Ambient storage of dry powdered probiotics is necessary for manufacturer's cost reduction and customer's convenience. Complex coacervation is a promising microencapsulation technique. In this work, a probiotic matrix of type-A gelatin/gum arabic/sucrose (GE/GA/S) with high coacervation pH was designed, based on the alkaline isoelectric point of type-A gelatin. Bacterial survival during ambient storage at room temperature and certain relative humidity were detected. To clarify the protection factors of the coacervation matrix of GE/GA/S, dry microcapsules of GA, GE, GE/sucrose and GE/GA were prepared as controls and compared in terms of their morphology, moisture content, dynamic vapor absorption and cell viability. Probiotics in GE/GA/S microcapsules behaved the best during spray drying, ambient storage and heat treatment. The results proved that sucrose addition was necessary for cell viability against environmental stresses, and that encapsulation by complex coacervation was a positive factor in cell protection, especially at neutral coacervation pH.

For the first time sodium alginate is used to improve the stability of oil body emulsions against salt, pH and freeze–thaw cycling.

BACKGROUND: Rapid dissolution in digestive tract and moisture sorption during ambient storage are the two challenges of dry probiotic preparations. To solve these problems, microcapsules with shellac (LAC) addition containing Limosilactobacillus reuteri TMW 1.656 were designed in this work to provide a good moisture barrier and to provide controlled release in digestive tract, based on the hydrophobicity and acid-resistance of LAC. Four microcapsules were prepared using the method of emulsification/external gelation based on the crosslinking reaction between alginate or LAC with calcium ion, including alginate/ sucrose (ALG), alginate/shellac/sucrose (ALG/LAC), alginate/whey protein isolate/sucrose (ALG/WPI) and alginate/whey protein isolate/shellac/sucrose (ALG/WPI/LAC). RESULTS: Measurements of physical properties showed that microcapsules with LAC addition (ALG/WPI/LAC and ALG/LAC) had larger particle size, much denser structure, lower hygroscopicity and slower solubilization in water, which agreed with the primary microcapsule design. Probiotic survivals in digestive juices followed the order of ALG/WPI/LAC ≥ ALG/WPI ≥ ALG/LAC > ALG. Probiotic stability after heating and ambient storage both exhibited the order of ALG/WPI/LAC > ALG/LAC ≈ ALG/W-PI > ALG, which can be explained by the decreased hygroscopicity with adding LAC. CONCLUSION: LAC addition contributed to better probiotic survivals after freeze drying, simulated digestion, heating and ambient storage, and whey protein isolate (WPI) addition had a synergistic effect. Microcapsule hygroscopicity was closely related with probiotic survivals after heating and ambient storage, while microcapsule solubilization was closely related with probiotic survivals in simulated juices. Within our knowledge, this is the first report to improve probiotic stability during ambient storage based on LAC hydrophobicity.

No abstract