СОЗДАНИЕ ПЕРСПЕКТИВНЫХ МАЛОГАБАРИТНЫХ ГАЗОТУРБИННЫХ УСТАНОВОК С НЕЗАВИСИМЫМИ ЧАСТОТАМИ ВРАЩЕНИЯ КОМПРЕССОРА И ТУРБИНЫРассмотрена возникающая при проектирова-нии малоразмерных турбогенераторов проблема выбора оптимальной тепловой схемы и компоновки для получения максимального КПД установки. Проведены разработка и научно-техническое обос-нование малогабаритной газотурбинной установки с оптимальным соотношением частот вращения малорасходной турбины радиально-осевого типа и малорасходного центробежного компрессора. При-ведены данные экспериментальных исследований проточных частей малорасходной турбины ради-ально-осевого типа и малорасходного центробеж-ного компрессора.Ключевые слова: малогабаритные газотур-бинные установки, МГТУ, разделение частот вра-щения, тепловая схема, компоновка, малорасход-ный центробежный компрессор, малорасходная турбина радиально-осевого типа, эксперименталь-ные характеристики.V.V. Barskov, V.A. Rassokhin, S.N. Besedin, A.V. Osipov CREATION OF PERSPECTIVE SMALL-SIZE GAS-TURBINE INSTALLATIONS WITH INDEPENDENT ROTATING SPEEDS COMPRESSOR AND TURBINEThe problem of a choice of the optimum thermal diagram and configuration arising in case of design of small turbogenerators for obtaining the maximum efficiency of installation is considered. Are developed also scientific and technical reasons for small-size gasturbine installation with an optimum ratio of rotating speeds of the low-account turbine of radial-axial type and the low-account centrifugal compressor. Data of the pilot studies of flowing parts of the low-account turbine of radial-axial type and the low-account centrifugal compressor are provided.Key words: small-size gas-turbine installations, MSTU, division of rotating speeds, thermal diagram, configuration, low-account centrifugal compressor, low-account turbine of radial-axial type, the experimental characteristics. ВведениеМногообразие потребителей энергии и требований к виду и качеству энерго-обеспечения заставляет по-новому взгля-нуть на роль автономных энергетических агрегатов малой мощности (от десятков киловатт до нескольких мегаватт) в общей структуре энергетики. В условиях совре-менной государственной политики и курса экономики на импортозамещение в бли-жайшей перспективе серьезное внимание следует уделить сооружению отечествен-ных, относительно дешевых автономных энергетических установок (АЭУ) малой мощности различного назначения, финан-сирование которых возможно как из мест-ных бюджетов, так и за счет инвестиций частного капитала.Эффективность использования мало-габаритных газотурбинных установок оп-ределяется:• низкой себестоимостью производ-ства электроэнергии и тепла при использо-вании совершенного оборудования;• высокой надежностью энергоснаб-жения, существенным сокращением сро-ков их сооружения;• независимостью режима работы от загруженности энергосистемы, уменьше-нием отчуждения территории под крупное энергетическое строительство;• повышением экологичности произ-водства электроэнергии и тепла;• снижением затрат на охрану окру-жающей среды;• применением перспективных со...
In 2014 for the realization of experimental investigation there was assembled a completed experimental plant for testing lowspending turbo-machines with the use of an inductor brake (IB) at the enterprise “Microturbine Techniques” Co. and was installed on a test board of the laboratory of the department “Turbines, Fluid Machines and Aviation Engines” of SPbPU. In the structure of a test bench there is included an air system, oil system, system of control, measuring and information accumulation. From the air system air passes through a flow gage and delivered to IB. All tests will be agreed with the frequencies of rotor rotation in the course of which there were carried out measurements. According to values read of consumption, pressure, temperatures and efforts to a stator lever of an inductor brake with the aid of PC software the parameters of a lowspending centrifugalflow compressor (LCC) will be computed. The criterion of capacity equality consumed by LCC and taken off from a lowspending radialaxial turbine will be zero value of the effort on a stator lever of an inductor brake. As a result of the work performed the IB equipment is prepared, all systems of the test board are connected up. The systems of control, measuring and experimental data accumulation are connected up and adjusted. A visualization program is developed.
In the article the problem arising in the design of small-size turbo-generators (mhtg) in selecting the optimal thermal circuit and layout to maximize the efficiency of the installation. The experience of work on the creation of small mgtg, the features created by the installation and effectiveness of use. Outlines the key ways to improve the efficiency of the installation - the use of regenerative heating air supply before combustion, the increase of gas temperature before the turbine, the achievement of the optimum degree of pressure increase. Marked limitations in efficiency optimization, recommendations on the choice of scheme and layout mgtg, the benefits of the proposed scheme and layout.
scite is a Brooklyn-based organization that helps researchers better discover and understand research articles through Smart Citations–citations that display the context of the citation and describe whether the article provides supporting or contrasting evidence. scite is used by students and researchers from around the world and is funded in part by the National Science Foundation and the National Institute on Drug Abuse of the National Institutes of Health.
customersupport@researchsolutions.com
10624 S. Eastern Ave., Ste. A-614
Henderson, NV 89052, USA
Copyright © 2024 scite LLC. All rights reserved.
Made with 💙 for researchers
Part of the Research Solutions Family.