Background: The yeast Xanthophyllomyces dendrorhous synthesizes astaxanthin, a carotenoid with high commercial interest. The proposed biosynthetic route in this organism is isopentenylpyrophosphate (IPP) → geranyleranyl pyrophosphate (GGPP) → phytoene → lycopene → β-carotene → astaxanthin. Recently, it has been published that the conversion of β-carotene into astaxanthin requires only one enzyme, astaxanthin synthase or CrtS, encoded by crtS gene. This enzyme belongs to the cytochrome P450 protein family.

BackgroundThe yeast Xanthophyllomyces dendrorhous is one of the most promising and economically attractive natural sources of astaxanthin. The biosynthesis of this valuable carotenoid is a complex process for which the regulatory mechanisms remain mostly unknown. Several studies have shown a strong correlation between the carbon source present in the medium and the amount of pigments synthesized. Carotenoid production is especially low when high glucose concentrations are used in the medium, while a significant increase is observed with non-fermentable carbon sources. However, the molecular basis of this phenomenon has not been established.ResultsIn this work, we showed that glucose caused transcriptional repression of the three genes involved in the synthesis of astaxanthin from geranylgeranyl pyrophosphate in X. dendrorhous, which correlates with a complete inhibition of pigment synthesis. Strikingly, this regulatory response was completely altered in mutant strains that are incapable of synthesizing astaxanthin. However, we found that addition of ethanol caused the induction of crtYB and crtS gene expression and promoted de novo synthesis of carotenoids. The induction of carotenogenesis was noticeable as early as 24 h after ethanol addition.ConclusionFor the first time, we demonstrated that carbon source-dependent regulation of astaxanthin biosynthesis in X. dendrorhous involves changes at the transcriptional level. Such regulatory mechanism provides an explanation for the strong and early inhibitory effect of glucose on the biosynthesis of this carotenoid.

The cloning and nucleotide sequence of the genes (idi, crtE, crtYB, crtl and crtS) controlling the astaxanthin biosynthesis pathway of the wild-type ATCC 24230 strain of Xanthophyllomyces dendrorhous in their genomic and cDNA version were obtained. The idi, crtE, crtYB, crtl and crtS genes were cloned, as fragments of 10.9, 11.5, 15.8, 5.9 and 4 kb respectively. The nucleotide sequence data analysis indicates that the idi, crtE, crtYB, crtl and crtS genes have 4, 8,4, 11, and 17 introns and 5, 9, 5, 12 and 18 exons respectively. In addition, a highly efficient site-directed mutagenesis system was developed by transformation by integration, followed by mitotic recombination (the double recombinant method). Heterozygote idi (idi+/idi-::hph), crtE (crtE+/crtE-::hph), crtYB (crtYB+/crtYB-::hph), crtI (crtI+/crtI-::hph) and crtS (crtS+/crtS-::hph) and homozygote mutants crtYB (crtYB-::hph/crtYB-::hph), crtI (crtI-::hph/crtI-::hph) and crtS (crtS-::hph/crtS-::hph) were constructed. All the heterozygote mutants have a pale phenotype and produce less carotenoids than the wild-type strain. The genetic analysis of the crtYB, crtl and crtS loci in the wild-type, heterozygote, and homozygote give evidence of the diploid constitution of ATCC 24230 strains. In addition, the cloning of a truncated form of the crtYB that lacks 153 amino acids of the N-terminal region derived from alternatively spliced mRNA was obtained. Their heterologous expression in Escherichia coli carrying the carotenogenic cluster of Erwinia uredovora result in trans-complementation and give evidence of its functionality in this bacterium, maintaining its phytoene synthase activity but not the lycopene cyclase activity.

Xanthophyllomyces dendrorhous is a basidiomycetous yeast of considerable biotechnological interest because it synthesizes astaxanthin as its main carotenoid. The carotenoid production increases when it is grown using nonfermentable compounds as the sole carbon source. This work analyzes the expression of the carotenogenic genes and their relationship with the amount and types of carotenoids produced when X. dendrorhous is grown using a nonfermentable (succinate) or a fermentable carbon source (glucose). When X. dendrorhous is grown in succinate, carotenoid production is approximately three times higher than when it is grown in glucose. Moreover, carotenoid biosynthesis occurs at the start of the growth cycle when X. dendrorhous is grown in succinate, whereas when it is grown in glucose, carotenoids are produced at the end of the exponential phase. Additionally, we observed that some carotenogenic genes, such as alternative transcripts of crtYB and crtI, are differentially expressed when the yeast is grown in these carbon sources; other genes, such as crtS, exhibit a similar pattern of expression. Our data indicate that transcriptional regulation is not sufficient to explain the differences in carotenoid production between the two culture conditions, indicating that additional regulatory mechanisms may be operating in the carotenogenic pathway of X. dendrorhous.

No abstract

The yeast Xanthophyllomyces dendrorhous synthesizes the carotenoid astaxanthin, which has applications in biotechnology because of its antioxidant and pigmentation properties. However, wild-type strains produce too low amounts of carotenoids to be industrially competitive. Considering this background, it is indispensable to understand how the synthesis of astaxanthin is controlled and regulated in this yeast. In this work, the steps leading to the synthesis of the carotenoid precursor geranylgeranyl pyrophosphate (GGPP, C20) in X. dendrorhous from isopentenyl pyrophosphate (IPP, C5) and dimethylallyl pyrophosphate (DMAPP, C5) was characterized. Two prenyl transferase encoding genes, FPS and crtE, were expressed in E. coli. The enzymatic assays using recombinant E. coli protein extracts demonstrated that FPS and crtE encode a farnesyl pyrophosphate (FPP, C15) synthase and a GGPP-synthase, respectively. X. dendrorhous FPP-synthase produces geranyl pyrophosphate (GPP, C10) from IPP and DMAPP and FPP from IPP and GPP, while the X. dendrorhous GGPP-synthase utilizes only FPP and IPP as substrates to produce GGPP. Additionally, the FPS and crtE genes were over-expressed in X. dendrorhous, resulting in an increase of the total carotenoid production. Because the parental strain is diploid, the deletion of one of the alleles of these genes did not affect the total carotenoid production, but the composition was significantly altered. These results suggest that the over-expression of these genes might provoke a higher carbon flux towards carotenogenesis, most likely involving an earlier formation of a carotenogenic enzyme complex. Conversely, the lower carbon flux towards carotenogenesis in the deletion mutants might delay or lead to a partial formation of a carotenogenic enzyme complex, which could explain the accumulation of astaxanthin carotenoid precursors in these mutants. In conclusion, the FPS and the crtE genes represent good candidates to manipulate to favor carotenoid biosynthesis in X. dendrorhous.

No abstract

No abstract