No abstract

No abstract

H(2)S removal from biogas produced in anaerobic digestion of sludge through the introduction of oxygen under micro-aerobic conditions is studied. Research was carried out in two pilot plant reactors (working volume, 200 L each) treating sludge from WWTP with HRT of 20 days. Mixing was provided via sludge or biogas recirculation. Introduction of very low oxygen flow (0.013-0.024 L/L(reactor) d) successfully removed H(2)S content in biogas with an efficiency above 99%. Reactor performance during micro-aerobic operation in terms of biogas production, methane yield and COD removal were not affected by the amount of oxygen supplied, remaining stable and similar to the anaerobic behaviour. Sludge recirculation ( approximately 50 L/h) and biogas recirculation ( approximately 3.5 L/min) as mixing methods were found not significant in H(2)S removal from biogas while biogas recirculation reduced by 10 times dissolved sulphide concentration compared to sludge recirculation.

The treatment of H2S in the biogas produced during anaerobic digestion has to be carried out to ensure the efficient long-lasting use of its energetic potential. The microaerobic removal of H2S was studied to determine the treatment capacity at low and high H2S concentrations in the biogas (0.33 and 3.38% v/v) and to determine the optimal O2 rate that achieved a concentration of H2S of 150 mg/Nm3 or lower. Research was performed in pilot-plant scale digesters of sewage sludge, with 200 L of working volume, in mesophilic conditions with a hydraulic retention time of 20 d. O2 was supplied at different rates to the headspace of the digester to create the microaerobic conditions. The treatment successfully removed H2S from the biogas with efficacies of 97% for the low concentration and 99% for the highest, in both cases achieving a concentration below 150 mg/Nm3. An optimal O2 rate of 6.4 NLO2/Nm3 of biogas when treating the biogas was found with 0.33% (v/v) of H2S and 118 NLO2/ Nm3 of biogas for the 3.38% (v/v) concentration. This relation may be employed to control the H2S content in the biogas while optimising the O2 supply.