Delicatessen meats are reported to be the leading vehicle of foodborne listeriosis in the United States. Listeria monocytogenes can reach high numbers in these products during storage, and the growth rate is largely dictated by product formulation and storage temperature. To assess the impact of product age on Listeria growth, five commercial brands each of cured and uncured turkey breast, ham, and roast beef (three lots per brand) were sliced (approximately 25 g per slice) at the beginning of the shelf life, the midpoint, and the last allowable day of sale, surface inoculated with an eight-strain cocktail of L. monocytogenes (approximately 40 CFU/g), and then quantitatively examined for Listeria, lactic acid bacteria, and mesophilic aerobic bacteria during aerobic storage at 4, 7, or 10°C. As expected, L. monocytogenes grew faster in deli meats without rather than with Listeria inhibitors (lactate and/or diacetate) and at the highest storage temperature (10°C). Lag-phase durations for L. monocytogenes in deli meats with and without Listeria inhibitors were 9.21, 6.96, and 5.00 and 6.35, 3.30, and 2.19 days at 4, 7, and 10°C, respectively. Generation times for L. monocytogenes in deli meats with and without Listeria inhibitors were 1.59, 1.53, and 0.85 and 0.94, 0.50, and 0.36 at 4, 7, and 10°C, respectively. Maximum population densities for L. monocytogenes in deli meats with and without Listeria inhibitors were 5.26, 5.92, and 5.97 and 8.47, 8.96 and 9.34 log CFU/g at 4, 7, and 10°C, respectively. Although lactate and diacetate suppressed L. monocytogenes growth, the extent of inhibition differed, ranging from total inhibition in roast beef to only partial inhibition in ham and cured turkey. Listeria growth was also impacted by lot-to-lot variation in the concentrations of Listeria inhibitors, product pH, and background microflora. These data will be useful for developing recommendations for “best consumed by” dating for deli meats using a risk-based approach.

First recognized in 1895, X-ray irradiation soon became a breakthrough diagnostic tool for the dental and medical professions. However, the food industry remained slow to adopt X-ray irradiation as a means for controlling insects and microbial contaminants in food, instead using gamma and electron beam (E-beam) irradiation. However, the reinvention of X-ray machines with increased efficiency, combined with recent developments in legislation and engineering, is now allowing X-ray to actively compete with gamma irradiation and E-beam as a microbial reduction strategy for foods. This review summarizes the historical developments of X-rays and discusses the key technological advances over the past two decades that now have led to the development of several different X-ray irradiators capable of enhancing the safety and shelf life of many heat-sensitive products, including lettuce, spinach, tomatoes, and raw almonds, all of which have been linked to high profile outbreaks of foodborne illness.

Low-energy X-ray irradiation was assessed as a means of eliminating Escherichia coli O157:H7 on lettuce. Round-cut iceberg lettuce samples (2.54-cm diameter) were dip or spot inoculated with a three-strain cocktail of E. coli O157:H7, stored for 24 h at 4 degrees C, and then irradiated at four dose levels up to 0.25 kGy using a prototype low-energy (70 kV) X-ray irradiator. E. coli O157:H7 survivors were quantified by plating on sorbitol MacConkey agar containing cefixime and tellurite. Dip inoculation yielded a D(10)-value of 0.040 +/- 0.001 kGy, which is 3.4 times lower than a previously reported value of 0.136 kGy using gamma radiation. The D(10)-value for E. coli O157:H7 on spot-inoculated samples was 0.078 +/- 0.008 kGy, which is about twice that of dip-inoculated samples. When 10 stacked leaves were irradiated from both sides, a dose of 0.2 kGy was achieved at the center of the stack with a surface dose of 1 kGy, corresponding to a approximately 5-log reduction of E. coli O157:H7 at the center of the stack. Based on these findings, low-energy X-ray irradiation appears to be a promising microbial inactivation strategy for leafy greens and potentially for other types of fresh produce.

No abstract