Lactic acid bacteria (LAB), which are commonly used in the production of fermented foods, have been gaining attention for their antifungal and antimycotoxin properties. In this work, the strain Lactobacillus plantarum UM55 was selected among other LAB for inhibiting the growth of Aspergillus flavus. Further, it is shown that cell-free supernatant (CFS) of this strain inhibits the production of aflatoxins (AFLs) by 91%. This inhibition was dependent on CFS pH, increased with increasing concentrations of CFS, and was independent of fungal growth, which was inhibited only by 32%. CFS was also effective in inhibiting the growth and AFLs production in A. parasiticus, A. arachidicola, A. nomius and A. minisclerotigenes. Further, L. plantarum UM55 CFS was analysed for the presence of organic acids and the main differences compared to controls were found in the levels of lactic acid, phenyllactic acid (PLA), hydroxyphenyllactic acid (OH-PLA), and indole lactic acid (ILA). These compounds were individually tested against A. flavus, with all of the compounds showing an inhibiting effect on fungal growth and AFLs production. PLA showed the stronger effects, and the obtained IC for the inhibition of growth and AFLs was of 11.9 and 0.87mg/mL, respectively. AFLs IC for ILA, OH-PLA and lactic acid were of 1.47, 1.80, and 3.92mg/mL, respectively. The antiaflatoxigenic properties of LAB depend on strain's capability to produce lactic acid, PLA, OH-PLA and ILA.

Lactic acid bacteria (LAB) are a promising solution to reduce exposure to dietary mycotoxins because of the unique mycotoxin decontaminating characteristic of some LAB. Ochratoxin A (OTA) is one of the most prominent mycotoxins found in agricultural commodities. The present work reports on the ability of Pediococcus parvulus strains that were isolated from Douro wines that spontaneously underwent malolactic fermentation to detoxify OTA. These strains were identified and characterised using a polyphasic approach that employed both phenotypic and genotypic methods. When cultivated on OTA-supplemented MRS media, OTA was biodegraded into OTα by certain P. parvulus strains. The presence of OTα was confirmed using LC-MS/MS. The conversion of OTA into OTα indicates that the OTA amide bond was hydrolysed by a putative peptidase. The rate of OTA biodegradation was found to be dependent on the inoculum size and on the incubation temperature. Adsorption assays with dead P. parvulus cells showed that approximately 1.3%±1.0 of the OTA was adsorbed onto cells wall, which excludes this mechanism in the elimination of OTA by strains that degrades OTA. Under optimum conditions, 50% and 90% of OTA were degraded in 6 and 19h, respectively. Other LAB strains that belonged to different species were tested but did not degrade OTA. OTA biodegradation by P. parvulus UTAD 473 was observed in grape must. Because some P. parvulus strains have relevant probiotic properties, the strains that were identified could be particularly relevant to food and feed applications to counteract the toxic effects of OTA.

Edible films and coatings have been extensively studied in recent years due to their unique properties and advantages over more traditional conservation techniques. Edible films and coatings improve shelf life and food quality, by providing a protective barrier against physical and mechanical damage, and by creating a controlled atmosphere and acting as a semipermeable barrier for gases, vapor, and water. Edible films and coatings are produced using naturally derived materials, such as polysaccharides, proteins, and lipids, or a mixture of these materials. These films and coatings also offer the possibility of incorporating different functional ingredients such as nutraceuticals, antioxidants, antimicrobials, flavoring, and coloring agents. Films and coatings are also able to incorporate living microorganisms. In the last decade, several works reported the incorporation of bacteria to confer probiotic or antimicrobial properties to these films and coatings. The incorporation of probiotic bacteria in films and coatings allows them to reach the consumers' gut in adequate amounts to confer health benefits to the host, thus creating an added value to the food product. Also, other microorganisms, either bacteria or yeast, can be incorporated into edible films in a biocontrol approach to extend the shelf life of food products. The incorporation of yeasts in films and coatings has been suggested primarily for the control of the postharvest disease. This work provides a comprehensive review of the use of edible films and coatings for the incorporation of living microorganisms, aiming at the biopreservation and probiotic ability of food products.

An electrospun mesh was created with sufficient pore size to allow cell infiltration into its structure, thus resulting in a fully populated construct appropriate for 3D tissue engineering applications.

The control of fungal contamination is particularly important to avoid both spoilage of food and feed products and the occurrence of toxic compounds, known as mycotoxins. Some lactic acid bacteria (LAB) strains have shown the capacity to inhibit fungal growth and the production of mycotoxins. In this work, cell-free supernatants (CFS) of Lactobacillus plantarum UM55 and Lactobacillus buchneri UTAD104 were tested against Penicillium nordicum radial growth and OTA production. When CFS of these strains were used, the radial growth of the fungus was inhibited by less than 20%, but the production of OTA was reduced by approx. 60%. These antifungal effects resulted from organic acids produced by LAB. The CFS of L. plantarum UM55 contained lactic acid, phenyllactic acid (PLA), hydroxyphenyllactic acid (OH-PLA) and indole lactic acid (ILA), while L. buchneri UTAD104 CFS contained acetic acid, lactic acid and PLA. These organic acids were further tested individually for their inhibitory capacity. Calculation of the inhibitory concentrations (ICs) showed that acetic acid, ILA and PLA were the most effective in inhibiting P. nordicum growth and OTA production. When the inhibitory activity of LAB cells incorporated into the culture medium was tested, L. buchneri UTAD104 inhibited the production of OTA entirely in all conditions tested, but fungal growth was only inhibited completely by the highest concentrations of cells. Acetic acid production was primarily responsible for this effect. In conclusion, the ability of LAB to inhibit mycotoxigenic fungi depends on strain capability to produce specific organic acids, and those acids may differ from strain to strain. Also, the use of LAB cells, especially from L. buchneri, in food products prone to contamination with P. nordicum (e.g. dry-cured meats and cheeses) may be an alternative solution to control fungal growth and OTA production.

No abstract

No abstract

No abstract