Meat safety and hygiene are fundamental issues for producers and endusers. To achieve these goals, the inspection of carcasses and organs at slaughter is critical. The results of post-mortem inspection are the basis for planning preventive measures against consumer risks and for limiting economic losses. In this retrospective study, the causes of the seizure and destruction of carcasses and organs were analysed at a slaughterhouse in central Italy from 2010 to 2016. 436,646 slaughtered animals were taken into consideration, for a total of 61,799 seizures (73.29% pigs, 23.87% cattle, 2.77% sheep and 0.07% horses). The organs or groups of organs that most frequently showed lesions in pigs were liver (72.38%), heart (10.77%) and pluck (10.20%); in cattle, lungs (64.86%), liver (31.20%) and stomachs (11.63%); in sheep, liver (77.15%), pluck (18.70%) and lung (3.80%); in horses, liver (75.56%), kidney (68.89%) and lung (31.11%). Among the diagnoses, parasitic diseases of the liver (ascariasis and distomatosis) were especially frequent in all species, followed by pericarditis and polyserositis in pigs and diseases affecting the respiratory system in cattle. The data obtained show that postmortem inspection is of fundamental importance for limiting risks for the consumer and ensuring meat safety. It is also evident, even more than ten years after the coming into force of the so-called hygiene package regulations, that the slaughterhouse can still act as an epidemiological observatory to provide the data needed for the development of plans for the control and eradication of the most frequent diseases in the area.
Currently, there is an increasing interest to valorise agri-food waste containing bioactive compounds with potential health benefits. In this paper, the recovery of functional molecules from apple pomace, the most abundant by-product of the apple processing industry, was carried out by ultrasound-assisted extraction (UAE) on fresh and freeze-dried samples. UAE extract, obtained by double extraction of freeze-dried apple pomace, was subjected to chromatographic and spectrophotometric characterization. It showed good levels of total phenol content, high antioxidant activity, and interesting antioxidant compounds (quercetin derivatives, chlorogenic acid, phloridzin). Subsequently, freeze-dried apple pomace, containing 40.19% of dietary fibre, was used as a fortifying agent for beef burgers (4% and 8%). The results concerning colour and sensory analysis of the fortified products were graded even better than the control (0%). The improved fibre and phenol content, together with the neutral flavour, represent the most interesting characteristics of fortified burgers. The results confirm that UAE was a successful technique for extracting phenol compounds and that the addition of apple pomace represents a valid approach to increase the health properties and palatability of beef burgers, including for consumers who do not like meat.
Staphylococcus aureus is not only a common cause of bovine mastitis, but also an agent of food poisoning in humans. In an attempt to determine whether staphylococci causing bovine mastitis could also cause food poisoning, 60 isolates of presumed S. aureus were isolated in the period between March and August 2017 from 3,384 routine, composite, quarter milk samples of individual cows raised on 12 dairy farms in central Italy. Seventeen out of 60 isolates were confirmed as S. aureus after coagulase, thermonuclease, and biochemical tests. These isolates were analyzed by PCR for the presence of the nuc, sea, seb, sec, sed, and see genes. The positive isolates were nuc, 100% (17); sea, 35.29% (6); seb, 5.88% (1); sec, 5.88% (1); sed, 29.41% (5); and see, 47.06% (8). The isolates were also tested with 2 enzyme immunoassay diagnostic kits, one for the screening detection of the production of staphylococcal enterotoxins (SEA, SEB, SEC, SED, SEE) and one for the detection of specific enterotoxin produced by each isolate. Seven out of 17 (41.18%) were enterotoxin producers: 7 produced SEA (41.18%), 1 SEB (5.88%), 1 SEC (5.88%), 5 SED (29.41%), and 6 SEE (35.29%). To further characterize the isolates, they were analyzed by the Kirby Bauer test for susceptibility to 13 antimicrobials (ampicillin, ciprofloxacin, kanamycin, tetracycline, gentamicin, methicillin, nalidixic acid, erythromycin, amoxicillin/ clavulanic acid, streptomycin, vancomycin, neomycin, and enrofloxacin), and we detected resistance to ampicillin (52.94%), nalidixic acid (70.59%), erythromycin (5.88%), and amoxicillin/clavulanic acid (17.65%). The isolates were sensitive to the main classes of antimi-crobials used for the treatment of bovine subclinical mastitis. The presence of enterotoxin-producing isolates of S. aureus in bovine milk means that a temperature abuse or a breakdown in the thermal treatment of the milk could present a food safety risk, particularly if all enterotoxigenic isolates could potentially produce SEA in milk.
Possible contamination by Staphylococcus aureus of the production environment and of the meat of a canned meat production factory was analysed. A total of 108 samples were taken from nine critical control points, 13 of them were positive for S. aureus. None of the isolates produced enterotoxins. To determine how much time can elapse between can seaming and sterilisation in the autoclave without any risk of enterotoxin production by S. aureus, the growth and enterotoxin production of three enterotoxin A producing strains of S. aureus (one ATCC strain and two field strains) in canned meat before sterilisation was investigated at three different temperatures (37, 20 and 10 °C). Two types of meat were used, one with and one without sodium nitrite. In the canned products, the spiked bacteria spread throughout the meat and reached high levels. Enterotoxin production was shown to start 10 hours after incubation at 37 °C and after 48 h after incubation at 20 °C; the production of enterotoxin was always detected in the transition between the exponential and the stationary growth phase. At 10 °C, the enterotoxin was never detected. The statistical analysis of the data showed that the difference between the two different types of meat was not statistically significant (p value > 0.05). Since it is well known that following heat treatment, staphylococcal enterotoxins, although still active (in in vivo assays), can be undetectable (loss of serological recognition) depending on the food matrix and pH, it is quite difficult to foresee the impact of heat treatment on enterotoxin activity. Therefore, although the bacteria are eliminated, the toxins may remain and cause food poisoning. The significance of the results of this study towards implementing good manufacturing practices and hazard analysis critical control points in a canned meat factory are discussed with reference to the management of pre-retorting steps after seaming.
The CoViD-19 pandemic has caused a sudden spike in demand and production of hand sanitisers. Concerns are rising regarding the quality of such products, as the safeguard of consumers is a priority worldwide. We analyse here the ethanolic content of seven off-the-shelf hand sanitiser gels (two biocides and five cosmetics) from the Italian market, using gas chromatography. The WHO recommends that products containing ethanol should have 60-95% (v/v) alcohol. Four of the tested hand gels have ethanolic contents within the recommended range, while three products (all cosmetics) contain < 60% (v/v), i.e. 52.1% (w/w), ethanol. The product with the lowest alcoholic content has 37.1% w/w ethanol. Toxic methanol is not found in any of the hand sanitisers. We show, in addition, that products with the highest ethanolic content have generally greater antibacterial activity. In conclusion, all tested products are complying with the EU regulations, as the three "substandard" products are classified as cosmetics, whose purpose is cleaning and not disinfecting. Nevertheless, if such hand cleaners were inappropriately used as hand disinfectants, they might be ineffective. Thus, consumer safety relays on awareness and ability to distinguish between biocidal and cosmetics hand gels. The obtained results might sensitise the scientific community, health agencies and ultimately consumers towards the risks of using hand sanitisers of substandard alcoholic concentration. If the wrong product is chosen by consumers, public health can be compromised by the inappropriate use of "low-dosed" cosmetic gels as disinfectants, particularly during the period of the CoViD-19 pandemic.
The term ‘packaging’ refers to the technological intervention aimed at the protection of food from a variety of factors, which provokes the product detriment. Packaging is considered as one of the most interesting technological aspects and a constantly evolving issue in food production. This paper aims at the evaluation of the properties of packaging currently used in the meat industry and analyses the advantages, the disadvantages and the microbiota involved. Packaging is a coordinated system, which prepares the products for transportation, distribution, storage, marketing and consumption. Even if several packaging alternatives are proposed, the common purpose is to guarantee high standards, yet maintaining the required characteristics as long as possible. Meat is a dynamic system with a limited shelf-life and the nutritional and sensory properties may change during storage due to microbial activity and physical or chemical changes. Microbial spoilage, for instance, determines an impact in meat, producing unattractive odours, flavours, discolouration, gas and slime.
Listeria monocytogenes has been referred to as a concern microorganism in cheese making due to its ability to survive and grow in a wide range of environmental conditions, such as refrigeration temperatures, low pH and high salt concentration at the end of the production process. Since cheese may be a potential hazard for consumers, especially high-risk consumers (e.g., pregnant, young children, the elderly, people with medical conditions), efforts of the dairy industry have been aimed at investigating new conservation techniques based on natural additives to meet consumers’ demands on less processed foods without compromising the food safety. Thus, the aim of this study was to evaluate the efficacy of Myrtus communis L. (myrtle) and Rosmarinus officinalis L. (rosemary) essential oils (EO) against Listeria monocytogenes ATCC 679 spiked in sheep cheese before ripening. After the cheesemaking process, the samples were stored at 8 °C for 2 h, 1 d, 3 d, 14 d and 28 d. The composition of EO was identified by gas chromatography-mass spectrometry (GC-MS) analysis. Constituents such as 1,8-cineole, limonene, methyl-eugenol, α-pinene, α-terpineol, α-terpinolene and β-pinene were present in both EO, accounting for 44.61% and 39.76% from the total of chemical compounds identified for myrtle and rosemary EO, respectively. According to the chemical classification, both EO were mainly composed of monoterpenes. Minimum inhibitory concentration (MIC) against L. monocytogenes was obtained at 31.25 μL/mL to myrtle EO and at 0.40 μL/mL to rosemary EO. Then, cheeses were inoculated with L. monocytogenes (Ca. 6 log CFU/mL) and EO was added at MIC value. The addition of rosemary and myrtle EO displayed lower counts of L. monocytogenes (p < 0.01) (about 1–2 log CFU/g) during the ripening period compared to control samples. Ripening only influences (p < 0.001) the growth of L. monocytogenes in control samples. Since rosemary and myrtle EO do not exert any negative impact on the growth of native microflora (p > 0.05), their use as natural antimicrobial additives in cheese demonstrated a potential for dairy processors to assure safety against L. monocytogenes.
scite is a Brooklyn-based organization that helps researchers better discover and understand research articles through Smart Citations–citations that display the context of the citation and describe whether the article provides supporting or contrasting evidence. scite is used by students and researchers from around the world and is funded in part by the National Science Foundation and the National Institute on Drug Abuse of the National Institutes of Health.
hi@scite.ai
10624 S. Eastern Ave., Ste. A-614
Henderson, NV 89052, USA
Copyright © 2024 scite LLC. All rights reserved.
Made with 💙 for researchers
Part of the Research Solutions Family.