Efficient phototrophic production of a high-value sesquiterpenoid from the eukaryotic microalga Chlamydomonas reinhardtii, Metabolic Engineering, http://dx.doi.org/10.1016/j.ymben.2016 This is a PDF file of an unedited manuscript that has been accepted for publication. As a service to our customers we are providing this early version of the manuscript. The manuscript will undergo copyediting, typesetting, and review of the resulting galley proof before it is published in its final citable form. Please note that during the production process errors may be discovered which could affect the content, and all legal disclaimers that apply to the journal pertain. olaf.kruse@uni-bielefeld.de AbstractThe heterologous expression of terpene synthases in microbial hosts has opened numerous possibilities for bioproduction of desirable metabolites. Photosynthetic microbial hosts present a sustainable alternative to traditional fermentative systems, using freely available (sun)light and carbon dioxide as inputs for bio-production. Here, we report the expression of a patchoulol synthase from Pogostemon cablin Benth in the model green microalga Chlamydomonas reinhardtii. The sesquiterpenoid patchoulol was produced from the alga and was used as a marker of sesquiterpenoid production capacity. A novel strategy for gene loading was employed and patchoulol was produced up to 922 ± 242 µg g -1 CDW in six days. We additionally investigated the effect of carbon source on sesquiterpenoid productivity from C. reinhardtii in scale-up batch cultivations. It was determined that up to 1.03 mg L -1 sesquiterpenoid products could be produced in completely photoautotrophic conditions and that the alga exhibited altered sesquiterpenoid production metabolism related to carbon source.

Liquid fuels sourced from fossil sources are the dominant energy form for mobile transport today. The consumption of fossil fuels is still increasing, resulting in a continued search for more sustainable methods to renew our supply of liquid fuel. Photosynthetic microorganisms naturally accumulate hydrocarbons that could serve as a replacement for fossil fuel, however productivities remain low. We report successful introduction of five synthetic metabolic pathways in two green cell factories, prokaryotic cyanobacteria and eukaryotic algae. Heterologous thioesterase expression enabled high-yield conversion of native fatty acyl-acyl carrier protein (ACP) into free fatty acids (FFA) in Synechocystis sp. PCC 6803 but not in Chlamydomonas reinhardtii where the polar lipid fraction instead was enhanced. Despite no increase in measurable FFA in Chlamydomonas, genetic recoding and over-production of the native fatty acid photodecarboxylase (FAP) resulted in increased accumulation of 7-heptadecene. Implementation of a carboxylic acid reductase (CAR) and aldehyde deformylating oxygenase (ADO) dependent synthetic pathway in Synechocystis resulted in the accumulation of fatty alcohols and a decrease in the native saturated alkanes. In contrast, the replacement of CAR and ADO with Pseudomonas mendocina UndB (so named as it is responsible for 1-undecene biosynthesis in Pseudomonas) or Chlorella variabilis FAP resulted in high-yield conversion of thioesterase-liberated FFAs into corresponding alkenes and alkanes, respectively. At best, the engineering resulted in an increase in hydrocarbon accumulation of 8- (from 1 to 8.5 mg/g cell dry weight) and 19-fold (from 4 to 77 mg/g cell dry weight) for Chlamydomonas and Synechocystis, respectively. In conclusion, reconstitution of the eukaryotic algae pathway in the prokaryotic cyanobacteria host generated the most effective system, highlighting opportunities for mix-and-match synthetic metabolism. These studies describe functioning synthetic metabolic pathways for hydrocarbon fuel synthesis in photosynthetic microorganisms for the first time, moving us closer to the commercial implementation of photobiocatalytic systems that directly convert CO into infrastructure-compatible fuels.

The coccolithophore Emiliania huxleyi is a microalga with biogeochemical and biotechnological relevance, due to its high abundance in the ocean and its ability to form intricate calcium carbonate structures. Depletion of macronutrients in oceanic waters is very common and will likely enhance with advancing climate change. We present the first comprehensive metabolome study analyzing the effect of phosphorus (P) and nitrogen (N) starvation on the diploid and haploid life‐cycle stage, applying various metabolome analysis methods to gain new insights in intracellular mechanisms to cope with nutrient starvation. P‐starvation led to an accumulation of many generic and especially N‐rich metabolites, including lipids, osmolytes, and pigments. This suggests that P‐starvation primarily arrests cell‐cycling due to lacking P for nucleic acid synthesis, but that enzymatic functionality is widely preserved. Also, the de‐epoxidation ratio of the xanthophyll cycle was upregulated in the diploid stage under P‐starvation, indicating increased nonphotochemical quenching, a response typically observed under high light stress. In contrast, N‐starvation resulted in a decrease of most central metabolites, also P‐containing ones, especially in the diploid stage, indicating that most enzymatic functionality ceased. The two investigated nutrient starvation conditions caused significantly different responses, contrary to previous assumptions derived from transcriptomic studies. Data highlight that instantaneous biochemical flux is a more dominant driver of the metabolome than the transcriptomically rearranged pathway patterns. Due to the fundamental nature of the observed responses it may be speculated that microalgae with similar nutrient requirements can cope better with P‐starvation than with N‐starvation.

Oleaginous photosynthetic microalgae hold great promise as non-food feedstocks for the sustainable production of bio-commodities. The algal lipid quality can be analysed by Raman micro-spectroscopy, and the lipid content can be imaged in vivo in a label-free and non-destructive manner by coherent anti-Stokes Raman scattering (CARS) microscopy. In this study, both techniques were applied to the oleaginous microalga Monoraphidium neglectum, a biotechnologically promising microalga resistant to commonly applied lipid staining techniques. The lipid-specific CARS signal was successfully separated from the interfering two-photon excited fluorescence of chlorophyll and for the first time, lipid droplet formation during nitrogen starvation could directly be analysed. We found that the neutral lipid content deduced from CARS image analysis strongly correlated with the neutral lipid content measured gravimetrically and furthermore, that the relative degree of unsaturation of fatty acids stored in lipid droplets remained similar. Interestingly, the lipid profile during cellular adaption to nitrogen starvation showed a two-phase characteristic with initially fatty acid recycling and subsequent de novo lipid synthesis. This works demonstrates the potential of quantitative CARS microscopy as a label-free lipid analysis technique for any microalgal species, which is highly relevant for future biotechnological applications and to elucidate the process of microalgal lipid accumulation.

The microalga Botryococcus braunii is widely regarded as a potential renewable and sustainable source for industrial applications because of its capability to produce large amounts of metabolically expensive (exo-) polysaccharides and lipids, notably hydrocarbons. A comprehensive and systematic metabolic characterization of the Botryococcus braunii race A strain CCAP 807/2 was conducted within the present study, including the detailed analysis of growth-associated and physiological parameters. In addition, the intracellular metabolome was profiled for the first time and showed growth- and product-specific fluctuations in response to the different availability of medium resources during the cultivation course. Among the identified metabolites, a constant expression of raffinose was observed for the first time under standard conditions, which has until now only been described for higher plants. Overall, the multilayered analysis during the cultivation of strain CCAP 807/2 allowed the differentiation of four distinct physiological growth phases and revealed differences in the production profiles and content of liquid hydrocarbons and carbohydrates with up to 84% of organic dry weight (oDW). In the process, an enhanced production of carbohydrates with up to 63% of oDW (1.36±0.03 g L-1) could be observed during the late linear growth phase, whereas the highest accumulation of extracellular hydrocarbons with up to 24% of oDW (0.66±0.12 g L-1) occurred mainly during the stationary growth phase. Altogether, the knowledge obtained is potentially useful for the general understanding of the overall physiology of Botryococcus braunii and provide important insights into the growth behavior and product formation of this microalga, and is thus relevant for large scale biofuel production and industrial applications.