Ground lignocellulosic biomass (Miscanthus giganteus, pine (Pinus sylvestris) and willow (Salix viminalis)) was pretreated with ionic liquid-water mixtures of 1-butyl-3-methylimidazolium methyl sulfate and 1-butyl-3-methylimidazolium hydrogen sulfate. A solid fraction enriched in cellulose was recovered, which was subjected to enzymatic hydrolysis. Up to 90% of the glucose and 25% of the hemicellulose contained in the original biomass were released by the combined ionic liquid pretreatment and the enzymatic hydrolysis. After the pretreatment, the ionic liquid liquor contained the majority of the lignin and the hemicellulose. The lignin portion was partially precipitated from the liquor upon dilution with water. The amount of hemicellulose monomers in the ionic liquid liquor and their conversion into furfurals was also examined. The performance of ionic liquid-water mixtures containing 1,3-dialkylimidazolium ionic liquids with acetate, methanesulfonate, trifluoromethanesulfonate and chloride anions was investigated. The applicability of the ionic liquid 1-butylimidazolium hydrogensulfate for lignocellulose pretreatment was also examined. It was found that ionic liquid liquors containing methyl sulfate, hydrogen sulfate and methanesulfonate anions were most effective in terms of lignin/cellulose fractionation and enhancement of cellulose digestibility.

The application of the protic ionic liquid 1-butylimidazolium hydrogen sulfate in the deconstruction (aka pretreatment) and fractionation of lignocellulosic biomass has been investigated. A cellulose rich pulp and a lignin fraction were produced. The pulp was subjected to enzymatic saccharification which allowed recovery of up to 90% of the glucan as fermentable glucose. The influence of the solution acidity on the deconstruction of Miscanthus giganteus was examined by varying the 1-butylimidazole to sulfuric acid ratio. Increased acidity led to shorter pretreatment times and resulted in reduced hemicellulose content in the pulp. Addition of water to the ionic liquid resulted in enhanced saccharification yields. The ability to tune acidity through the use of protic ionic liquids offers a significant advantage in flexibility over dialkylimidazolium analogues. † Electronic supplementary information (ESI) available. See

A compositional analysis was performed on Buddleja davidii to determine its general biomass characteristics and provide detailed analysis of the chemical structures of its cellulose and lignin using NMR. B. davidii is a new potential lignocellulosic bioresource for producing bioethanol because it has several attractive agroenergy features. The biomass composition of B. davidii is 30% lignin, 35% cellulose, and 34% hemicellulose. Solid-state CP/MAS (13)C NMR showed that 33% of the cellulose is para-crystalline and 41% is at inaccessible surfaces. Both quantitative (13)C and (31)P NMR were used to examine the structure of lignin. The lignin was determined to be guaiacyl and syringyl with an h:g:s ratio of 0:81:19.

Ethanol organosolv pretreatment was performed on Buddleja davidii to evaluate this bioresource as a potential feedstock for bioethanol production. B. davidii was pretreated and delignified, while 85% of the glucose content of the untreated material was retained in the pretreated solid fraction. The enzymatic hydrolysis showed that organosolv pretreatment produced solid substrates that were readily digestible by cellulases. Gel-permeation chromatography was used to determine the degree of polymerization (DP) of cellulose, and solid-state cross polarization/magic angle spinning 13C NMR experiments were conducted to study the changes in crystallinity and ultrastructure of cellulose. The results showed a decrease in DP along with an increase in the relative proportions of para-crystalline and amorphous cellulose and a decrease in cellulose Iα and Iβ. Removal of lignin and hemicellulose, reduction in DP, and decrease in the crystalline allomorphs (Iα and Iβ) increased the amenability of the biomass to enzymatic degradation.