Use of the organic solvent, tri(n-butyl)phosphate (TNBP), and detergents for the inactivation of viruses in labile blood derivatives was evaluated by addition of marker viruses (VSV, Sindbis, Sendai, EMC) to anti-hemophilic factor (AHF) concentrates. The rate of virus inactivation obtained with TNBP plus Tween 80 was superior to that observed with ethyl ether plus Tween 80, a condition previously shown to inactivate greater than or equal to 10(6.9) CID50 of hepatitis B and greater than or equal to 10(4) CID50 of Hutchinson strain non-A, non-B hepatitis. The AHF recovery after TNBP/Tween treatment was greater than or equal to 90 percent. Following the reaction, TNBP could be removed from the protein by gel exclusion chromatography on Sephadex G25; however, because of its large micelle size, Tween 80 could not be removed from protein by this method. Attempts to remove Tween 80 by differential precipitation of protein were only partially successful. An alternate detergent, sodium cholate, when combined with TNBP, resulted in almost as efficient virus inactivation and an 80 percent recovery of AHF. Because sodium cholate forms small micelles, it could be removed by Sephadex G25 chromatography. Electrophoretic examination of TNBP/cholate-treated AHF concentrates revealed few, if any, changes in protein mobility, except for plasma lipoprotein(s).

The thermal inactivation of viruses in labile blood derivatives was evaluated by addition of marker viruses (VSV, Sindbis, Sendai, EMC) to anti-hemophilic factor (AHF) concentrates. The rate of virus inactivation at 60 degrees C was decreased by at least 100- to 700-fold by inclusion of 2.75 M glycine and 50 percent sucrose, or 3.0 M potassium citrate, additives which contribute to retention of protein biologic activity. Nonetheless, at least 10(4) infectious units of each virus was inactivated within 10 hours. Increasing the temperature from 60 to 70 or 80 degrees C caused a 90 percent or greater loss in AHF activity. An even greater decline in the rate of virus inactivation was observed on heating AHF in the lyophilized state, although no loss in AHF activity was observed after 72 hours of heating at 60 degrees C. Several of the proteins present in lyophilized AHF concentrates displayed an altered electrophoretic mobility as a result of exposure to 60 degrees C for 24 hours. Exposure to lyophilized AHF to irradiation from a cobalt 60 source resulted in an acceptable yield of AHF at 1.0, but not at 2.0, megarads. At 1 megarad, greater than or equal to 6.0 logs of VSV and 3.3 logs of Sindbis virus were inactivated.

The red blood cells of blood stored in containers made of polyvinylchloride (PVC) film are osmotically more stable and lose on average about 1/3 less hemoglobin than when blood is stored in another plastic [poly-(ethylene-co-ethyl acrylate); EEA]. The stability of uniform volumes of stored red blood cells varies directly with PVC surface area, whereas changes in EEA surface area have comparatively little or no effect. PVC contains high concentrations of the plasticizer, diethylhexylphthalate (DEHP), known to migrate into blood and to have a high potential for toxicity. To determine if DEHP could be the red cell stabilizing agent in PVC, whole blood was stored in containers made from EEA into which was incorporated varying amounts of DEHP. Incorporation of DEHP into EEA significantly reduced erythrocyte osmotic fragility (p = 0.01). The degree of reduced fragility correlated with the level of DEHP in the cell phase implicating DEHP in PVC containers as the stabilizing agent for red cells.