In the attempt to explore complex bacterial communities of environmental samples, primers hybridizing to phylogenetically highly conserved regions of 16S rRNA genes are widely used, but differential amplification is a recognized problem. The biases associated with preferential amplification of multitemplate PCR were investigated using 'universal' bacteria-specific primers, focusing on the effect of primer mismatch, annealing temperature and PCR cycle number. The distortion of the template-to-product ratio was measured using predefined template mixtures and environmental samples by terminal restriction fragment length polymorphism analysis. When a 1 : 1 genomic DNA template mixture of two strains was used, primer mismatches inherent in the 63F primer presented a serious bias, showing preferential amplification of the template containing the perfectly matching sequence. The extent of the preferential amplification showed an almost exponential relation with increasing annealing temperature from 47 to 61 degrees C. No negative effect of the various annealing temperatures was observed with the 27F primer, with no mismatches with the target sequences. The number of PCR cycles had little influence on the template-to-product ratios. As a result of additional tests on environmental samples, the use of a low annealing temperature is recommended in order to significantly reduce preferential amplification while maintaining the specificity of PCR.

No abstract

Biogas production from sugarcane waste has large potential for energy generation, however, to enable the optimization of the anaerobic digestion (AD) process each substrate characteristic should be carefully evaluated. In this study, the kinetic challenges for biogas production from different types of sugarcane waste were assessed. Samples of vinasse, filter cake, bagasse, and straw were analyzed in terms of total and volatile solids, chemical oxygen demand, macronutrients, trace elements, and nutritional value. Biochemical methane potential assays were performed to evaluate the energy potential of the substrates according to different types of sugarcane plants. Methane yields varied considerably (5–181 Nm3·tonFM−1), mainly due to the different substrate characteristics and sugar and/or ethanol production processes. Therefore, for the optimization of AD on a large-scale, continuous stirred-tank reactor with long hydraulic retention times (>35 days) should be used for biogas production from bagasse and straw, coupled with pre-treatment process to enhance the degradation of the fibrous carbohydrates. Biomass immobilization systems are recommended in case vinasse is used as substrate, due to its low solid content, while filter cake could complement the biogas production from vinasse during the sugarcane offseason, providing a higher utilization of the biogas system during the entire year.

Flexible biogas production that adapts biogas output to energy demand can be regulated by changing feeding regimes. In this study, the effect of changes in feeding intervals on process performance, microbial community structure, and the methanogenesis pathway was investigated. Three different feeding regimes (once daily, every second day, and every 2 h) at the same organic loading rate were studied in continuously stirred tank reactors treating distiller's dried grains with solubles. A larger amount of biogas was produced after feeding in the reactors fed less frequently (once per day and every second day), whereas the amount remained constant in the reactor fed more frequently (every 2 h), indicating the suitability of the former for the flexible production of biogas. Compared to the conventional more frequent feeding regimes, a methane yield that was up to 14% higher and an improved stability of the process against organic overloading were achieved by employing less frequent feeding regimes. The community structures of bacteria and methanogenic archaea were monitored by terminal restriction fragment length polymorphism (T-RFLP) analysis of 16S rRNA and mcrA genes, respectively. The results showed that the composition of the bacterial community varied under the different feeding regimes, and the observed T-RFLP patterns were best explained by the differences in the total ammonia nitrogen concentrations, H 2 levels, and pH values. However, the methanogenic community remained stable under all feeding regimes, with the dominance of the Methanosarcina genus followed by that of the Methanobacterium genus. Stable isotope analysis showed that the average amount of methane produced during each feeding event by acetoclastic and hydrogenotrophic methanogenesis was not influenced by the three different feeding regimes.I nterest in a demand-driven biogas supply for flexible electricity production with the aim of balancing the supply of electricity generated from sources producing fluctuating amounts of electricity, such as solar and wind sources, has increased recently. Different strategies can be employed to obtain a demand-driven biogas supply, including a strategy involving a conventional biogas plant with biogas storage or a strategy involving a conventional biogas plant with a biogas upgrade to biomethane for subsequent storage in a natural gas grid (1-3). Conventional biogas production with integrated heat and power (CHP) plants are normally run on a semicontinuous substrate feeding regime in order to provide a constant biogas output and electricity generation (4).Alternatively, flexible biogas production that adapts biogas output to energy demand can be implemented by feeding management, including varying the feeding regimes and substrate composition. The production of larger amounts of biogas can be achieved immediately after feeding, and smaller amounts of biogas production are achieved during the nonfeeding period. Compared to the conventional operation of biogas plants with biogas storage, flexible biogas produc...

No abstract

No abstract

A Dehalococcoides-dominated culture coupling reductive dechlorination of tetrachloroethene (PCE) to ethene to growth was enriched from a European field site for the first time. Microcosms were set up using groundwater from a chlorinated ethene-contaminated anaerobic aquifer in Bitterfeld (Germany). Active, lactate-amended microcosms capable of PCE dechlorination to ethene without the accumulation of intermediates were used for further enrichment. After three transfers on lactate as an electron donor and PCE as an electron acceptor, the enrichment was transferred to parallel cultures with one of the chlorinated ethenes as an electron acceptor and acetate and hydrogen as the carbon and energy source, respectively. After three more transfers, a highly purified culture was derived that was capable of dechlorinating PCE with hydrogen and acetate as the electron donor and carbon source, respectively. PCR, followed by denaturing gradient gel electrophoresis, cloning and sequencing revealed that this culture was dominated by a Dehalococcoides sp. belonging to the Pinellas group. Investigation of substrate specificity in the parallel cultures suggested the presence of a novel Dehalococcoides that can couple all dechlorination steps, from PCE to ethene, to energy conservation. Quantitative real-time PCR confirmed growth with PCE, cis-dichloroethene, 1,1-dichloroethene or vinyl chloride as electron acceptors. The culture was designated BTF08 due to its origin in Bitterfeld.

Laboratory biogas reactors were operated under various conditions using maize silage, chicken manure, or distillers grains as substrate. In addition to the standard process parameters, the hydrogen and carbon stable isotopic composition of biogas was analyzed to estimate the predominant methanogenic pathways as a potential process control tool. The isotopic fingerprinting technique was evaluated by parallel analysis of mcrA genes and their transcripts to study the diversity and activity of methanogens. The dominant hydrogenotrophs were Methanomicrobiales, while aceticlastic methanogens were represented by Methanosaeta and Methanosarcina at low and high organic loading rates, respectively. Major changes in the relative abundance of mcrA transcripts were observed compared to the results obtained from DNA level. In agreement with the molecular results, the isotope data suggested the predominance of the hydrogenotrophic pathway in one reactor fed with chicken manure, while both pathways were important in the other reactors. Short-term changes in the isotopic composition were followed, and a significant change in isotope values was observed after feeding a reactor digesting maize silage. This ability of stable isotope fingerprinting to follow short-term activity changes shows potential for indicating process failures and makes it a promising technology for process control.