This study tested the hypothesis that bioactive coating glass (SiO(2)-CaO-P(2)O(5)-MgO-K(2)O-Na(2)O system), used for implant coatings, enhanced the induction of collagen type 1 synthesis and in turn enhanced the expression of downstream markers alkaline phosphatase, Runx2 and osteocalcin during osteoblast differentiation. The ions from experimental bioactive glass (6P53-b) and commercial Bioglass(TM) (45S5) were added to osteoblast-like MC3T3-E1 subclone 4 cultures as a supplemented ion extract (glass conditioned medium (GCM)). Ion extracts contained significantly higher concentrations of Si and Ca (Si, 47.9+/-10.4 ppm; Ca, 69.8+/-14.0 for 45S5; Si, 33.4+/-3.8 ppm; Ca, 57.1+/-2.8 ppm for 6P53-b) compared with the control extract (Si<0.1 ppm, Ca 49.0 ppm in alpha-MEM) (ANOVA, p<0.05). Cell proliferation rate was enhanced (1.5x control) within the first 3 days after adding 45S5 and 6P53-b GCM. MC3T3-E1 subclone 4 cultures were then studied for their response to the addition of test media (GCM and control medium along with ascorbic acid (AA; 50 ppm)). Each GCM+AA treatment enhanced collagen type 1 synthesis as observed in both gene expression results (day 1, Col1alpha1, 45S5 GCM+AA: 3x control+AA; 6P53-b GCM+AA: 4x control+AA; day 5, Col1alpha2, 45S5 GCM+AA: 3.15x control+AA; 6P53-b GCM+AA: 2.35x control+AA) and in histological studies (Picrosirius stain) throughout the time course of early differentiation. Continued addition of each GCM and AA treatment led to enhanced expression of alkaline phosphatase (1.4x control+AA after 5 days, 2x control+AA after 10 days), Runx2 (2x control+AA after 7 days) and osteocalcin gene (day 3, 45S5 GCM+AA: 14x control+AA; day 5, 6P53-b GCM+AA: 19x control+AA) and protein expression (40x-70x control+AA after 6 days). These results indicated the enhanced effect of bioactive glass ions on key osteogenic markers important for the bone healing process.

Traumatic fractures cause structurally unstable sites due to severe bone loss. Such fractures generate a high yield of reactive oxygen species (ROS) that can lead to oxidative stress. Excessive and prolonged ROS activity impedes osteoblast differentiation and instigates long healing times. Stimulation of antioxidants such as superoxide dismutase (SOD1), are crucial to reduce ROS, stimulate osteogenesis, and strengthen collagen and mineral formation. Yet, no current fixative devices have shown an ability to enhance collagen matrix formation through antioxidant expression. This study reports plasma-enhanced chemical vapor deposition based amorphous silicon oxynitride (Si(ON)x) as a potential new fracture healing biomaterial that adheres well to the implant surface, releases Si(+4) to enhance osteogenesis, and forms a surface hydroxyapatite for collagen mineral attachment. These materials provide a sustained release of Si(+4) in physiological environment for extended times. The dissolution rate partially depends on the film chemistry and can be controlled by varying O/N ratio. The presence of Si(+4) enhances SOD1, which stimulates other osteogenic markers downstream and leads to rapid mineral formation. In vivo testing using a rat critical-sized calvarial defect model shows a more rapid bone-regeneration for these biomaterials as compared to control groups, that implies the clinical significance of the presented biomaterial.

Structurally unstable fracture sites require metal fixative devices, which have long healing times due to their lack of osteoinductivity. Bioactive glass coatings lack in interfacial bonding, delaminate, and have reduced bioactivity due to the high temperatures used for their fabrication. Here, we test the hypothesis that low-temperature PECVD amorphous silica can enhance adhesion to the underlying metal surface and that N incorporation enhances osteogenesis and rapid biomineralization. A model Ti/TiO2-SiOx interface was formed by first depositing Ti onto Si wafers, followed by surface patterning, thermal annealing to form TiO2, and depositing SiOx/Si(ON)x overlays. TEM micrographs showed conformal SiOx layers on Ti/TiO2 overlays while XPS data revealed the formation of an elemental Ti-O-Si interface. Nanoscratch testing verified strong SiOx bonding with the underlying TiO2 layers. In vitro studies showed that the surface properties changed significantly to reveal the formation of hydroxycarbonate apatite within 6 h, and Si(ON)x surface chemistry induced osteogenic gene expression of human periosteal cells and led to a rapid "bone-like" biomineral formation within 4 weeks. XANES data revealed that the incorporation of N increased the surface HA bioactivity by increasing the carbonate to phosphate ratio. In conclusion, silicon oxynitride overlays on bone-implant systems enhance osteogenesis and biomineralization via surface nitrogen incorporation.

a b s t r a c t a r t i c l e i n f o) after 30 days. In examining the extracellular matrix generated by cells when exposed to each GCM, it was found that 45S5 GCM had slightly elevated levels of mineral content within ECM as compared to 6P53-b GCM after 30 days while control treatments exhibited no mineral content. The formation of well-defined mineralized nodules (distinct PO 4 3− [960 cm

Abstract

This study resulted in enhanced collagen type 1 and osteocalcin expression in human periodontal ligament fibroblasts (hPDLF) when exposed to bioactive glass conditioned media that subsequently may promote early mineralized tissue development. Commercial Bioglass™ (45S5) and experimental bioactive coating glass (6P53-b), were used to make a glass conditioned media (GCM) for comparison to control medium. ICP-MS analysis showed increased concentrations of Ca(2+), PO(4) (3-), Si(4+), and Na(+), for 45S5 GCM and Mg(2+), K(+), Ca(2+), PO(4)(3-), Si(4+), and Na(+) for 6P53-b GCM (relative to control medium). Differentiating hPDLF cultures exposed to 45S5 and 6P53-b GCM showed enhanced expression of collagen type 1 (Col1α1, Col1α2), osteocalcin, and alkaline phosphatase gene expression. These GCM also enhanced osteocalcin protein expression. After 16 d of culture, 45S5 and 6P53-b GCM treated cells showed regions of deep red Alizarin staining, indicating increased Ca within their respective extracellular matrices (ECM), while control-treated cells did not exhibit these features. SEM analysis showed more developed ECM in GCM treated cultures, indicated by multiple tissue layering and abundant collagen fiber bundle formation, while control treated cells did not exhibit these features. SEM analysis showed polygonal structures suggestive of CaP in 45S5 GCM treated cultures. These results indicate the osteogenic potential of bioactive coating glass in periodontal bone defect filling applications.

This study tests the hypothesis that silicon and calcium ions combinatorially target gene expression during osteoblast differentiation. MC3T3-E1 subclone 4 osteoblast progenitors (transformed mouse calvarial osteoblasts) were exposed to Si 4þ (from Na 2 SiO 3 ) and Ca 2þ (from CaCl 2 :H 2 O) ion treatments both individually (0.4 mM each þ control treatment) and combinatorially (0.4 mM Si 4þ þ 0.4 mM Ca 2þ þ control treatment) and compared to control treated (a-minimum essential medium, 10% fetal bovine serum, and 1% penicillinstreptomycin) cells. Cell proliferation studies showed no significant increase in cell density between treatments over 5 days of culture. Cellular differentiation studies involved addition of ascorbic acid (50 mg/L) for all treatments. Relative gene expression was determined for collagen type 1 (Col(I)a1/Col(I)a2), core-binding factor a (cbfa1/Runx2), and osteocalcin (OCN), which indicated osteoblast progenitor differentiation into a mineralizing phenotype. . These results support the larger concept that ions (possibly released from bioactive glasses) could control bone formation by targeting osteoblast marker expression.

Inflammatory response in the dental pulp can alter the collagen matrix formation by dental pulp stem cells and lead to a delay or poor healing of the pulp. This inflammatory response is mediated by cytokines, including interleukin-1β and tumor necrosis factor-α. In this study, it is hypothesized that suppressing the actions of these inflammatory cytokines by knocking down the activity of transcription factor Nuclear Factor–κB will lead to dental pulp stem cell differentiation into odontoblasts and the production of collagen. Here, the role of Nuclear Factor–κB signaling and its reduction was examined during odontogenic behavior in the presence of these cytokines. The results showed a significant increase in Nuclear Factor–κB gene expression and p65 protein expression by interleukin-1β and tumor necrosis factor-α. Nuclear Factor–κB activation in the presence of these cytokines decreased significantly in a dose-dependent manner by a Nuclear Factor–κB inhibitor (MG132) and p65 siRNA. Down-regulation of Nuclear Factor–κB activity also enhanced the gene expression of the odontoblastic markers (dentin sialophosphoprotein, Nestin, and alkaline phosphatase) and displayed an odontoblastic cell morphology indicating the promotion of odontogenic differentiation of dental pulp stem cells. Finally, dental pulp stem cells exposed to reduced Nuclear Factor–κB activity resulted in a significant increase in collagen (I)-α1 expression in the presence of these cytokines. In conclusion, a decrease in Nuclear Factor-κB in dental pulp stem cells in the presence of inflammatory cytokines enhanced odontoblastic differentiation and collagen matrix formation.