While unfermented grape must contains approximately equal amounts of the two hexoses glucose and fructose, wine producers worldwide often have to contend with high residual fructose levels (>2 gl(-1)) that may account for undesirable sweetness in finished dry wine. Here, we investigate the fermentation kinetics of glucose and fructose and the influence of certain environmental parameters on hexose utilisation by wine yeast. Seventeen Saccharomyces cerevisiae strains, including commercial wine yeast strains, were evaluated in laboratory-scale wine fermentations using natural Colombard grape must that contained similar amounts of glucose and fructose (approximately 110 gl(-1) each). All strains showed preference for glucose, but to varying degrees. The discrepancy between glucose and fructose utilisation increased during the course of fermentation in a strain-dependent manner. We ranked the S. cerevisiae strains according to their rate of increase in GF discrepancy and we showed that this rate of increase is not correlated with the fermentation capacity of the strains. We also investigated the effect of ethanol and nitrogen addition on hexose utilisation during wine fermentation in both natural and synthetic grape must. Addition of ethanol had a stronger inhibitory effect on fructose than on glucose utilisation. Supplementation of must with assimilable nitrogen stimulated fructose utilisation more than glucose utilisation. These results show that the discrepancy between glucose and fructose utilisation during fermentation is not a fixed parameter but is dependent on the inherent properties of the yeast strain and on the external conditions.

The recombinant xylose-utilizing Saccharomyces cerevisiae TMB 3399 was constructed by chromosomal integration of the genes encoding D-xylose reductase (XR), xylitol dehydrogenase (XDH), and xylulokinase (XK). S. cerevisiae TMB 3399 was subjected to chemical mutagenesis with ethyl methanesulfonate and, after enrichment, 33 mutants were selected for improved growth on D-xylose and carbon dioxide formation in Durham tubes. The best-performing mutant was called S. cerevisiae TMB 3400. The novel, recombinant S. cerevisiae strains were compared with Pichia stipitis CBS 6054 through cultivation under aerobic, oxygen-limited, and anaerobic conditions in a defined mineral medium using only D-xylose as carbon and energy source. The mutation led to a more than five-fold increase in maximum specific growth rate, from 0.0255 h(-1) for S. cerevisiae TMB 3399 to 0.14 h(-1) for S. cerevisiae TMB 3400, whereas P. stipitis grew at a maximum specific growth rate of 0.44 h(-1). All yeast strains formed ethanol only under oxygen-limited and anaerobic conditions. The ethanol yields and maximum specific ethanol productivities during oxygen limitation were 0.21, 0.25, and 0.30 g ethanol g xylose(-1) and 0.001, 0.10, and 0.16 g ethanol g biomass(-1) h(-1) for S. cerevisiae TMB 3399, TMB 3400, and P. stipitis CBS 6054, respectively. The xylitol yield under oxygen-limited and anaerobic conditions was two-fold higher for S. cerevisiae TMB 3399 than for TMB 3400, but the glycerol yield was higher for TMB 3400. The specific activity, in U mg protein(-1), was higher for XDH than for XR in both S. cerevisiae TMB 3399 and TMB 3400, while P. stipitis CBS 6054 showed the opposite relation. S. cerevisiae TMB 3400 displayed higher specific XR, XDH and XK activities than TMB 3399. Hence, we have demonstrated that a combination of metabolic engineering and random mutagenesis was successful to generate a superior, xylose-utilizing S. cerevisiae, and uncovered distinctive physiological properties of the mutant.

No abstract

Differences between the recombinant xylose-utilizing Saccharomyces cerevisiae strain TMB 3399 and the mutant strain TMB 3400, derived from TMB 3399 and displaying improved ability to utilize xylose, were investigated by using genome-wide expression analysis, physiological characterization, and biochemical assays. Samples for analysis were withdrawn from chemostat cultures. The characteristics of S. cerevisiae TMB 3399 and TMB 3400 grown on glucose and on a mixture of glucose and xylose, as well as of S. cerevisiae TMB 3400 grown on only xylose, were investigated. The strains were cultivated under chemostat conditions at a dilution rate of 0.1 h ؊1 , with feeds consisting of a defined mineral medium supplemented with 10 g of glucose liter ؊1 , 10 g of glucose plus 10 g of xylose liter ؊1 or, for S. cerevisiae TMB 3400, 20 g of xylose liter ؊1 . S. cerevisiae TMB 3400 consumed 31% more xylose of a feed containing both glucose and xylose than S. cerevisiae TMB 3399. The biomass yields for S. cerevisiae TMB 3400 were 0.46 g of biomass g of consumed carbohydrate ؊1 on glucose and 0.43 g of biomass g of consumed carbohydrate ؊1 on xylose. A K s value of 33 mM for xylose was obtained for S. cerevisiae TMB 3400. In general, the percentage error was <20% between duplicate microarray experiments originating from independent fermentation experiments. Microarray analysis showed higher expression in S. cerevisiae TMB 3400 than in S. cerevisiae TMB 3399 for (i) HXT5, encoding a hexose transporter; (ii) XKS1, encoding xylulokinase, an enzyme involved in one of the initial steps of xylose utilization; and (iii) SOL3, GND1, TAL1, and TKL1, encoding enzymes in the pentose phosphate pathway. In addition, the transcriptional regulators encoded by YCR020C, YBR083W, and YPR199C were expressed differently in the two strains. Xylose utilization was, however, not affected in strains in which YCR020C was overexpressed or deleted. The higher expression of XKS1 in S. cerevisiae TMB 3400 than in TMB 3399 correlated with higher specific xylulokinase activity in the cell extracts. The specific activity of xylose reductase and xylitol dehydrogenase was also higher for S. cerevisiae TMB 3400 than for TMB 3399, both on glucose and on the mixture of glucose and xylose.

The XPR2 gene from Yarrowia lipolytica encodes an inducible alkaline extracellular protease. Its complex regulation involves pH, carbon, nitrogen and peptones. Two previously identified upstream activating sequence (UAS) regions were analysed in a reporter system, outside the XPR2 context. Fragments from the UAS regions were inserted upstream of a minimal LEU2 promoter directing the expression of a reporter gene. The activity of the hybrid promoters was assessed following integration into the Y. lipolyfica genome. This study confirmed the presence of two UASs composed of several interacting elements. Within the distal UAS (UASl), a TUFfRAPl binding site exhibited a UAS activity, which was enhanced by the presence of two adjacent repeats, overlapping sites similar to the CAR1 upstream repressing sequence from Saccharomyces cerewisiae. Within the proximal UAS (UASZ), the UAS activity required the interaction of both an ABF1-like binding site and a decameric repeat, containing Aspergillus nidulans PacC site consensus sequences. This decameric repeat was able to mediate repression due to carbon and/or nitrogen sources as well as pH-dependent activation. A study in the context of frans-regulatory mutations in the Y. /ipo/yfica RIM101 gene showed that the PacC-like sites, potential binding sites for YIRimlOlp, were implicated in the derepression of UASZ-driven expression at neutral-alkaline pH. The in vivo response of the PacC-like decamers to external pH was dependent on the status of the pH-regulated activator YIRimlOlp, which is homologous to the A. nidulans PacC regulator. The carboninitrogen regulation imposed on the decamers was shown to be independent of YlRimlOlp and to override its effects.

There is a growing consumer demand for wines containing lower levels of alcohol and chemical preservatives. The objectives of this study were to express the Aspergillus niger gene encoding a glucose oxidase (GOX; beta- d-glucose:oxygen oxidoreductase, EC 1.1.3.4) in Saccharomyces cerevisiae and to evaluate the transformants for lower alcohol production and inhibition of wine spoilage organisms, such as acetic acid bacteria and lactic acid bacteria, during fermentation. The A. niger structural glucose oxidase (gox) gene was cloned into an integration vector (YIp5) containing the yeast mating pheromone alpha-factor secretion signal (MFalpha1(S)) and the phosphoglycerate-kinase-1 gene promoter (PGK1(P)) and terminator (PGK1(T)). The PGK1(P)- MFalpha1(S)- gox- PGK1(T) cassette (designated GOX1) was introduced into a laboratory strain (Sigma1278) of S. cerevisiae. Yeast transformants were analysed for the production of biologically active glucose oxidase on selective agar plates and in liquid assays. The results indicated that the recombinant glucose oxidase was active and was produced beginning early in the exponential growth phase, leading to a stable level in the stationary phase. The yeast transformants also displayed antimicrobial activity in a plate assay against lactic acid bacteria and acetic acid bacteria. This might be explained by the fact that a final product of the GOX enzymatic reaction is hydrogen peroxide, a known antimicrobial agent. Microvinification with the laboratory yeast transformants resulted in wines containing 1.8-2.0% less alcohol. This was probably due to the production of d-glucono-delta-lactone and gluconic acid from glucose by GOX. These results pave the way for the development of wine yeast starter culture strains for the production of wine with reduced levels of chemical preservatives and alcohol.

We have initiated a study of the promoter region of the alkaline extracellular protease gene (XPR2) from Yarrowia lipolytica to identify upstream sequences possibly involved in carbon, nitrogen, and peptone control ofXPR2 expression. Deletion analysis showed that the TATA box and two major upstream activation sequences (UASs) were essential for promoter activity under conditions of repression or full induction. Within the distal UAS (UAS1), in vivo footprinting studies with dimethyl sulfate (DMS) identified two sequences similar to Saccharomyces cerevisiae GCN4 (-800 to -792)-and TUF/RAP1 (-790 to -778)-binding sites and two sequences which partially overlap a repeated sequence (-778 to -771 and -720 to -713) similar to the CAR] upstream repression sequence of S. cerevisiae. Oligonucleotides carrying the TUF/RAPi-like-binding site and adjacent downstream nucleotides restored full transcriptional activity of a UAS1-deleted promoter. Within the proximal UAS (UAS2), a directly repeated decameric sequence (-146 to -137 and -136 to -127) was protected against DMS in vivo. Sequences identical to the ABF1-binding site of S. cerevisiae (-121 to -109) or similar to the GCN4-binding site (-113 to -105) were not clearly protected from DMS in vivo. An oligomer (-150 to -106) carrying these three sequences, inserted into a UAS2-deleted promoter, increased the transcriptional activity. The results from footprints under different physiological conditions suggested that protein binding to both UASs was constitutive. Deletion of both UASs greatly reducedXPR2 expression without abolishing its regulation. Our results strongly suggest that these UASs are targets for transcriptional factors required for assisting specific regulatory proteins.

Grape juice contains about equal amounts of glucose and fructose, but wine strains of Saccharomyces cerevisiae ferment glucose slightly faster than fructose, leading to fructose concentrations that exceed glucose concentrations in the fermenting must. A high fructose/glucose ratio may contribute to sluggish and stuck fermentations, a major problem in the global wine industry. We evaluated wine yeast strains with different glucose and fructose consumption rates to show that a lower glucose preference correlates with a higher fructose/glucose phosphorylation ratio in cell extracts and a lower K (m) for both sugars. Hxk1 has a threefold higher V (max) with fructose than with glucose, whereas Hxk2 has only a slightly higher V (max) with glucose than with fructose. Overexpression of HXK1 in a laboratory strain of S. cerevisiae (W303-1A) accelerated fructose consumption more than glucose consumption, but overexpression in a wine yeast strain (VIN13) reduced fructose consumption less than glucose consumption. Results with laboratory strains expressing a single kinase showed that total hexokinase activity is inversely correlated with the glucose/fructose (G/F) discrepancy. The latter has been defined as the difference between the rate of glucose and fructose fermentation. We conclude that the G/F discrepancy in wine yeast strains correlates with the kinetic properties of hexokinase-mediated sugar phosphorylation. A higher fructose/glucose phosphorylation ratio and a lower K (m) might serve as markers in selection and breeding of wine yeast strains with a lower tendency for sluggish fructose fermentation.