No abstract

The effect of Spirulina (Arthrospira platensis), individually or in combination with two commercial carbohydrases, in piglet diets was assessed on growth performance, nutrient digestibility and meat quality traits. Forty post‐weaned male piglets from Large White × Landrace sows crossed with Pietrain boars with an initial live weight of 12.0 ± 0.89 kg were used. Piglets were assigned to one of four dietary treatments (n = 10): cereal and soya bean meal base diet (control), base diet with 10% Spirulina (SP), SP diet supplemented with 0.005% Rovabio® Excel AP (SP + R) and SP diet supplemented with 0.01% lysozyme (SP + L). Animals were slaughtered after a 4‐week experimental period. Growth performance was negatively affected by the incorporation of Spirulina in the diets, with an average decrease of 9.1% on final weight, in comparison with control animals. Total tract apparent digestibility (TTAD) of crude protein was higher (p < .05) in the control group than in other groups. In addition, lysozyme increased TTAD of crude fat and acid detergent fibre, relative to the SP and control groups, respectively. In addition, the incorporation of Spirulina, individually and supplemented with enzymes, did not impair meat quality traits. Surprisingly, no protective effect against lipid oxidation was observed with the inclusion of Spirulina in pork after 7 days of storage. This study indicates that growth performance of post‐weaning piglets was impaired by the incorporation of 10% Spirulina in the diets, which is mediated by an increase in digesta viscosity and a lower protein digestibility, as a consequence of the resistance of microalga proteins to the action of endogenous peptidases. In addition, it also indicates that lysozyme, in contrast to Rovabio® Excel AP, is efficient in the degradation of Spirulina cell wall in piglet's intestine. However, the digestion of proteins liberated by Spirulina cell wall disruption is still a challenge.

No abstract

Finishing Holstein young bulls exclusively on pasture generally results in very lean carcass and meat, but corn supplementation is expected to simultaneously improve carcass traits and intramuscular lipids (IML). The expected increase in IML would allow for a larger 18:2c9,t11 (CLA) deposition in meat without affecting the n-3 PUFA present in LM phospholipids (PL). Holstein bulls (n = 33) with initial BW of 423 ± 52.4 kg reared exclusively on pasture were assigned to 1 of 3 finishing period (85 d) diets: finished exclusively on pasture (P0) or finished on pasture and individually supplemented with 4 (P4) or 8 kg/d (P8) of ground corn. Final BW (546 ± 56.3 kg) was not affected (P> 0.05) by corn supplementation, but ADG increased (P < 0.01) with the increasing corn supplementation level from 1.23 kg/d for P0 to 1.44 kg/d for P4 and to 1.67 kg/d for P8. Subcutaneous fat depth in P0 bulls was 0.8 mm and increased (P < 0.001) in both P4 (2.9 mm) and P8 (2.7 mm) bulls, but no difference (P = 0.73) was observed between P4 and P8 bulls. Similarly, the IML increased with corn supplementation, from 1.84 g/100 g muscle in P0 to 2.96 in P4 and to 3.24 in P8, but no difference (P = 0.55) was found between P4 and P8 bulls. Corn supplementation decreased (P < 0.01) 18:1t11 in neutral lipids (NL) but not 18:2c9,t11 (P > 0.34). The 18:1t10 (mg/g total NL fatty acid [FA] ± SEM) were 2.5 ± 0.13 in P0, 5.5 ± 1.68 in P4, and 14.8 ± 3.18 in P8 bulls, being greater in P8 compared with P4 (P = 0.02). Total FA in muscle PL and SFA were unaffected, but increasing corn supplementation resulted (P < 0.001) in an increase of 18:2n-6 in PL by replacement of mostly the 18:1c9 and 18:3n-3. Notably, the total number of cis double bonds present in FA of PL remained constant (P = 0.74) with corn supplementation. Compared with P0, corn supplementation maintained (P > 0.05) the high n-3 PUFA content in meat (mg/100 g meat) and increased the 18:2c9,t11 (P = 0.028) and 18:1c9 (P < 0.001). However, increasing corn supplementation from 4 to 8 kg/d increased the 18:1t10 (P = 0.031) and had no effect on 18:2c9,t11. Therefore, supplementing grass-finished Holstein bulls with moderate amounts of ground corn (4 kg/d) increased carcass fat cover and IML, maintained n-3 PUFA, and increased 18:2c9,t11 content in meat, whereas greater corn supplementation (8 kg/d; P8) resulted in no further improvements.

In the present study, 199 pre-selected Carbohydrate-Active enZymes (CAZymes) and sulfatases were assessed, either alone or in combination, to evaluate their capacity to disrupt Laminaria digitata cell wall, with the consequent release of interesting nutritional compounds. A previously characterized individual alginate lyase, belonging to the family 7 of polysaccharide lyases (PL7) and produced by Saccharophagus degradans, was shown to be the most efficient in the in vitro degradation of L. digitata cell wall. The alginate lyase treatment, compared to the control, released up to 7.11 g/L of reducing sugars (p < 0.001) and 8.59 mmol/100 g dried alga of monosaccharides (p < 0.001), and reduced cell wall fluorescence intensity by 39.1% after staining with Calcofluor White (p = 0.001). The hydrolysis of gel-forming polymer alginate by the alginate lyase treatment could prevent the trapping of fatty acids and release beneficial monounsaturated fatty acids, particularly 18:1c9 (p < 0.001), to the extracellular medium. However, no liberation of proteins (p > 0.170) or pigments (p > 0.070) was observed. Overall, these results show the ability of an individual alginate lyase, from PL7 family, to partially degrade L. digitata cell wall under physiological conditions. Therefore, this CAZyme can potentially improve the bioavailability of L. digitata bioactive compounds for monogastric diets, with further application in feed industry.

The effect of high pressure processing (HPP), at different combinations of pressure and time, on dry fermented sausages (DFS) was evaluated by chemical, microbiological and sensory analyses. Lipid composition and stability were also assessed. HPP (N 400 MPa and longer than 154 s) produced a reduction in spoilage microbiota, without negative effect on fermentative microbiota, that will be able to continue their role. Total fatty acids and lipid stability were not affected. Only a small effect on fatty acid (FA) composition was observed. Nutritional value of the lipid fraction was only affected by the ratio n−6/n−3 FA. Treatments at 400 MPa for 154 s or 960 s resulted in DFS being detected as different from control by sensory analysis. Those differences did not depreciate the product; on the contrary it seems to improve the bright aspect of the whole sausage, the cohesion and firmness and the correctly dried aspect of slices. Industrial relevance: Dry fermented meat sausages are very popular ready-to-eat meat based products. This study assesses the effects of HPP on this much appreciated traditional products. The results showed that HPP can be successfully applied to these Mediterranean fermented products without losses of sensory and nutritional characteristics. The modelling and optimization of the HPP process applied on dry fermented sausages demonstrated in this study are an advantage to industry efficiency. The utilisation of HPP by the industry can significantly increase dry fermented meat sausage shelf life and safety, providing it an opportunity to reach the global market.

Laminaria digitata is a novel feedstuff that can be used in pig diets to replace conventional feedstuffs. However, its resilient cell wall can prevent the monogastric digestive system from accessing intracellular nutrients. Carbohydrate-active enzyme (CAZyme) supplementation is a putative solution for this problem, degrading the cell wall during digestion. The objective of this work was to evaluate the effect of 10% L. digitata feed inclusion and CAZyme supplementation on the meat quality and nutritional value of weaned piglets. Forty weaned piglets were randomly allocated to four experimental groups (n = 10): control, LA (10% L. digitata, replacing the control diet), LAR (LA + CAZyme (0.005% Rovabio® Excel AP)) and LAL (LA + CAZyme (0.01% alginate lyase)) and the trial lasted for two weeks. The diets had no effect on any zootechnical parameters measured (p > 0.05) and meat quality traits, except for the pH measured 24 h post-mortem, which was higher in LAL compared to LA (p = 0.016). Piglets fed with seaweed had a significantly lower n-6/n-3 PUFA ratio compared to control, to which the higher accumulation of C20:5n-3 (p = 0.001) and C18:4n-3 (p < 0.0001) contributed. In addition, meat of seaweed-fed piglets was enriched with bromine (Br, p < 0.001) and iodine (I, p < 0.001) and depicted a higher oxidative stability. This study demonstrates that the nutritional value of piglets’ meat could be improved by the dietary incorporation of L. digitata, regardless of CAZyme supplementation, without negatively affecting growth performance in the post-weaning stage.

Background Chlorella vulgaris has been proposed as a sustainable green feedstock in poultry nutrition due to its ease of cultivation, minimal environmental impact and balanced nutritional composition. However, the majority of studies documents the use of C. vulgaris as a dietary supplement in broilers instead of a feed ingredient. To the best of our knowledge, no report has shown the effect of a high-level incorporation (>2 % in the diet) of C. vulgaris on plasma metabolites and hepatic lipid composition of broilers. One hundred and twenty Ross 308 male birds were housed in 40 wired-floor cages and randomly distributed by the following experimental diets at 22 days of age (n = 10) during 15 days: (1) a corn-soybean meal based diet (control); (2) based diet with 10% of C. vulgaris; (3) diet 2 supplemented with 0.005% Rovabio® Excel AP; and (4) diet 2 supplemented with 0.01% of a pre-selected four-CAZyme mixture. Results The inclusion of C. vulgaris at 10% in the diet, regardless of the presence of exogenous CAZymes, changed plasma metabolites but did not compromise broilers growth. Plasma total lipids increased in broilers fed C. vulgaris combined with the two feed CAZymes (p < 0.001) compared with the control diet. Moreover, the supplementation with Rovabio® increased total cholesterol and LDL-cholesterol, while the addition of the four-CAZyme mixture increased triacylglycerols, VLDL-cholesterol and ALP activity. In opposition, HDL-cholesterol levels decreased in broilers fed microalga alone (p = 0.002). Regarding hepatic composition, the inclusion of C. vulgaris in broiler diets, individually or combined with exogenous CAZymes, had a minor effect on fatty acids but improved the n-6/n-3 ratio and total carotenoids. Conclusions In summary, the inclusion of a high level (10%) of C. vulgaris in broiler´s diet, regardless of the presence of exogenous CAZymes, improved hepatic antioxidant composition and did not impair broiler’s performance. In addition, the feed supplementation with CAZymes increased broilers lipemia. Therefore, dietary C. vulgaris at this incorporation level seems to be safe for animal health and do not compromise performance traits, with no need of CAZymes supplementation.