This study was designed to evaluate growth performance, carcass cutting yield, and processing characteristics of boneless hams and bellies from finishing pigs fed diets containing 0, 5, 10, or 20 ppm of the phenethanolamine ractopamine hydrochloride (RAC). Sixty pigs were blocked by starting weight and randomly assigned to pens (four pigs/pen) within each of three blocks. Treatments were then randomly assigned to the pens to total six pens of the 0-ppm level and three pens each at the 5-, 10-, and 20-ppm RAC levels. Weight gain and feed consumption were monitored and animals were slaughtered by weight block after approximately 48 d on trial. Slaughter weight, ADG, and feed/gain were improved (P less than .05) for RAC treatments. Dressing percentage was higher and increased linearly (P less than .05) for RAC treatments. Carcass weight, length, leaf fat weight, backfat thickness, loin eye area, and color, marbling, and firmness of the longissimus were evaluated. The RAC-treated carcasses were heavier (P less than .05) and loin eye area increased linearly (P less than .05). One side of each carcass was fabricated using National Association of Meat Purveyors specifications. Trimmed hams and loins from the RAC treatments were heavier (P less than .05) than those from control animals. No differences (P greater than .05) in carcass cutting yield (percentage of trimmed primal cuts) were observed between treatments. However, trimmed hams and loins from the 20-ppm RAC treatment represented a greater (P less than .05) percentage of carcass weight than did those from control animals. Ractopamine did not affect raw belly or bacon characteristics (P less than .05).(ABSTRACT TRUNCATED AT 250 WORDS)

A supercritical fluid extraction (SFE) method using CO2 has been developed for the removal analysis of fat from ground beef samples for nutritional analysis. The SFE procedure was coupled with a solid phase extraction (SPE) disk for the isolation of fats from acid hydrolyzed ground beef samples prior to SFE. The meat hydrolysate is filtered and collected on the reversed-phase SPE disk which is then subjected to SFE. The extracted fat is then transesterified to fatty acid methyl esters (FAMEs), and total, saturated, and cis-monounsaturated fats were determined by gas chromatography. The SFE method was tested on two commercial extractors and the results compared to a solvent-based (ether/hexane) extraction method. No significant differences were found between the results obtained by the solvent-based and the SC-CO2 methods. The SFE method proved a suitable replacement for a traditional organic solvent extraction methods, thereby eliminating the use and costs associated with solvent disposal as well as the exposure of laboratory personnel to toxic and/or flammable solvents. Keywords: Supercritical fluid extraction; solid phase extraction; CO2; lipid analysis; triglycerides; fatty acid methyl esters; ground beef

Ractopamine hydrochloride (RAC) has consistently led to an advantage in carcass cutting yields of finishing pigs and remains a common feed additive in US finishing pig diets. Less is known about the effect of RAC on further processing characteristics. Some researchers have reported advantages in ultimate pH of the LM in pigs fed RAC. If a greater ultimate pH was also observed in hams, the increased pH could affect further processing characteristics and lead to better protein interaction and improved textural properties. The objective of this experiment was to determine if RAC-fed pigs yielded hams with a greater ultimate pH, and if so, whether or not that advantage improves textural properties and water retention of further processed hams. Two hundred hams from barrows and gilts fed RAC or control diets were selected based on HCW. Hams were fabricated into 5 separate pieces to determine cutting yields, and 6 muscles were evaluated for ultimate pH. Hams were processed to make cured and smoked hams. Ractopamine increased cutting yields of the whole ham (P < 0.0001), inside (P < 0.01), outside (P < 0.01), and knuckle (P < 0.01) when expressed as a percentage of chilled side weight. Ultimate pH of the rectus femoris, vastus lateralis, and semitendinosus were all 0.06 pH units greater (P < 0.05), the biceps femoris was 0.04 pH units greater (P = 0.02), and the semimembranosus and adductor muscles were 0.03 pH units greater in pigs fed 7.4 mg/kg of RAC when compared with control pigs. Cured hams from RAC-fed pigs were heavier at all stages of production. No differences were detected in binding strengths (P = 0.88) or protein fat-free values (P = 0.13) between RAC (9.06 kg and 20.37) and control hams (9.01 kg and 20.13). Ractopamine increased cutting yields, total weight of cured hams, and ultimate muscle pH. Ractopamine can be fed to pigs to achieve the desired growth characteristic advantages and cutting yields without affecting further processed ham characteristics.