trends for the development of healthier soups and creams adapted to specific consumer requirements have also been explored.

Chia and quinoa have gained popularity among consumers worldwide due to the wide variety of nutrients but also to the bioactive compounds that they contain. Lately, their processing has generated different coproducts (non-commercial grains, flour, partially deoiled flour, rich-fiber fraction, and oil, among others), which could be reincorporated to the food chain with important technological properties, antioxidant activity included. Both sets of ingredients have been revealed a great technological potential for meat product development and innovation, taking into account that oxidation is one of the main reactions responsible for their deterioration and shelf life reduction. This review focuses on the antioxidant compounds of chia and quinoa coproducts and on the strategies used to add them to meat products highlighting their effect on the lipid oxidation control. Apart from the different ways in which quinoa and chia can be incorporated into meat products and their antioxidant properties, innovative approaches for increasing this antioxidant effect and counteracting any negative alterations they may cause will be discussed.

No abstract