SummarySugarcane is a prime bioethanol feedstock. Currently, sugarcane ethanol is produced through fermentation of the sucrose, which can easily be extracted from stem internodes. Processes for production of biofuels from the abundant lignocellulosic sugarcane residues will boost the ethanol output from sugarcane per land area. However, unlocking the vast amount of chemical energy stored in plant cell walls remains expensive primarily because of the intrinsic recalcitrance of lignocellulosic biomass. We report here the successful reduction in lignification in sugarcane by RNA interference, despite the complex and highly polyploid genome of this interspecific hybrid. Down-regulation of the sugarcane caffeic acid O-methyltransferase (COMT) gene by 67% to 97% reduced the lignin content by 3.9% to 13.7%, respectively. The syringyl ⁄ guaiacyl ratio in the lignin was reduced from 1.47 in the wild type to values ranging between 1.27 and 0.79. The yields of directly fermentable glucose from lignocellulosic biomass increased up to 29% without pretreatment. After dilute acid pretreatment, the fermentable glucose yield increased up to 34%. These observations demonstrate that a moderate reduction in lignin (3.9% to 8.4%) can reduce the recalcitrance of sugarcane biomass without compromising plant performance under controlled environmental conditions.

␤-Alanine (␤-Ala) betaine is an osmoprotective compound accumulated by most members of the highly stress-tolerant family Plumbaginaceae. Its potential role in plant tolerance to salinity and hypoxia makes its synthetic pathway an interesting target for metabolic engineering. In the Plumbaginaceae, ␤-Ala betaine is synthesized by S-adenosyl-lmethionine-dependent N-methylation of ␤-Ala via N-methyl ␤-Ala and N,N-dimethyl ␤-Ala. It was not known how many N-methyltransferases (NMTases) participate in the three N-methylations of ␤-Ala. An NMTase was purified about 1,890-fold, from Limonium latifolium leaves, using a protocol consisting of polyethylene glycol precipitation, heat treatment, anion-exchange chromatography, gel filtration, native polyacrylamide gel electrophoresis, and two substrate affinity chromatography steps. The purified NMTase was trifunctional, methylating ␤-Ala, N-methyl ␤-Ala, and N,N-dimethyl ␤-Ala. Gel filtration and sodium dodecyl sulfate-polyacrylamide gel electrophoresis analyses indicated that the native NMTase is a dimer of 43-kD subunits. The NMTase had an apparent K m of 45 m S-adenosyl-l-methionine and substrate inhibition was observed above 200 m. The apparent K m values for the methyl acceptor substrates were 5.3, 5.7, and 5.9 mm for ␤-Ala, N-methyl ␤-Ala, and N,N-dimethyl ␤-Ala, respectively. The NMTase had an isoelectric point of 5.15 and was reversibly inhibited by the thiol reagent p-hydroxymercuribenzoic acid.

Overcoming the recalcitrance in lignocellulosic biomass for efficient hydrolysis of the polysaccharides cellulose and hemicellulose to fermentable sugars is a research priority for the transition from a fossilfuel-based economy to a renewable carbohydrate economy. Methylglucuronoxylans (MeGXn) are the major components of hemicellulose in woody biofuel crops. Here, we describe efficient production of the GH10 xylanase Xyl10B from Thermotoga maritima in transplastomic plants and demonstrate exceptional stability and catalytic activities of the in planta produced enzyme. Fully expanded leaves from homotransplastomic plants contained enzymatically active Xyl10B at a level of 11-15% of their total soluble protein. Transplastomic plants and their seed progeny were morphologically indistinguishable from non-transgenic plants. Catalytic activity of in planta produced Xyl10B was detected with poplar, sweetgum and birchwood xylan substrates following incubation between 40 and 90 °C and was also stable in dry and stored leaves. Optimal yields of Xyl10B were obtained from dry leaves if crude protein extraction was performed at 85 °C. The transplastomic plant derived Xyl10B showed exceptional catalytic activity and enabled the complete hydrolysis of MeGXn to fermentable sugars with the help of a single accessory enzyme (α-glucuronidase) as revealed by the sugar release assay. Even without this accessory enzyme, the majority of MeGXn was hydrolyzed by the transplastomic plant-derived Xyl10B to fermentable xylose and xylobiose.

L- Aspartate-alpha-decarboxylase catalyzes the decarboxylation of L -aspartate to generate Beta-alanine and carbon dioxide. This is an unusual pyruvoyl-dependent enzyme unique to prokaryotes that undergoes limited self-processing. The Escherichia coli pan D gene encoding L- aspartate-alpha-decarboxylase was expressed under a constitutive promoter in transgenic tobacco. Transgene expression was verified by assays based on RNA blots, immunoblots and enzyme activity in vitro. The pan D lines had increased levels of leaf Beta-alanine (1.2- to 4-fold), pantothenate (3.2- to 4.1-fold) and total free amino acids (up to 3.7-fold) compared to wild-type and vector controls. Growth of homozygous lines expressing E. coli L- aspartate-alpha-decarboxylase was less affected than that of the control lines when the plants were stressed for 1 week at 35 degrees C. When transferred from 35 to 30 degrees C for 3 weeks, the Pan D transgenic lines recovered significantly (P

Metabolic engineering for beta-alanine over-production in plants is expected to enhance environmental stress tolerance. The Escherichia coli L-aspartate-alpha-decarboxylase (AspDC) encoded by the panD gene, catalyzes the decarboxylation of L-aspartate to generate beta-alanine and carbon dioxide. The constitutive E. coli panD expression cassette was co-introduced with the constitutive, selectable aadA expression cassette into the chloroplast genome of tobacco via biolistic gene transfer and homologous recombination. Site specific integration of the E. coli panD expression cassette into the chloroplast genome and generation of homotransplastomic plants were confirmed by PCR and Southern blot analysis, respectively, following plant regeneration and germination of seedlings on selective media. PanD expression was verified by assays based on transcript detection and in vitro enzyme activity. The AspDC activities in transplastomic plants expressing panD were drastically increased by high-temperature stress. beta-Alanine accumulated in transplastomic plants at levels four times higher than in wildtype plants. Analysis of chlorophyll fluorescence on plants subjected to severe heat stress at 45 degrees C under light verified that photosystem II (PSII) in transgenic plants had higher thermotolerance than in wildtype plants. The CO(2) assimilation of transplastomic plants expressing panD was more tolerant to high temperature stress than that of wildtype plants, resulting in the production of 30-40% more above ground biomass than wildtype control. The results presented indicate that chloroplast engineering of the beta-alanine pathway by over-expression of the E. coli panD enhances thermotolerance of photosynthesis and biomass production following high temperature stress.

Lignocellulosic biomass has the potential to serve as feedstock and direct replacement for petrochemicals in the fuel, chemical, pharmaceutical and material industries. Energy cane has been identified by the U.S. Department of Energy (DOE) as prime lignocellulosic feedstock as it produces record biomass yields and is able to grow on low-value land with reduced inputs. Molecular improvement of energy cane is an essential step toward the development of a high-value crop and may contribute to improved biomass conversion to value added products. Such improvements require a development of an efficient regeneration and transformation system for the vegetatively propagated energy cane varieties. In this report, an efficient biolistic gene delivery protocol for energy canes (genotype L 79-1002 and Ho 00-961) has been established with immature leaf rolls as explants. Embryonic calli, developed approximately 6 weeks after culture initiation and was used as target for biolistic transfer of a minimum expression cassette of P-ubi::nptII::35S polyA derived from plasmid pJFNPTII. Putative transgenic clones of callus were obtained after selection on callus induction medium supplemented with 30 mg l(-1) geneticin. Regeneration was carried out on NB medium, which is modified from MS supplemented with 1.86 mg l(-1) naphthaleneacetic acid (NAA) and 0.1mg l(-1), 6- benzylaminopurine (BAP) and 20mg l(-1) paromomycin. Shoots growing on selection media were transferred to hormone free medium with 20 mg l(-1) paromomycin. Putative transgenic lines were first analyzed by PCR. Transgene integration was confirmed by Southern blot analysis. ELISA (Enzyme-Linked Immunosorbent Assay) and Immunochromathography assays confirmed transgene expression.

A protocol is described that supports the production of transgenic sugarcane plants ready for transfer to soil within 3 mo from culture initiation. Biolistic gene transfer into cross-sections of immature leaf whorl explants followed by direct somatic embryogenesis resulted in the stable genetic transformation of the commercially important sugarcane cultivar CP 88-1762. Accelerating the production of transgenic sugarcane plants not only saves time and effort but will likely also minimize somaclonal variation. Southern blot analysis revealed simple transgene integration patterns ranging from one to five hybridization products. NPTII-ELISA confirmed that most of the transgenic plants expressed the transgene stably in vegetative progeny. Using a minimal, linear expression cassette (MC) without vector backbone sequences for the biolistic gene transfer and reducing the amount of MC to 10 ng per shot may have led to simple transgene integration and stable transgene expression. Therefore, this protocol has great potential for the generation of commercial transgenic sugarcane events.

No abstract