In this study, feed coal (FC) from the Figueira Thermoelectric Power Plant (FTPP), located in the state of Paraná (PR), Brazil was characterized by X-ray fluorescence (XRF), X-ray diffractometry (XRD), infrared spectroscopy (FTIR), thermogravimetric analysis (TGA), scanning electron microscopy (SEM), particle size distribution analysis by laser diffraction, loss of ignition (LOI), total carbon content (TC), pH and conductivity. FC-derived by-products (CCBs) collected at the FTPP were: bottom ash (BA), fly ash from cyclone filter (CA) and fly ash from bag filter (FA). In addition to the techniques used for feed coal characterization, CCBs were also characterized by total surface area (by using BET method), external surface area (by using laser diffraction), cation exchange capacity (CEC), bulk density, besides leaching and solubilization tests. FC sample contains 72.2% of volatile material, of which 55.3% is total carbon content. LOI, FTIR, TGA and TC analyzes corroborated with these results. The main crystalline phases in the FC sample were found to be quartz, kaolinite and pyrite. The elements As, Cr, Ni and Pb were encountered in the FC sample, indicating that the use of FTPP feed coal should be monitored due to the toxic potential of these elements. The three coal ashes were classified as class F according to ASTM and presented similar chemical composition, with total content of the main oxides (SiO2, Al2O3 and Fe2O3) above 72%. Ashes enrichment factor analysis (EF) showed that As, Zn and Pb concentrate mainly in fly ash from bag filter (FA), whereas the elements K and Mg presented higher enrichment in the bottom ash (BA) . All ashes presented quartz, mullite and magnetite as crystalline phases, as well as the same functional groups, related to the presence of humidity, organic matter and Si and Al compounds. XRD, XRF, TGA, FTIR, LOI and TC techniques were correlated and confirmed the obtained results. Total and external surface area values of CCBs were related to the total carbon content (TC), as well as to the results of particle size distribution and the scanning electron micrographs of the samples. On the other hand the CEC of the ashes showed relation with the particle size distribution and with the external surface area. Leaching and solubilization tests of CCBs showed that FA sample was considered hazardous and classified as class I waste, while CA and BA samples were considered non-hazardous and non-inert wastes and classified as class II-A. FA sample from Figueira power plant must be discarded only after treatment or a stringent disposal criterion must be followed to avoid contamination on site. In this work, feed coal sample was also compared to the CCBs samples generated from it. The results showed the differences between fuel and products through the different characterization techniques. In addition to contributing to the understanding of the relationship between coal and its combustion products, this work can also help to reduce the environmental impacts caused by the CCBs disposal, as well as can also be used to compare the characteristics of CCBs from FTPP with the new wastes that will be generated by the same thermal power plant that will be soon modernized.
The focus of this study was to measure the Volatile Organic Compounds (VOCs) concentrations in the megacity – São Paulo Metropolitan Area (SPMA). The measurements analyzed in this study included 78 hydrocarbon (HC) samples collected during 2006, and 66 samples of HC, 62 of aldehydes and 42 of ethanol collected during 2011-2012. The observational results showed that the consumption of ethanol, gasoline and diesel from 2006 to 2012 increased by 64 %, 23 % and 25 %, respectively, with substantial changes in the atmospheric composition. The 10 most abundant VOCs in the atmosphere found during 2011/2012 at CETESB IPEN/USP air quality monitoring station were ethanol, acetaldehyde, formaldehyde, acetone, propane, ethene, ethane, butane, 1-ethyl-4-methyl benzene, and 1,2,4-trimethyl benzene. During the 2006 campaign, alkanes represented 54.8 % of the total HC concentration, alkenes 29.2 %, aromatics 13.6 %, and alkadienes 2.4 %. On the other hand, during the 2011-2012 campaign, aldehydes represented 35.3 % of the VOCs, ethanol 22.6 %, aromatics 15.5 %, alkanes 13.5 %, acetone 6.8 %, alkenes 6.0 %, and alkadienes with less than 0.1 %. An increase in VOCs concentrations in the SPMA atmosphere from 2006 to 2012, such as aldehydes and aromatics (which are important ozone precursors) was measured.
High-purity zeolites A were synthesized from different coal combustion by-products (baghouse filter fly ash, cyclone filter ash, and bottom ash) and characterized in terms of morphology, chemical, and mineralogical composition. The products were tested for carbon dioxide capture by using a continuous CO 2 flow system passing through a column packed with the adsorbent material, which was connected to an analyser that directly measures the concentration of CO 2. The values of CO 2 adsorption capacities calculated for the unmodified Na-A zeolites (ZABF, ZACF, and ZABA) were 556.48, 494.29 and 654.82 mg g-1 , respectively. These values were higher than those achieved by the calcium-modified zeolite samples. ZABA adsorbent presented the best performance in CO 2 capture when compared to the other adsorbent material and achieved an adsorption capacity 32% higher than a 4A commercial zeolite. In the adsorption cycles study, the percentage of CO 2 desorption by ZABA at the second and third cycles reached 93%, showing that zeolite A can be regenerated by heating at 150 ºC. The use of coal ashes to obtain zeolites and the application of these products for the CO 2 adsorption can be an important strategy to mitigate both the problem of waste management and the greenhouse gases emission in coal-fired power plants.
scite is a Brooklyn-based organization that helps researchers better discover and understand research articles through Smart Citations–citations that display the context of the citation and describe whether the article provides supporting or contrasting evidence. scite is used by students and researchers from around the world and is funded in part by the National Science Foundation and the National Institute on Drug Abuse of the National Institutes of Health.
hi@scite.ai
10624 S. Eastern Ave., Ste. A-614
Henderson, NV 89052, USA
Copyright © 2024 scite LLC. All rights reserved.
Made with 💙 for researchers
Part of the Research Solutions Family.