The currently available commercial human anthrax vaccine requires multiple injections for efficacy and has side effects due to its alum adjuvant. These factors limit its utility when immunizing exposed populations in emergent situations. We evaluated a novel mucosal adjuvant that consists of a nontoxic, water-in-oil nanoemulsion (NE). This material does not contain a proinflammatory component but penetrates mucosal surfaces to load antigens into dendritic cells. Mice and guinea pigs were intranasally immunized with recombinant Bacillus anthracis protective antigen (rPA) mixed in NE as an adjuvant. rPA-NE immunization was effective in inducing both serum anti-PA immunoglobulin G (IgG) and bronchial anti-PA IgA and IgG antibodies after either one or two mucosal administrations. Serum anti-PA IgG2a and IgG2b antibodies and PA-specific cytokine induction after immunization indicate a Th1-polarized immune response. rPA-NE immunization also produced high titers of lethal-toxin-neutralizing serum antibodies in both mice and guinea pigs. Guinea pigs nasally immunized with rPA-NE vaccine were protected against an intradermal challenge with ϳ1,000 times the 50% lethal dose (ϳ1,000؋ LD 50 ) of B. anthracis Ames strain spores (1.38 ؋ 10 3 spores), which killed control animals within 96 h. Nasal immunization also resulted in 70% and 40% survival rates against intranasal challenge with 10؋ LD 50 and 100؋ LD 50 (1.2 ؋ 10 6 and 1.2 ؋ 10 7 ) Ames strain spores. Our results indicate that NE can effectively adjuvant rPA for intranasal immunization. This potentially could lead to a needle-free anthrax vaccine requiring fewer doses and having fewer side effects than the currently available human vaccine.

Dutch-belted and New Zealand White rabbits were passively immunized with AVP-21D9, a human monoclonal antibody to protective antigen (PA), at the time of Bacillus anthracis spore challenge using either nasal instillation or aerosol challenge techniques. AVP-21D9 (10 mg/kg) completely protected both rabbit strains against lethal infection with Bacillus anthracis Ames spores, regardless of the inoculation method. Further, all but one of the passively immunized animals (23/24) were completely resistant to rechallenge with spores by either respiratory challenge method at 5 weeks after primary challenge. Analysis of the sera at 5 weeks after primary challenge showed that residual human anti-PA levels decreased by 85 to 95%, but low titers of rabbit-specific anti-PA titers were also measured. Both sources of anti-PA could have contributed to protection from rechallenge. In a subsequent study, bacteriological and histopathology analyses revealed that B. anthracis

Bacillus anthracis is the causative agent of anthrax. We have developed a novel whole-bacterial-cell anthrax vaccine utilizing B. anthracis that is killed but metabolically active (KBMA). Vaccine strains that are asporogenic and nucleotide excision repair deficient were engineered by deleting the spoIIE and uvrAB genes, rendering B. anthracis extremely sensitive to photochemical inactivation with S-59 psoralen and UV light. We also introduced point mutations into the lef and cya genes, which allowed inactive but immunogenic toxins to be produced. Photochemically inactivated vaccine strains maintained a high degree of metabolic activity and secreted protective antigen (PA), lethal factor, and edema factor. KBMA B. anthracis vaccines were avirulent in mice and induced less injection site inflammation than recombinant PA adsorbed to aluminum hydroxide gel. KBMA B. anthracis-vaccinated animals produced antibodies against numerous anthrax antigens, including high levels of anti-PA and toxin-neutralizing antibodies. Vaccination with KBMA B. anthracis fully protected mice against challenge with lethal doses of toxinogenic unencapsulated Sterne 7702 spores and rabbits against challenge with lethal pneumonic doses of fully virulent Ames strain spores. Guinea pigs vaccinated with KBMA B. anthracis were partially protected against lethal Ames spore challenge, which was comparable to vaccination with the licensed vaccine anthrax vaccine adsorbed. These data demonstrate that KBMA anthrax vaccines are well tolerated and elicit potent protective immune responses. The use of KBMA vaccines may be broadly applicable to bacterial pathogens, especially those for which the correlates of protective immunity are unknown.

Several pathogenic bacteria produce adenylyl cyclase toxins, such as the edema factor (EF) of Bacillus anthracis. These disturb cellular metabolism by catalyzing production of excessive amounts of the regulatory molecule cAMP. Here, a structure-based method, where a 3D-pharmacophore that fit the active site of EF was constructed from fragments, was used to identify non-nucleotide inhibitors of EF. A library of small molecule fragments was docked to the EF-active site in existing crystal structures and those with the highest HINT scores were assembled into a 3D-pharmacophore. About 10,000 compounds, from over 2.7 million compounds in the ZINC database, had a similar molecular framework. These were ranked according to their docking scores, using methodology that was shown to achieve maximum accuracy (i.e., how well the docked position matched the experimentally determined site for ATP analogues in crystal structures of the complex). Finally, 19 diverse compounds with the best AutoDock binding/docking scores were assayed in a cell based assay for their ability to reduce cAMP secretion induced by EF. Four of the test compounds, from different structural groups, inhibited in the low micromolar range. One of these has a core structure common to phosphatase inhibitors previously identified by high-throughput assays of a diversity library. Thus, the fragment based pharmacophore identified a small number of diverse compounds for assay, and greatly enhanced the selection process of advanced lead compounds for combinatorial design.

Human thrombin has been shown to stimulate monocyte chemotaxis, phagocytosis, and interleukin (IL8) production, but the mechanisms responsible for stimulation are not well defined. In some cells, thrombin stimulation of proliferation appears to require both cleavage of the proteolytically activated receptor for thrombin (PAR1) and activation of a nonproteolytically activated thrombin receptor (N-PAR), while in others activation of either receptor alone may be sufficient for stimulation. We, therefore, have initiated studies to address thrombin receptor expression and cell responsiveness to thrombin in interferon gamma (IFNgamma)-differentiated and nondifferentiated U937 monocytic cells. Northern blot analysis shows that PAR1 expression is upregulated upon differentiation. Experiments with biotinylated and 125I-thrombin show that specific thrombin binding is dramatically increased by differentiation although it is not clear if this binding is to PAR1 or to a separate binding component such as N-PAR which is present on fibroblasts and other cells. Addition of thrombin at concentrations of 1-10 microg/ml (30-300 nM, concentrations where specific thrombin binding is observed) stimulates proliferation of IFNgamma-differentiated U937 cells but not of undifferentiated U937 cells. Thrombin also stimulates interleukin-6 (IL6) production in IFNgamma-differentiated U937 cells. Moreover, thrombin induces high levels of IL6, interleukin-1beta (IL1beta), and tumor necrosis factor-alpha (TNF alpha) production by peripheral blood mononuclear cells (PBMC) and monocytes. These results show that differentiated U937 cells and mature PBMC are responsive to thrombin whereas nondifferentiated U937 are not. Further, this responsiveness appears to correlate with expression of PAR1 and to a dramatic increase in specific thrombin binding. That thrombin stimulates cytokine production and proliferation in populations of differentiated monocytes suggests that thrombin may be an important regulator of inflammation and wound healing.