Beef from retail and foodservice establishments in 11 US cities was evaluated using Warner-Bratzler shear (WBS) and consumer eval uation panels. Postmortem aging times ranged from 3 to 83 d for retail and 7 to 136 d for foodservice with mean aging times of 22.6 d and 30.1 d, respectively. For retail, the three cuts from the round -top round, bottom round, and eye of round -had the highest (P < 0.05) WBS values compared to cuts from the chuck, rib, and loin. Top loin steaks had the lowest (P < 0.05) WBS value compared to ribeye and top sirloin foodservice steaks. Retail bone-in top loin, top loin, ribeye, T-bone, and porterhouse received the highest (P < 0.05) ratings by consumers for overall like and like tenderness. Quality grade had little or no effect on foodservice sensory evalu ations. Improvements in round tenderness are needed to increase consumer acceptability.

The tenderness and palatability of retail and food service beef steaks from across the United States (12 cities for retail, 5 cities for food service) were evaluated using Warner-Bratzler shear (WBS) and consumer sensory panels. Subprimal postfabrication storage or aging times at retail establishments averaged 20.5 d with a range of 1 to 358 d, whereas postfabrication times at the food service level revealed an average time of 28.1 d with a range of 9 to 67 d. Approximately 64% of retail steaks were labeled with a packer/processor or store brand. For retail, top blade had among the lowest (P < 0.05) WBS values, whereas steaks from the round had the greatest (P < 0.05) values. There were no differences (P > 0.05) in WBS values between moist-heat and dry-heat cookery methods for the top round and bottom round steaks or between enhanced (contained salt or phosphate solution) or nonenhanced steaks. Food service top loin and rib eye steaks had the lowest (P < 0.05) WBS values compared with top sirloin steaks. Retail top blade steaks and food service top loin steaks received among the greatest (P < 0.05) consumer sensory panel ratings compared with the other steaks evaluated. Prime food service rib eye steaks received the greatest ratings (P < 0.05) for overall like, like tenderness, tenderness level, like juiciness, and juiciness level, whereas ungraded rib eye steaks received the lowest ratings (P < 0.05) for like tenderness and tenderness level. The WBS values for food service steaks were greater (P < 0.05) for the Select and ungraded groups compared with the Prime, Top Choice, and Low Choice groups. The WBS values and sensory ratings were comparable to the last survey, signifying that no recent or substantive changes in tenderness have occurred.

Crossbred pigs (n = 30) were fed to determine the influence of supplementation with vitamin E on growth and slaughter characteristics of swine and on the quality characteristics of fresh pork. Pigs received either a control diet containing no vitamin E (CON) or a diet formulated to contain 100 mg of vitamin E/kg feed (VITE). During 84 d of feeding, feed intake and weight gain were measured every 2 wk. After the feeding period, pigs were slaughtered and the loin from the left side of each carcass was removed 4 d after death. Alpha-Tocopherol concentration and proximate composition of the longissimus muscle were determined. Loins were sliced into 10-cm sections and stored under vacuum (2 degrees C) for 0, 14, 28, and 56 d. After storage, loins were sliced into 2.54-cm chops, wrapped in polyvinyl chloride film and stored in a retail case (2 to 4 degrees C) for 5 d. Thiobarbituric acid (TBA) values, Hunter L, a, and b values, total plate counts, pH, purge loss, drip loss, cook loss, taste panel characteristics, and visual panel characteristics were evaluated. Growth traits, slaughter characteristics, and proximate composition did not differ (P > .05) between dietary treatment groups. Alpha-Tocopherol concentrations were greater (P < .05) and TBA values during extended retail display were less (P < .05) for VITE chops than for CON chops. Overall palatability ratings were more desirable (P < .05, at 14 d of vacuum storage) for VITE chops than for CON chops. Color measurements, sensory characteristics, total plate counts, pH, purge loss, drip loss, and cook loss were not influenced (P > .05) by vitamin E supplementation. These results indicated that at the tissue alpha-tocopherol concentrations of the present study, vitamin E supplementation of the growing-finishing diet of hogs reduced lipid oxidation in fresh pork but did not influence pork color or tissue drip loss.

The National Beef Quality Audit-2011 (NBQA-2011) was conducted to assess targeted characteristics on the harvest floor that affect the quality and value of cattle, carcasses, and byproducts. Survey teams evaluated approximately 18,000 cattle/carcasses between May and November 2011 in 8 beef processing facilities. Cattle identification methods were lot visual tags (85.7%), individual visual tags (50.6%), electronic tags (20.1%), metal-clip tags (15.7%), other (5.3%), none (2.5%), and wattles (0.5%). Hide colors or breed types were black (61.1%), red (12.8%), yellow (8.7%), Holstein (5.5%), brown (5.0%), gray (5.0%), white (1.4%), and brindle (1.0%). Brand frequencies were none (55.2%), 1 (40.4%), 2 (4.4%), and 3 or more (0.04%) brands, and brands were located on the butt (35.2%), side (9.0%), and shoulder (2.5%). Hide locations of mud or manure were no mud/manure (49.2%), legs (36.8%), belly (23.7%), side (14.9%), top-line (11.0%), and tail region (13.7%). There were 76.2% of cattle without horns, and the majority of those with horns (71.6%) were between 0 cm and 12.7 cm in length. Permanent incisor numbers were zero (87.3%), 1 (1.4%), 2 (8.0%), 3 (0.9%), 4 (1.9%), 5 (0.3%), 6 (0.2%), 7 (0.1%), and 8 (0.02%). Most carcasses (77.0%) were not bruised, 18.7% had 1 bruise, 3.4% had 2 bruises, 0.6% had 3 bruises, and 0.3% had more than 3 bruises. Bruise locations were loin (50.1%), rib (21.3%), chuck (13.8%), round (7.3%), and brisket/flank/plate (7.5%). Condemnation item and incidence were whole carcass (none recorded), liver (20.9%), lungs (17.3%), tongue (10.0%), viscera (9.3%), and head (7.2%). Compared with the NBQA-2005, the NBQA-2011 had an increased percentage of black-hided cattle (56.3 vs. 61.1%), more cattle with brands (38.7 vs. 44.8%), and more cattle with some form of identification (93.3 vs. 97.5%). In addition, there was a lesser percentage of carcasses with bruising in 2011 (23.0%) than in 2005 (35.2%), as well as a smaller percentage of carcasses with more than 1 bruise (2005 = 9.4% vs. 2011 = 4.2%). Compared with the 2005 audit, a similar percentage of the cattle were deemed 30 mo of age or older using dentition (2005 = 2.7% vs. 2011 = 3.3%). The information from NBQA-2011 helps the beef industry measure progress against previous NBQA assessments and provides a benchmark for future educational and research activities.

Studies were conducted to evaluate the efficacy of a commercial blend of sulfuric acid and sodium sulfate (SSS) in reducing Salmonella on inoculated whole chilled chicken wings and to compare its efficacy to peroxyacetic acid (PAA) and cetylpyridinium chloride (CPC). Wings were spot inoculated (5 to 6 log CFU/ml of sample rinsate) with a five-strain mixture of novobiocin- and nalidixic acid-resistant Salmonella and then left untreated (control) or treated by immersing individual wings in 350 ml of antimicrobial solution. An initial study evaluated two treatment immersion times, 10 and 20 s, of SSS (pH 1.1) and compared cell recoveries following rinsing of treated samples with buffered peptone water or Dey/Engley neutralizing broth. In a second study, inoculated wings were treated with SSS (pH 1.1; 20 s), PAA (700 ppm, 20 s), or CPC (4,000 ppm, 10 s) and analyzed for survivors immediately after treatment (0 h) and after 24 h of aerobic storage at 4°C. Color and pH analyses were also conducted in the latter study. Recovery of Salmonella survivors following treatment with SSS (10 or 20 s) was not (P ≥ 0.05) affected by the type of cell recovery rinse solution (buffered peptone water or Dey/Engley neutralizing broth), but there was an effect (P < 0.05) of SSS treatment time. Immersion of samples for 10 or 20 s in SSS resulted in pathogen reductions of 0.8 to 0.9 and 1.1 to 1.2 log CFU/ml, respectively. Results of the second study showed that there was an interaction (P < 0.05) between antimicrobial type and storage time. Efficacy against Salmonella at 0 h increased in the order CPC , SSS , PAA; however, after 24 h of aerobic storage, pathogen counts of SSS- and PAA-treated wings did not differ (P ≥ 0.05). Overall, the results indicated that SSS applied at pH 1.1 for 20 s was an effective antimicrobial intervention to reduce Salmonella contamination on chicken wings.

Two experiments were conducted to evaluate the effectiveness of zilpaterol hydrochloride (ZH) to enhance growth performance and carcass characteristics in calf-fed Holstein steers. In Exp. 1, Holstein steers (n = 2,311) were fed in a large-pen trial in 2 phases at a commercial feed yard in the desert Southwest. In Exp. 2, a total of 359 steers were fed in a small-pen university study. In Exp. 1 and 2, cattle were implanted with a combination trenbolone acetate-estradiol implant approximately 120 d before slaughter. Cattle were fed ZH for 0, 20, 30, or 40 d before slaughter at a rate of 8.3 mg/kg (DM basis). A 3-d withdrawal was maintained immediately before slaughter. Cattle within an experiment were fed to a common number of days on feed. During the last 120 d before slaughter, ADG was not enhanced by feeding ZH for 20 d (P = 0.33 in Exp. 1, and P = 0.79 in Exp. 2). Gain-to-feed conversion was increased by feeding ZH for all durations in Exp. 1 (P < 0.05). Feeding ZH increased HCW by 9.3 (Exp. 2) to 11.6 (Exp. 1) kg at 20 d compared with the control groups. Across both experiments, dressing percent was increased for all durations of feeding ZH (P < 0.05). Although skeletal maturity score, liver integrity, lean color, fat thickness, and KPH were not affected by feeding ZH for 20 d in either experiment (P >or= 0.6), LM area was increased for all durations of feeding ZH (P < 0.05). The percentage of carcasses identified as USDA Choice was reduced (P < 0.01) for all durations of feeding ZH in Exp. 1. This effect was not observed in Exp. 2. Holstein steers clearly respond to the beta-agonist ZH, and 20 d of feeding ZH with a 3-d withdrawal significantly increased carcass weights, muscling, and carcass leanness.

The National Beef Quality Audit (NBQA)-2016 used in-plant cooler assessments to benchmark the current status of the fed steer and heifer beef industry in the United States. In-plant cooler assessments ( = 9,106 carcasses) were conducted at 30 facilities, where approximately 10% of a single day's production were evaluated for USDA quality grade (QG) and yield grade (YG) factors. Frequencies of evaluated traits were 66.5% steer and 33.4% heifer sex classes and 82.9% native, 15.9% dairy-type, and 1.2% estimated breed types. Mean USDA YG factors were 1.42 cm for adjusted fat thickness, 89.5 cm for LM area, 390.3 kg for HCW, and 1.9% for KPH. Mean USDA YG was 3.1, with a frequency distribution of 9.6% YG 1, 36.7% YG 2, 39.2% YG 3, 12.0% YG 4, and 2.5% YG 5. Mean USDA QG traits were Small for marbling score, A for overall maturity, A55 for lean maturity, and A for skeletal maturity. Mean USDA QG was Select with a frequency distribution of QG of 3.8% Prime, 67.3% Choice, 23.2% Select, and 5.6% lower score. Lower score included dark cutter (1.9%), blood splash (0.1%), and hard bone, which are USDA overall maturity scores of C or older (1.8%). Marbling score distributions were 0.85% Slightly Abundant or greater, 7.63% Moderate, 23.54% Modest, 39.63% Small, 23.62% Slight, and 0.83% Traces or less. Carcasses that were Choice or Select and USDA YG 2 or 3 accounted for 70.7% of the carcasses evaluated. Compared with the previous NBQA, we found a numerical increase in mean USDA YG, USDA QG, adjusted fat thickness, HCW, LM area, and marbling score with an increase in dairy-type carcasses and percentage of carcasses grading USDA Prime and Choice as well as frequency of USDA YG 4 and 5. The findings from this study will be used by all segments of the industry to understand and improve the quality of fed steer and heifer beef that is being produced.

The National Beef Quality Audit-2016 (NBQA-2016) was conducted to assess current transportation, mobility, and quality characteristics of U.S. fed steers and heifers. Data were collected at 17 beef processing facilities between March and November 2016. About 8,000 live cattle were evaluated for transportation and mobility, and about 25,000 carcasses were evaluated on the slaughter floor. Cattle were in transit to the slaughter facility for a mean duration of 2.7 h from a mean distance of 218.5 km using trailers with dimensions ranging from 17.84 m2 to 59.09 m2. Area allotted per animal averaged 1.13 m2 and ranged from 0.85 m2 to 2.28 m2. A total of 96.8% of cattle received a mobility score of 1 (walks easily, no apparent lameness). Identification types (35.1% had multiple) were lot visual tags (61.5%), individual tags (55.0%), electronic tags (16.9%), metal-clip tags (9.2%), bar-coded tags (0.05%), wattles (0.01%), and other (2.6%). Cattle were black-hided (57.8%), Holstein (20.4%), red-hided (10.5%), yellow-hided (4.8%), gray-hided (2.9%), brown-hided (1.3%), and white-hided (1.1%). Unbranded hides were observed on 74.3% of cattle; 18.6% had brands located on the butt, 6.3% on the side, and 1.3% on the shoulder (values exceed 100% due to multiple brands). For hide-on carcasses, 37.7% displayed no mud or manure; specific locations for mud or manure were legs (40.8%), belly (33.0%), tail region (15.5%), side (6.8%), and top-line (3.9%). Cattle without horns represented 83.3% of the sample, and cattle that did have horns measured: &lt; 2.54 cm (5.5%), 2.54 to 12.7 cm (8.3%), and &gt; 12.7 cm (2.9%). Carcasses without bruises represented 61.1% of those sampled, whereas 28.2% had 1, 8.2% had 2, 2.1% had 3, and 0.3% had 4 bruises. Of those carcasses with a bruise, the bruise was located on the loin (29.7%), round (27.8%), chuck (16.4%), rib (14.4%), and brisket/plate/flank (11.6%). Frequencies of offal condemnations were livers (30.8%), lungs (18.2%), viscera (16.3%), hearts (11.1%), heads (2.7%), and tongues (2.0%). Compared to NBQA-2011, fewer cattle were identified for traceability, fewer were black-hided, a greater number were Holstein cattle, more with no brand and no horns, fewer without bruises, more liver, lung, and viscera condemnations, and fewer heads and tongues were condemned. The NBQA remains an influential survey for the U.S. beef industry to provide benchmarks and strategic plans for continued improvement of beef quality and consistency.