Antioxidant stilbenoids, such as resveratrol, arachidin-1, and arachidin-3, have demonstrated beneficial effects on human health. Although resveratrol is commercially available, arachidin-1 and arachidin-3 are not, resulting in an opportunity to explore purification methods and to confirm biological activity. Recently, Arachis hypogaea hairy root cultures (produced via Agrobacterium rhizogenes-mediated transformation) were reported to secrete stilbenoids into liquid growth media upon elicitation in quantities sufficient for commercial production. The purpose of this study was to purify substantial quantities of resveratrol, arachidin-1, and arachidin-3 from A. hypogaea hairy root cultures using centrifugal partition chromatography (CPC), determine the antioxidant activity of these compounds using the thiobarbituric acid reactive substances (TBARS) assay, and determine the cytotoxicity of the compounds using the 3-(4,5-dimethylthiazol-2-yl)-2,5-diphenyltetrazolium bromide (MTT) assay. In a single run of CPC, resveratrol, arachidin-1, and arachidin-3 were separated to a purity of 97.1%, 97.0%, and 91.8%, respectively. Lipid oxidation was inhibited by a 27 and 7 μM dose for reference standards of resveratrol and arachidin-1, respectively, while oxidation was not inhibited up to a 27 μM dose for reference standard of arachidin-3. Oxidation was inhibited at a 14, 7, and 14 μM doses for CPC-purified resveratrol, arachidin-1, and arachidin-3, respectively. Arachidin-1 and arachidin-3 demonstrated cytotoxicity at 27 and 55 μM in RAW 264.7 and HeLa cell lines, respectively; while resveratrol exhibited no cytotoxicity to either cell line. These results demonstrate the integration of a production and purification system for the manufacturing of A. hypogaea-derived stilbenoids.
Switchgrass (Panicum virgatum L.) has recently received significant attention as a possible feedstock for the production of liquid fuels such as ethanol. In addition, switchgrass may also be a source of valuable co-products, such as antioxidants, and our laboratory recently reported that switchgrass contains policosanols and alpha-tocopherol. Motivation for this work began when a switchgrass sample was extracted with water at 50 degrees C and was then tested for low-density lipoprotein (LDL) oxidation inhibition activity using the Thiobarbituric Acid Reactive Substances (TBARS) assay. The TBARS results showed that the switchgrass water extracts inhibited LDL oxidation by as much as 70% in comparison to the control. Liquid chromatography coupled with mass spectrometry (LC-MS) and high performance liquid chromatography (HPLC) were used to identify the compounds that were responsible for LDL oxidation inhibition activity as flavonoids: quercitrin (quercetin-3-O-rhamnoside) and rutin (quercetin-3-O-rutinoside). To maximize flavonoid concentrations, switchgrass was then extracted with water and 60% methanol at different temperatures. The 60% methanol treatment resulted in higher rutin and quercitrin yields when compared to water-only extraction; however, the use of this solvent would not be practical with current biorefinery technology. Centrifugal partition chromatography (CPC) was then used to purify rutin and quercitrin from the switchgrass water extract, which were then tested via the TBARS assay and shown to exhibit lipid peroxidation inhibition activity similar to that obtained with pure flavonoid standards. This is the first report on the presence of rutin and quercitrin in switchgrass. The results support the extraction of viable coproducts from switchgrass prior to conversion to liquid fuel.
Acetic acid is introduced into cellulose conversion processes as a consequence of composition of lignocellulose feedstocks, causing significant inhibition of adapted, genetically modified and wild-type S. cerevisiae in bioethanol fermentation. While adaptation or modification of yeast may reduce inhibition, the most effective approach is to remove the acetic acid prior to fermentation. This work addresses liquid-liquid extraction of acetic acid from biomass hydrolysate through a pathway that mitigates acetic acid inhibition while avoiding the negative effects of the extractant, which itself may exhibit inhibition. Candidate solvents were selected using simulation results from Aspen Plus™, based on their ability to extract acetic acid which was confirmed by experimentation. All solvents showed varying degrees of toxicity toward yeast, but the relative volatility of ethyl acetate enabled its use as simple vacuum evaporation could reduce small concentrations of aqueous ethyl acetate to minimally inhibitory levels. The toxicity threshold of ethyl acetate, in the presence of acetic acid, was found to be 10 g L(-1) . The fermentation was enhanced by extracting 90% of the acetic acid using ethyl acetate, followed by vacuum evaporation to remove 88% removal of residual ethyl acetate along with 10% of the broth. NRRL Y-1546 yeast was used to demonstrate a 13% increase in concentration, 14% in ethanol specific production rate, and 11% ethanol yield. This study demonstrated that extraction of acetic acid with ethyl acetate followed by evaporative removal of ethyl acetate from the raffinate phase has potential to significantly enhance ethanol fermentation in a corn stover bioethanol facility. © 2016 American Institute of Chemical Engineers Biotechnol. Prog., 32:929-937, 2016.
5-Hydroxymethylfurfural (HMF) has potential as a key platform commodity for producing plastics from bioderived sugars rather than petroleum. To date, economically feasible HMF production has been limited by high substrate cost, the use of expensive solvents, or low reaction yields. In this work, a process to produce HMF directly from corn in a single-vessel reaction is described. Molar HMF yields of 88% are attained through the addition of activated carbon to a reaction media consisting of water, dimethyl sulfoxide, and acetonitrile. An HMF production process is described, and a preliminary economic analysis demonstrates that the minimum selling price of HMF is $1105 per tonne. This selling price is competitive with paraxylene, a similar petroleum-derived chemical for plastic synthesis that is sold for ∼ $1300 per tonne. A sensitivity analysis was performed to identify critical technical hurdles for successful commercialization of an HMF production facility. Additionally, Monte Carlo analysis suggests that the probability of creating a profitable process is high. The results of this work represent a significant step forward for the commercialization of HMF as a commodity chemical to compete with petroleum-based precursors to plastics.
scite is a Brooklyn-based organization that helps researchers better discover and understand research articles through Smart Citations–citations that display the context of the citation and describe whether the article provides supporting or contrasting evidence. scite is used by students and researchers from around the world and is funded in part by the National Science Foundation and the National Institute on Drug Abuse of the National Institutes of Health.
hi@scite.ai
10624 S. Eastern Ave., Ste. A-614
Henderson, NV 89052, USA
Copyright © 2024 scite LLC. All rights reserved.
Made with 💙 for researchers
Part of the Research Solutions Family.