Physical aging and mechanical performance of poly(l‐lactide)/ZnO nanocomposites

Abstract

In this work nanocomposites based on poly (l‐lactide) (PLLA) and zinc oxide (ZnO) nanoparticles with a concentration up to 5 wt % have been prepared by solvent‐precipitation followed by compression moulding at 200 °C. Structural evolution of nanocomposites as a function of time and nanoparticle concentration has been monitored by differential scanning calorimetry (DSC). Results reveal a marked reduction of the enthalpy relaxation rate βH from 3.273 J/g for neat polymer to 0.912 J/g for its 0.25 wt % reinforced counterpart, revealing slower aging dynamics induced by zinc oxide. It is shown by field emission scanning electron microscopy (FE‐SEM) that concentrations larger than 1 wt % yield nanoparticle agglomeration. These large aggregates decrease the amount of nanoparticle surfaces exposed to PLLA chains, notably reducing the efficiency of ZnO nanoparticles to delay the physical aging of its hosting matrix. Mechanical tests show an increased stiffness upon ZnO loading as denoted by the increase in modulus from 2310 MPa to 2780 MPa for the 1 wt % nanocomposite. Obtained findings through this work lead the way for the development of nanocomposites based on renewable polymers and natural fillers to be used in packaging applications, where the use of nonbiodegradable materials for short‐term applications is extended. © 2016 Wiley Periodicals, Inc. J. Appl. Polym. Sci. 2016, 133, 43619.

Silk nano‐discs: A natural material for cancer therapy

“…[31] CSN have a surface charge of~−34 mV in water at 25 C rendering repulsive forces among them allowing for stable dispersions ( Figure S9, Supporting Information). [55] CSNs have β-sheet conformation which was confirmed using FT-IR, 13 C-ss-NMR and XRD. Absorption bands relating to protein conformation are detected in amide I, II, III and V spectral regions (Figure 2a).…”

Tributyl citrate as an effective plasticizer for biodegradable polymers: effect of plasticizer on free volume and transport and mechanical properties

“…The cell was placed on a Sartorius balance with 10 −5 g readability and the weight loss was recorded on a computer. 5,20,21 Sorption experiments were performed with an IGA-2 Hiden electromagnetic balance at 25.5 ∘ C and 0.24-0.92 water vapour activity. More details about the equipment and method have been described elsewhere.…”

Understanding the oxygen barrier property of highly transparent poly(lactic acid)/benzoxazine composite film by analyzing the UV‐shielding performance

“…Generally, the life of foods and outdoor products such as electronics are always affected by the oxygen and UV light, which need protection from outside environmental impact via packaging or encapsulating. Although there are a few literature data about the TiO 2 14 and ZnO 15,16 which can simultaneously improve the oxygen barrier and UV-shielding properties, the side effect of their photocatalytic activities should be concerned. 17 The graphene oxide nanosheet (GONS) 2 and rosin (RS) 18 also endow the PLA with good oxygen barrier and UV-shielding properties, but the visible light transparencies are low.…”