A comprehensive review on biodiesel production using
            <i>Moringa oleifera</i>
            oil

Niju, Subramaniapillai; Balajii, Muthusamy; Anushya, C.

doi:10.1080/15435075.2019.1619565

Cited by 16 publications

(19 citation statements)

References 57 publications

Supporting

Mentioning

Contrasting

Order By: Relevance

“…The results of their research state that the CuO-CaO catalyst has a high level of porosity, can be reused and its effectiveness is still high after five trials in the transesterification process. The results of Niju et al [28] stated that the yield produced was still above 90%, but after the fifth experiment the yield decreased significantly because of the strong catalyst also decreased. CuO-CaO catalyst is also able to reduce the problem of soap formation in the top layer of biodiesel caused by the use of a Ca-based catalyst.…”

Section: Heterogeneous Catalyst In Biodiesel Production From Moringa Seed Oilmentioning

confidence: 96%

“…The occurrence of soap formation can inhibit the separation between methyl esters and glycerol which results in the formation of emulsions during the biodiesel washing process. The reactions that occur in the esterification process are as follows [28].…”

Section: Esterification Reactionmentioning

confidence: 99%

“…Catalysts used for conventional transesterification processes usually are homogeneous alkaline catalysts, such as potassium hydroxide (KOH), sodium hydroxide (NaOH), potassium methoxide (CH3OK), and sodium methoxide (CH3ONa) [15]. The transesterification reaction of triglycerides to methyl esters is as follows [28].…”

Section: Transesterification Processmentioning

confidence: 99%

“…Niju et al [28] made biodiesel from Moringa seed oil using a CuO-CaO catalyst. The results of their research state that the CuO-CaO catalyst has a high level of porosity, can be reused and its effectiveness is still high after five trials in the transesterification process.…”

Section: Heterogeneous Catalyst In Biodiesel Production From Moringa Seed Oilmentioning

confidence: 99%

“…The use of heterogeneous catalysts in the manufacture of biodiesel from Moringa seed oil has promising potential. Apart from the relatively high yield of biodiesel (average higher than 90%), the use of heterogeneous catalysts also facilitates the separation and purification process [9] [28]. Heterogeneous catalysts are low likely to cause corrosion, are environmentally friendly, and can be reused after the catalyst is filtered [28].…”

Section: Heterogeneous Catalyst In Biodiesel Production From Moringa Seed Oilmentioning

confidence: 99%

See 4 more Smart Citations

Non-Edible Moringa Oleifera Seeds for Environmentally Friendly Biodiesel – A Review

Arafah

Sukmawati

Safitri

et al. 2021

jrh

View full text Add to dashboard Cite

ABSTRAKKetersediaan bahan bakar fosil semakin lama semakin berkurang. Hal tersebut menyebabkan dibutuhkannya pengganti bahan bakar alternatif yaitu biodiesel. Minyak biji kelor memiliki potensi sebagai bahan baku pembuatan biodiesel, karena kandungan asam oleatnya yang tinggi yaitu 75,36 –87,49%. Penelitian ini bertujuan untuk mengkaji pembuatan biodiesel, penggunaan katalis heterogen serta pengaruh parameter operasi terhadap hasil dan kualitas biodiesel dari minyak biji kelor dengan metode studi literatur. Tahapan yang dilakukan dalam studi literatur ini adalah pengumpulan, pemisahan dan analisis artikel jurnal serta perumusan pembahasan dan kesimpulan. Pembuatan biodiesel minyak biji kelor dilakukan dengan beberapa tahapan proses, yaitu pengambilan minyak dari biji, proses esterifikasi-transesterifikasi dan pemurnian biodiesel. Parameter operasi yang paling berpengaruh dalam menghasilkan biodiesel minyak biji kelor adalah rasio molar metanol dan minyak, konsentrasi katalis, waktu reaksi dan temperatur reaksi. Penggunaan katalis heterogen mampu menghasilkan yield biodiesel minyak biji kelor yang tinggi yaitu rata-rata lebih besar dari 90%. Biodiesel minyak biji kelor telah sesuai dengan standar nasional (SNI 7182 : 2015) dan internasional (ASTM D6751 dan EN 14214)Kata Kunci: Biodisel Minyak Biji Kelor, Katalis Heterogen, Parameter Operasi, Karakteristik Biodiesel. ABSTRACTThe availability of fossil fuels is decreasing over time. This causes the need for an alternative fuel substitute, namely biodiesel. Moringa oleifera seeds are the raw material for making Moringa seed oil, used as raw material for making biodiesel. This is due to its high oleic acid contents, in the range of 75,36% - 87,49% the objectives of this study are to observe the production of biodiesel from Moringa seed oil, the use of heterogeneous catalysts in the production of Moringa seed oil biodiesel, the effect of operating parameters on the yield and quality of biodiesel produced. Literature study was done in this research, including the collection of journal articles, separation and analysis of journal articles, as well as the formulation of discussions and conclusions. Based on this study, there are several stages in the production of Moringa seed oil biodiesel, namely extracting oil from the seeds, esterification- transesterification, and refining of biodiesel. Operating parameters affect the manufacture of Moringa seed oil biodiesel. The most influential operating parameters are the molar ratio of methanol and oil, catalyst concentration, reaction time, and reaction temperature. The use of heterogeneous catalysts is able to produce a high yield of Moringa seed oil biodiesel, which is on average greater than 90%. Moringa seed oil biodiesel complies with both national (SNI 7182: 2015) and international (ASTM D6751 and EN 14214) standardr.Keywords: Moringa Seed Oil, Biodiesel, Heterogeneous Catalyst, Operating Parameters

show abstract

Section: Heterogeneous Catalyst In Biodiesel Production From Moringa Seed Oilmentioning

confidence: 96%

Section: Esterification Reactionmentioning

confidence: 99%

Section: Transesterification Processmentioning

confidence: 99%

Section: Heterogeneous Catalyst In Biodiesel Production From Moringa Seed Oilmentioning

confidence: 99%

Section: Heterogeneous Catalyst In Biodiesel Production From Moringa Seed Oilmentioning

confidence: 99%

See 3 more Smart Citations

Non-Edible Moringa Oleifera Seeds for Environmentally Friendly Biodiesel – A Review

Arafah

Sukmawati

Safitri

et al. 2021

jrh

View full text Add to dashboard Cite

show abstract

A Global Scenario of Sustainable Technologies and Progress in a Biodiesel Production

Kumbhar¹,

Lokhande²,

Chavan³

et al. 2021

Biodiesel Technology and Applications

View full text Add to dashboard Cite

Preparation of silicon‐based soybean base oil by modified soybean oil by transesterification and hydrosilation

2021

View full text Add to dashboard Cite

A new green lubricating base oil was synthesized from soybean oil and triethyl silane by a combination of transesterification and hydrosilylation. The factors affecting the process of hydrosilylation were thoroughly investigated. AlCl 3 /C catalyst as catalyst for hydrosilylation showed better catalytic performance, and a higher yield of 36.79% was obtained under optimal condition of molar ratio of transesterified soybean oils/triethyl silane (1:1.1), reaction temperature 120 C, and reaction time 8 h. In addition, the performance of silicon-based soybean base oil was tested according to industry standards. Compared with soybean oil, silicon-based soybean base oil was obtained with high viscosity index, good pour point of −17 C, and excellent wear characteristic.

show abstract

A comprehensive review on biodiesel production using Moringa oleifera oil

Cited by 16 publications

References 57 publications

Non-Edible Moringa Oleifera Seeds for Environmentally Friendly Biodiesel – A Review

Non-Edible Moringa Oleifera Seeds for Environmentally Friendly Biodiesel – A Review

A Global Scenario of Sustainable Technologies and Progress in a Biodiesel Production

Preparation of silicon‐based soybean base oil by modified soybean oil by transesterification and hydrosilation

Contact Info

Product

Resources

About