In order to improve physical and chemical properties of dough produced from wheat flour of suboptimal quality (protein content 10.7% dry basis, dough energy 4.0 cm2), optimal doses of ascorbic and citric acid were evaluated using a response surface methodology and desirability function. The paper brings the analysis of the main effects as well as their interactions. The effect of organic acids was evident in relation to pH lowering and decrease in free thiol groups, which consequently changed the physical properties of dough (increased dough energy, extensibility and resistance). The well known oxidative effect of ascorbic acid which is manifested as increase in dough energy and resistance, was enhanced by the addition of citric acid i.e. their synergistic action. Contribution of citric acid was the donation of hydrogen ions which changed the pH, lowered the content of free -SH groups and increased protein aggregation. Ascorbic acid individually significantly increased energy (linear regression coefficient b1 = 4.010-4) but higher effect was exerted by the addition of ascorbic and citric acid mixture as seen through higher interaction regression coefficient (b12 = 0.076). Dough resistance was significantly affected only by ascorbic acid due to its oxidizing action whereas dough extensibility was affected by both acids (main effects) at all applied doses and their mixtures. The effect on dough extensibility depends on the dose of acids but resistance decreased with quadratic increase of acid doses. Second-order polynomials were used in modeling of responses (dough energy, resistance and extensibility) which showed a good fit with experimental data as shown by high values of the coefficients of determination R2 for energy, resistance and extensibility (0.953, 0.976 and 0.996, respectively). Based on F value, it could be concluded that the model gave good prediction of experimental data while p-values for all responses showed that the models were significant at significance of 90%. The obtained models were used to optimize the doses of ascorbic and citric acid in order to maximize dough energy and extensibility. Significant increase of dough energy by 4.7 times and extensibility by 1.5 times was achieved by the set of optimum conditions of 97 mg/kg citric and 100 mg/kg ascorbic acid. The obtained results are applicable in semi-industrial and industrial facilities for flour processing

Article Highlights• Dough and bread quality of substandard flour can be improved by using TG and L-AA • RSM was applied in the analysis of the individual and interactive effect of TG and L-AA • TG has more linear effect in the fermentation process, on the crumb quality than L-AA • L-AA has a much greater effect on the specific volume of bread than TG • Desirability function defines optimum dose of TG and L-AA for sample of flour substandard quality AbstractOver the past decade, extreme variations in climatic conditions have been observed, which in combination with inadequate agro techniques lead to decreased quality of mercantile wheat, i.e. flour. The application of improvers can optimise the quality of substandard wheat flour. This paper focuses on systematic analysis of individual and interaction effects of ascorbic acid and transglutaminase as dough strengthening improvers. The effects were investigated using response surface methodology. Transglutaminase had much higher linear effect on the rheological and fermentative properties of dough from substandard flour than L-ascorbic acid. Both transglutaminase and L-ascorbic acid additions had a significant linear effect on the increase of bread specific volume. Effects of transglutaminase and ascorbic acid are dependent on the applied concentrations and it is necessary to determine the optimal concentration in order to achieve the maximum quality of the dough and bread. Optimal levels of tested improvers were determined using appropriate statistical techniques, which applied the desirability function. It was found that the combination of 30 mg/kg of transglutaminase and 75.8 mg/kg of L-ascorbic acid achieved positive synergistic effects on rheological and fermentative wheat dough properties, as well on textural properties and specific volume of bread made from substandard quality flour.Keywords: substandard quality flour, transglutaminase, L-ascorbic acid, optimization.Over the past decade, an appreciable stagnation of quality and yield of mercantile wheat at the global, regional and local levels has occurred [1][2][3][4]. This phenomenon is the consequence of more

The effects of different concentrations of the complex additive containing emulsifiers, oxido-reductive substances and enzymes, on the rheological conditions of dough, and on the sensory properties of three groups of bread were investigated. The best initial quality and the lowest degree of protein network weakening had the dough obtained from mixed wheat and rye flours. The best expected baking properties were shown by the white wheat flour due to the least damage of its starch. The use of the additive has an effect on the absorption of water and on the majority of C-values of all sorts of flour. The amount of additive had a significant effect on the sensory properties of wheat bread crumb texture. Also, storage duration significantly affected (p <0.01) the sensory properties of integral wheat bread aroma-taste and the weighted mean score. The interaction of these two factors had no significant effect on any of sensory properties of the investigated groups of bread

ABSTRACT:The aim of this work was to improve the quality of gluten-free bread made with high content of soy flour and enriched with sugar beet molasses by incorporating ingredients with a potential to simultaneously enhance the nutritional quality of the breads. The following ingredients were used: pea protein isolate, pea fibre and chia seeds. The chosen ingredients exerted positive effects on bread quality. They promoted volume increase and crumb softening. In this respect, the most effective ingredients were pea protein isolate (at 1% supplementation level), pеа fibre (at up to 2% supplementation level) and chia seeds (at 1% supplementation level). The sensory analysis revealed that pea fibre and chia addition at 1 and 2% supplementation level provided bread with higher scores regarding overall acceptance, crumb texture and taste. At 1% supplementation level, there was not found statistically significant difference in sensory attributes of bread supplemented with pea protein isolate in comparison to the control. However, pea protein isolate was found to strongly diminish bread taste at 4% supplementation level due to presence of beany taste.

ABSTRACT:The objective of this study was to analyze the individual and synergistic effects of three enzyme preparations (transglutaminase, lipase and xylanase) on the viscoelastic properties of wheat dough made from flour of substandard quality. A response surface methodology using Box-Behnken experimental design was used to evaluate the effects on the dynamic and creep-recovery parameters of dough. The results confirmed that the strengthening effect were observed by transglutaminase and lipase addition. The storage modulus increased with transglutaminase and lipase addition applied in doses of 15 mg/kg to 30 mg/kg, whilst xylanase (applied in doses of 25-50 mg/kg) had no significant effect on dough storage modulus (G'). Significant interaction effects of transglutaminase and xylanase (P 0.1) increased the values of zero shear viscosity ( 0 ). The optimal levels of the tested enzymes were determined by the desirability function approach. It was found that the combined effect of 30.0 mg/kg of transglutaminase, 28.1 mg/kg of lipase and 38.6 mg/kg of xylanase achieved a positive synergistic effect on wheat dough viscoelasticity made from flour of substandard quality.

ABSTRACT:This work was focused on the performance of trained and untrained panel in evaluating the texture of nine commercially produced wheat spaghetti. Several sensory methods were applied in order to investigate the performance of different panel groups. In order to avoid the loss of information obtained by non-parametric methods, data were scaled according to contingency tables. This analysis showed that significant differences existed between the two panels for the given products. On the basis of these results, it can be concluded that the used panels cannot be a good alternative to each other in providing sensory texture profiling of commercial spaghetti, except in the case when the properties of spaghetti were evaluated using the control sample.

Puff pastry has delicate and flaky texture which comes from unique combination of fat and dough. These bakery products are made from many thin layers of dough which are separated by alternate fat layers because of which they are considered to be high fat food. Properties of puff pastry depend mostly on the quality of flour, which must be specifically tailored for this purpose. The most commonly used flour in the production of puff pastry is refined wheat flour. Lately, the requirements of consumers for healthy bakery products have a great response in the baking industry. On the market there are new products made with ingredients which have high nutritional value. This paper presents an optimization of the composition of puff pastry made of spelt flour by varying the amount of ingredients such as: margarine, ascorbic acid and enzyme transglutaminase. The optimal ratio of these ingredients has been based on the consideration of their major and interaction effects. During the optimization of spelt puff pastry quality, the following goals were set: maximum volume, minimum firmness and maximum overall acceptability. The optimal solutions were in the concentration range from 3.60 mg/kg to 10 mg/kg for ascorbic acid, from 0.03 mg/kg to 3 mg/kg for transglutaminase and from 29.84 to 30% for margarine on dough basis. It is recommended that the composition of spelt puff pastry involve: 10 mg/kg ascorbic acid, 0.03 mg/kg transglutaminase and 30 % margarine on dough basis to provide the desired product characteristics.

Different types of instant porridges have become a popular choice for breakfast, and it is known that breakfast is an important meal for daily appetite control. On our market there is porridge of uniform composition based on cereals, primarily oats. However, high-protein porridge is not available, which is a significant deficiency in the assortment of these products. In addition, insufficient intake of quality protein remains a dietary problem, particularly among children and the elderly, where diets consist mainly of cereals. Plant proteins in combination with cereals could be used to produce high protein instant porridge. In this study, proteins from legumes such as soybean and pea, specifically soy protein concentrate, soy protein isolate, and pea protein isolate were applied. Protein preparations were added to the main mixture composed of the buckwheat and corn extrudate and other additional ingredients. The protein preparations were added at three different levels: soy protein concentrate at 0, 7.5 and 15% (w/w main mixture basis) and soy protein isolate and pea protein isolate at 0, 15 and 30% (w/w main mixture bases), with the objective of optimizing the composition of the high-protein instant porridge. The aim of optimization was to maximize the protein content and overall acceptability. The optimal doses of protein preparations were determined using the method of desirability function and it was found that the optimized dose for the soy protein concentrate was 1.43 g/100 g, soy protein isolate 21.07 g/100 g and pea protein isolate 14.83 g/100 g. The prediction value for protein content was 24.77 %/DM and overall acceptability 4.09. The obtained experimental values were close to the prediction values: 24.32 %/DM for protein content and 4.41 for overall acceptability. The protein content of the formulated porridge was 24.32 %/DM, which is more than twice as high as that in the oat porridge present on the market. Based on standard nutritional values, the newly formulated high-protein instant porridge could be recommended as appropriate breakfast meal for adults.