Microbiological and kinetic aspects of a biofilter inoculated with a consortium of five bacteria and two yeast adapted to remove toluene vapors were investigated. Initially the toluene sorption isotherm on peat and the effect of different environmental conditions on the toluene consumption rates of this consortium were measured. The fast start‐up of the biofilter and the decay in the elimination capacity (EC) were reproduced using microcosm assays with toluene successive additions. Nutrient limitation and a large degree of heterogeneity were also detected. EC values, extrapolated from microcosms, were higher than biofilter EC when it was operating close to 100% efficiency but tended to relate better as the biofilter EC diminished. In studies on the microbial evolution in the biofilter, an increase in the cell count and variation in the ecology of the consortium were noted. Bacterial counts up to 10 × 1011 cfu/gdry peat were found in 88 days, which corresponds to about a 104 increase from inoculum. Observations with SEM showed a nonuniform biofilm development on the support and the presence of an extracellular material. The results obtained in this work demonstrated that activity measurement in microcosms concomitant to the biofilter operation could be an important tool for understanding, predicting and improving the biofiltration performance. © 1999 John Wiley & Sons, Inc. Biotechnol Bioeng 63: 175–184, 1999.

A bacterial strain identified as Pseudomonas aeruginosa was isolated from a soil consortium able to mineralize pentane. P. aeruginosa could metabolize methyl t-butyl ether (MTBE) in the presence of pentane as the sole carbon and energy source. The carbon balance for this strain, grown on pentane, was established in order to determine the fate of pentane and the growth yield (0.9 g biomass/g pentane). An inhibition model for P. aeruginosa grown on pentane was proposed. Pentane had an inhibitory effect on growth of P. aeruginosa, even at a concentration as low as 85 micrograms/l. This resulted in the calculation of the following kinetic parameters (mumax = 0.19 h-1, Ks = 2.9 micrograms/l, Ki = 3.5 mg/l). Finally a simple model of MTBE degradation was derived in order to predict the quantity of MTBE able to be degraded in batch culture in the presence of pentane. This model depends only on two parameters: the concentrations of pentane and MTBE.

The performance of biofilters inoculated with the fungus Scedosporium apiospermum was evaluated. This fungus was isolated from a biofilter which operated with toluene for more than 6 months. The experiments were performed in a 2.9 L reactor packed with vermiculite or with vermiculite-granular activated carbon as packing material. The initial moisture content of the support and the inlet concentration of toluene were 70% and 6 g/m 3 , respectively. As the pressure drop increased from 5-40 mm H 2 O a strong initial growth was observed. Stable operation was maintained for 20 days with a moisture content of 55% and a biomass of 33 mg biomass/g dry support. These conditions were achieved with intermittent addition of culture medium, which permitted a stable elimination capacity (EC) of 100 g/m 3 reactor h without clogging. Pressure drop across the bed and CO 2 production were related to toluene elimination. Measurement of toluene, at different levels of the biofilter, showed that the system attained higher local EC (200 g/m 3 r h) at the reactor outlet. These conditions were related to local humidity conditions. When the mineral medium was added periodically before the EC decreases, EC of approximately 258 g/m 3 r h were maintained with removal efficiencies of 98%. Under these conditions the average moisture content was 60% and 41 mg biomass/g dry support was produced. No sporulation was observed. Evaluation of bacterial content and activities showed that the toluene elimination was only due to S. apiospermum catabolism.

The effects of successive mixing (homogenization) of packing material (peat), with or without water addition, on the removal of toluene vapors in a biofilter were studied. Over a period of 50 days, an increase in the Elimination Capacity (EC) of approximately 240% was obtained by successive mixing and water additions. After each mixing, a high EC of toluene was maintained only for a short period of 3–4 days. After this time, decreased biofilter performance was observed, probably associated with the development of dried and/or clogged zones. In the long‐term experiments, an attenuation of the EC recovery was observed after successive mixing. In this case, an increase of 110% over 4 months of experiment was obtained. The global reduction of EC over time could be explained by the colonization of the biofilter by filamentous fungi which was facilitated by the mixing of the packing material. The most frequently observed fungi were identified as Scedosporium sp. and Cladosporium sp. © 2000 John Wiley & Sons, Inc. Biotechnol Bioeng 68: 448–455, 2000.