Changes in toxicity during treatment of wastewater from oil plant contaminated with petroleum hydrocarbons

Abstract

BACKGROUND Exploitation of oil‐fields always faces problems with management of petroleum‐contaminated wastewaters. Wastewater, severely contaminated with petroleum hydrocarbons: total petroleum hydrocarbons (TPH, 340.7 mg L−1), benzene, toluene, ethylbenzene, xylene (BTEX, 5.52 mg L−1), phenols (2.95 mg L−1), and polycyclic aromatic hydrocarbons (PAH, 29.2 µg L−1), were pretreated on a flow‐line installation. The following processes were applied: flotation, coagulation with flocculation, sedimentation and filtration of sediments. Then a biological module with an active biopreparation (microbial consortium, based on non‐pathogenic indigenous bacteria and fungi) was used to remove extant hydrocarbons. RESULTS After wastewater pretreatment, TPH content decreased to 49.7 mg L−1. During biological treatment, petroleum contaminants (TPH, phenols, BTEX and PAH) were decreased by 89%, 69%, 62%, and 46%, respectively. Biodegradation reached 83–96% for nC11–nC22 and 34–68% for nC23–nC36 alkanes (more resistant). Microtox, MARA, Daphtoxkit and Ames test indicated that changes in toxicity were not strictly connected with the decrease in TPH contents, possibly due to the formation of toxic indirect metabolites during biodegradation. After treatment, wastewater had no toxic properties. CONCLUSION As results show, toxicological tests are an effective tool to monitor changes in toxicity during wastewaters treatment. This field scale study proved that combining physico‐chemical processes and biological treatment has high effectiveness in petroleum hydrocarbons removal. © 2014 Society of Chemical Industry

Organic Pollutants in Shale Gas Flowback and Produced Waters: Identification, Potential Ecological Impact, and Implications for Treatment Strategies

“…Low to moderate removal of VOCs, PAHs and phthalates during aerobic and anaerobic treatment of industrial wastewaters is reported by several authors. 67 , 115 − 117 Thus, 40% of the sum of PAHs present at initial concentrations of 15.2 μg/Lwere degraded in pilot-scale aerobic SBR treating petrochemical wastewater at long hydraulic retention time (HRT = 22 d.). 67 Two to three ring PAHs are more amenable to biodegradation under both aerobic and anaerobic conditions when compared to PAH with >3 rings.…”

Biological treatment of oil and gas produced water: a review and meta-analysis

“…Lu and Wei (2011) investigated treatment with zerovalent iron (20 g/L) and EDTA (150 mg/L) prior to studying biotreatability of produced water from a polymer flooded oilfield-45% COD removal was observed despite the presence of recalcitrant polymer hydrolyzed polyacrylamide. Coagulation-flocculation was used as a pretreatment in an aerobic batch test study with other pretreatments (flotation, sedimentation, and filtration), resulting in 91% TPH removal (Steliga et al 2015).…”

Zastosowanie testów toksykologicznych w przemyśle naftowym

“…W INiG -PIB od kilku lat trwają prace wdrożeniowe nad zastosowaniem testów toksykologicznych nowej generacji do określania rzeczywistej toksyczności odpadów (w tym zanieczyszczeń ropopochodnych), wód złożowych oraz płynów pozabiegowych z przemysłu wydobywczego nafty i gazu. Wyniki dotychczasowych badań potwierdzają zasadność stosowania testów toksykologicznych podczas oceny zagrożeń stwarzanych przez wody złożowe i inne odpady dla środowiska [6,7,[12][13][14]. Testy te pozwalają ponadto na określenie zmian toksyczności podczas prowadzenia procesów oczyszczania gleby oraz wody.…”