No abstract

The anammox-based process ELAN ® was started-up in two different sequencing batch reactor (SBR) pilot plant reactors treating municipal anaerobic digester supernatant. The main difference in the operation of both reactors was the dissolved oxygen (DO) concentration in the bulk liquid. SBR-1 was started at a DO value of 0.4 mg O 2 /L whereas SBR-2 was started at DO values of 3.0 mg O 2 /L. Despite both reactors working at a nitrogen removal rate of around 0.6 g N/(L d), in SBR-1, granulesrepresented only a small fraction of the total biomass and reached a diameter of 1.1 mm after 7 months of operation, while in SBR-2 the biomass was mainly composed of granules with an average diameter of 3.2 mm after the same operational period. Oxygen microelectrode profiling revealed that granules from SBR-2 where only fully penetrated by oxygen with DO concentrations of 8 mg O 2 /L while granules from SBR-1 were already oxygen penetrated at DO concentrations of 1 mg O 2 /L. In this way granules from SBR-2 performed better due to the thick layer of ammonia oxidizing bacteria, which accounted for up to 20% of all the microbial populations, which protected the anammox bacteria from non-suitable liquid media conditions.

The effectiveness of low free nitrous acid (FNA) pre-treatment times (PTs) (<8 h) on waste activated sludge (WAS) is not known. This study explores the effectiveness of four different FNA concentrations (0, 2.49, 3.55 and 4.62

The present study was undertaken to investigate the effect of different free nitrous acid (FNA) concentrations at low pre-treatment times (PTs) (1, 2 and 5h) and without pH control with mild agitation on primary sludge (PS) biodegradability and methane production (MP). Increasing PTs resulted in an increase in the solubility of the organic matter (around 25%), but not on cell-mortality (>75% in all the cases with FNA) and neither on methane generation. FNA pre-treatment at low PTs improve MP (around 16% at PT of 1h and 650mg N-NO/L). However, a similar improvement was found with mild agitation of PS without FNA at 2 and 5h. Taking into account the potential costs associated with the FNA pre-treatment, a mild agitation without FNA would be preferred to enhance MP in PS.

No abstract