A novel dairy product, namely “chocolate cheese”, was produced with two typical Sicilian food products: Pecorino cheese, processed from ewe's milk, and Modica chocolate. The cheese, manufactured with 0%, 5%, 10%, and 15% (w/w) solid or molten chocolate, was evaluated after 0, 2, 4, and 6 weeks of vacuum storage for its nutritional and health properties. The addition of chocolate reduced the pH, protein, fat, and ash; the addition of 5% or 10% molten chocolate reduced hardness (N/mm2). The addition of either solid or molten chocolate resulted in a slight increase (P < 0.1038) in the total polyphenol content, a higher oleic acid content, and less oxidative stability. The microbiological profile showed that the total mesophilic count and the number of mesophilic coccus lactic acid bacteria (LAB) were approximately equal (about 108 CFU/g) in all cheese. The survival of the microorganisms was affected by both the chocolate added and the storage time. Chocolate cheese stored for 6 weeks had less Enterobacteriaceae than control cheese, whereas yeasts were detected at higher cell densities in the former cheese. Filamentous fungi were undetectable in some cheese. Differences were also observed in the number of mesophilic rod LAB, which increased progressively over time in all cheese, and in Enterobacteriaceae, yeasts, and filamentous fungi, which decreased during storage. Descriptive and hedonic sensory tests and principal component analysis showed that fresh cheese and cheese stored for 2 weeks, including 5% molten chocolate, were the most preferred by evaluators. Based on these results, chocolate cheese has the potential to be appreciated in the market for its nutritional, health, and sensory properties. Practical Application Chocolate cheese, made by combining two typical Sicilian foods, Pecorino cheese and Modica chocolate, is proposed as a novel dairy product. The highest sensory acceptance was obtained with the addition of 5% molten chocolate and storage for 2 weeks. Given its improved antioxidant properties, healthier fat, and sensory properties, chocolate cheese has the potential to be appreciated in the market, especially by young consumers.
The aim of the present investigation was to explore the possibility of developing a fruit snack formulation based on dried fig powder and chocolate-coated. Dried Fig ( Ficus carica L .) powder with a maximum particle size of 354 μm and the lowest compaction force was formulated as the core. Persian gum was prepared at the concentrations of 1.5, 2 and 2.5% and xanthan gum was prepared at the levels of 0.25, 0.39 and 0.54% as the middle layer to the coating of the core. Regarding rheological assessments, sugar-free chocolate containing 29.3% isomalt was selected for the coating of the outer chocolate shell in the entitled snack. Textural analysis showed that coating of the core with hydrocolloids decreased hardness and adhesiveness of the samples ( p < 0.05). It was also observed that increasing the xanthan gum and Persian gum concentration led to the reduction of adhesiveness in the snacks ( p < 0.05). Coating of cores with hydrocolloids resulted in lower thickness of the chocolate outer shell, as well ( p < 0.05). Results of the sensory evaluation tests demonstrated that, the samples with hydrocolloid coating were the most preferred ones by the panelists.
Sulla is a tanniferous legume species largely used as fresh or preserved forage in the ruminants’ diets. Due to its content in polyphenols with antioxidant activity, especially condensed tannins (CT), fresh sulla forage (FSF), when eaten by ruminants, is able to enrich animal products with antioxidant molecules and polyunsaturated fatty acids (PUFA) that are beneficial for consumers’ health. Dehydration represents a valid alternative to haymaking to preserve these properties also in periods when FSF is unavailable. In this research, the effects of ewes’ diets based on sulla hay (SH), pelleted dehydrated sulla forage (DSF) or FSF were evaluated on cheese physico-chemical traits, including fatty acid (FA) profile, vitamins A and E, polyphenols, antioxidant capacity and oxidative stability. The individual daily milk from 10 first lambing (FL) and 10 third lambing (TL) Valle del Belìce ewes at about 60 days in milk, divided homogeneously into 5 groups fed different diets in a partial 5 × 2 Latin square design with 2 phases, and the bulk milk of farming ewes fed only on natural pasture, were used in 2 sessions of micro cheese-making to manufacture cheeses, sampled at 48 h of ripening. The experimental diets were: SHL = SH ad libitum; DSF2 = 2 kg/day DSF per head plus SH ad libitum; FSF2 = 2 kg/day FSF per head plus SH ad libitum; FSF4 = 4 kg/day FSF per head plus SH ad libitum; FSFL = FSF ad libitum. Concentrate was supplied at the amount of 0.8 or 1.2 kg/day per head for FL and TL, respectively. Cheese health properties greatly improved with FSFL diet, based on the exclusive use of fresh forage, that induced the increase in the content of molecules with antioxidant activity, as vitamin A, vitamin E and polyphenols, enhancing the oxidative stability, and the level of PUFA as rumenic acid (C18:2 c9t11) and α-linolenic acid (ALA, C18:3n-3). Cheeses from the DSF2 group showed levels of vitamin A, vitamin E and PUFA higher than SHL cheeses and comparable to those of FSF4 cheeses, whereas their ALA content was not different from that of FSFL cheeses. Evaluating those molecules affected by the level of fresh forage in the diet for their ability to trace the animals’ feeding regime, ALA and its ratio with linoleic acid (LA, C18:2n-6) (LA/ALA) exhibited an effective role as biomarker in discriminating cheese from animals fed fresh forage-based diets. The results showed how dehydrated sulla pellets, as an alternative to hay in periods of limited availability of fresh forage, can preserve the nutritional and health properties of dairy products with regards to their antioxidant capacity and FA profile.
Simple SummaryThe sheep meat sector in southern Italy, based mainly on light milk-fed lambs, requires technical innovations to improve the production system, the product quality, and enhance the consumption of lamb meat. To fulfill these requirements, this investigation aimed to implement feeding strategies to reduce the cost and energy level of diets for dairy breed lambs slaughtered at an older age than the light lambs, applying a feed restriction at 75% and/or including an inexpensive and local byproduct, such as durum wheat bran (DWB), as a fiber source. The proposed feeding plans were suitable to increase the slaughter age of lambs up to 120 days and produce lean carcasses that, compared to those from 90-day-old lambs, were heavier and with improved meat quality in terms of major water retention and tenderness. The dietary inclusion of DWB limited the fat content and improved the health properties of lamb meat with regard to its antioxidant capacity and fatty acid profile, whereas it reduced lambs’ growth when associated with feed restriction.AbstractThis experiment aimed to investigate the possibility to increase the carcass weight of dairy breed lambs and produce moderate-fat meat by applying inexpensive feeding strategies based on restriction and through the use of a fibrous byproduct such as the durum wheat bran (DWB). Sixty-five 45-day-old lambs of the Valle del Belice breed, divided into 6 groups, were fed alfalfa hay supplemented with concentrate feeds including DWB at 0% or 20% (DWB0, DWB20), supplied ad libitum (L) or restricted at 75% (R), and slaughtered at 90 or 120 days of age. The groups were as follows: DWB0-90L (n = 14), DWB20-90L (n = 14), DWB0-120R (n = 10), DWB20-120R (n = 9), DWB0-120L (n = 9), DWB20-120L (n = 9). The diet did not affect feed intake, growth or carcass weight of lambs fed ad libitum, whereas 120-day-old lambs fed DWB associated to restriction showed the lowest weight gain (105 vs. 170, 185 and 190 g/day in DWD20-120R, DWB0-120R, DWB0-120L and DWB20-120L; p = 0.04). The incidence of fat tissue in the hind leg increased (p < 0.0001) from 90L (5.82 and 5.45% with DWB0 and DWB20) to 120R (8.80 and 8.43% with DWB0 and DWB20) and 120L lambs (10.7 and 11.8% with DWB0 and DWB20). Older lambs’ meat, compared to that of 90L lambs, showed analogous levels of intramuscular fat, higher water retention, tenderness and lightness, and a more intense red colour. In meat from 120-day-old lambs, DWB intake tended to reduce the fat level (p = 0.009) and increased polyphenol content (1.10 vs. 1.62, and 1.02 vs. 1.65 g GAE/kg dry matter (DM) in 120R and 120L lambs; p = 0.02), antioxidant capacity (12.8 vs. 14.9, and 12.8 vs. 15.7 mmol trolox eq/kg DM in 120R and 120L lambs; p = 0.02), and the presence of n-3 polyunsaturated fatty acids (FA) (1.61 vs. 2.81, and 1.43 vs. 2.61 g/100 g FA in 120R and 120L lambs; p = 0.007), thereby improving the meat’s health properties. The panelists perceived the effects of DWB inclusion as well as the feeding level with triangle tests.
scite is a Brooklyn-based organization that helps researchers better discover and understand research articles through Smart Citations–citations that display the context of the citation and describe whether the article provides supporting or contrasting evidence. scite is used by students and researchers from around the world and is funded in part by the National Science Foundation and the National Institute on Drug Abuse of the National Institutes of Health.
hi@scite.ai
10624 S. Eastern Ave., Ste. A-614
Henderson, NV 89052, USA
Copyright © 2024 scite LLC. All rights reserved.
Made with 💙 for researchers
Part of the Research Solutions Family.