No abstract

A heterogeneous micro-environment was identi®ed in a 12 m 3 bioreactor with a height-to-diameter ratio of 2.5. The reactor was aerated by a ring sparger and stirred by three Rushton turbines. E. coli cells were cultivated in minimal medium to a cell density in the order of 30 g/l. Samples of glucose, the growth limiting component fed to the process, were taken at three levels in the bioreactor (top/middle/bottom). These showed that glucose concentration declined away from the feedpoint. The gradients depended on the mixing characteristics of the feedpoint, and concentrations of up to 400 times the mean value were found when feed was added to a relatively stagnant mixing zone. This resulted in up to 20% lower biomass yield compared to the bench scale. Gradients also affected the by-product formation, resulting in acetate formation in the large-scale bioreactor.

A dynamic model of glucose overflow metabolism in batch and fed-batch cultivations of Escherichia coli W3110 under fully aerobic conditions is presented. Simulation based on the model describes cell growth, respiration, and acetate formation as well as acetate reconsumption during batch cultures, the transition of batch to fed-batch culture, and fed-batch cultures. E. coli excreted acetate only when specific glucose uptake exceeded a critical rate corresponding to a maximum respiration rate. In batch cultures where the glucose uptake was unlimited, the overflow acetate made up to 9. 0 +/- 1.0% carbon/carbon of the glucose consumed. The applicability of the model to dynamic situations was tested by challenging the model with glucose and acetate pulses added during the fed-batch part of the cultures. In the presence of a glucose feed, E. coli utilized acetate 3 times faster than in the absence of glucose. The cells showed no significant difference in maximum specific uptake rate of endogenous acetate produced by glucose overflow and exogenous acetate added to the culture, the value being 0.12-0.18 g g-1 h-1 during the entire fed-batch culture period. Acetate inhibited the specific growth rate according to a noncompetitive model, with the inhibition constant (ki) being 9 g of acetate/L. This was due to the reduced rate of glucose uptake rather than the reduced yield of biomass.

Industrial 20-m3-scale and laboratory-scale aerobic fed-batch processes with Escherichia coli were compared. In the large-scale process the observed overall biomass yield was reduced by 12% at a cell density of 33 g/l and formate accumulated to 50 mg/l during the later constant-feeding stage of the process. Though the dissolved oxygen signal did not show any oxygen limitation, it is proposed that the lowered yield and the formate accumulation are caused by mixed-acid fermentation in local zones where a high glucose concentration induced oxygen limitation. The hypothesis was further investigated in a scale-down reactor with a controlled oxygen-limitation compartment. In this scaledown reactor similar results were obtained: i.e. an observed yield lowered by 12% and formate accumulation to 238 mg/l. The dynamics of glucose uptake and mixed-acid product formation (acetate, formate, D-lactate, succinate and ethanol) were investigated within the 54 s of passage time through the oxygen-limited compartment. Of these, all except succinate and ethanol were formed; however, the products were re-assimilated in the oxygen-sufficient reactor compartment. Formate was less readily assimilated, which accounts for its accumulation. The total volume of the induced-oxygen-limited zones was estimated to be 10% of the whole liquid volume in the large bioreactor. It is also suggested that repeated excretion and re-assimilation of mixed-acid products contribute to the reduced yield during scale-up and that formate analysis is useful for detecting local oxygen deficiency in large-scale E. coli processes.

A Large bioreactor is an inhomogenous system with concentration gradients which depend on the fluid dynamics and the mass transfer of the reactor, the feeding strategy, the saturation constant, and the cell density. The responses of Escherichia coli cells to short-term oscillations of the carbon/energy substrate in glucose limited fed-batch cultivations were studied in a two-compartment reactor system consisting of a stirred tank reactor (STR) and an aerated plug flow reactor (PFR) as a recycle loop. Short-term glucose excess or starvation in the PFR was simulated by feeding of glucose to the PFR or to the STR alternatively. The cellular response to repeated short-term glucose excess was a transient increase of glucose consumption and acetate formation. But, there was no accumulation of acetate in the culture, because it was consumed in the STR part where the glucose concentration was growth limiting. However, acetate accumulated during the cultivation if the oxygen supply in the PFR was insufficient, causing higher acetate formation. The biomass yield was then negatively influenced, which was also the case if the PFR was used to simulate a glucose starvation zone. The results suggest that short-term heterogeneities influence the cellular physiology and growth, and can be of major importance for the process performance. (c) 1995 John Wiley & Sons, Inc.