Nutrient Removal by Algae Grown in CO 2 -Enriched Wastewater over a Range of Nitrogen-to-Phosphorus Ratios Laura FultonIn conventional wastewater treatment, biological nutrient removal (BNR) depends on bacterial assimilation for phosphorus removal and nitrification+denitrification for nitrogen removal, with the resulting loss of the fixed nitrogen resource. Alternatively, treatment by microalgae allows for assimilative removal of both phosphorus (P) and nitrogen (N) thereby avoiding the oxygen demand of nitrification and preserving fixed N for fertilizer use. Paddle wheel mixed high-rate ponds have much higher algal productivity than typical oxidation ponds, but even high-rate ponds often cannot grow sufficient algae to completely assimilate the N and P in domestic wastewater. Algae growth in high-rate ponds is usually limited by the inorganic carbon concentration. Addition of carbon dioxide to high-rate ponds, for example from flue gas, eliminates this limitation and accelerates algae growth and nutrient assimilation. This laboratory study explored the extent to which soluble N and P are removed simultaneously by CO 2 -enriched algae cultures.Algal polycultures were grown on diluted domestic wastewater media that were manipulated to obtain a wide range of N:P ratios (2.5:1 to 103:1). In addition, two levels of trace metal concentrations were studied. Media feeding was semi-continuous. The variables monitored included N and P removals, the range of N:P ratios in the algal biomass, biomass production, and alkalinity. To achieve removal of total N and P, suspended solids also must be removed prior to discharge. Since flocculation and settling is a preferred method of algae removal, the effects of low dissolved nutrient concentrations and media composition on algae sinking potential (settleability) were also investigated.The low trace metal cultures achieved >99% total ammonia nitrogen (TAN) removal for N:P ratios 2.5 through 30 and >98% dissolved reactive phosphorus (DRP) removal for N:P ratios 2.5 through 60 (with one exception at N:P-20). This removal was due to the growth of 180-500 mg/L algal volatile solids. Effluent concentrations were <0.1 mg/L TAN for N:P 2.5 through 30, and <0.5 mg/L TAN for N:P-60. DRP effluent concentrations were ≤0.02 mg/L DRP. After 24 hours of settling in beakers, nearly all cultures had total suspended solids (TSS) concentrations <40 mg/L. Alkalinity consumption increased with increasing N:P ratios.For cultures with the higher trace metal concentrations, nutrient removal was similar: >96% of TAN and >95.9% DRP removal for all N:P conditions. However, settling with these media was poor. TSS concentrations after 24-h of settling were >100 mg/L. No clear relationship for alkalinity was found for these cultures. v N:P ratios in the algal biomass correlated with the N:P ratios in the media, except for control cultures that did not receive wastewater. No relationship was found between settling and the N:P ratios of the media or biomass. Nitrogen-fixing algae thrived in media conta...
High rate algae ponds fed clarified domestic wastewater and CO2-rich flue gas are expected to remove nutrients to concentrations similar to those achieved in mechanical treatment technologies, such as activated sludge. However, the energy intensity of wastewater treatment with CO2-supplemented high rate ponds (HRPs) would be less than that of mechanical treatments. In conjunction with anaerobic digestion of algal biomass and co-substrates, the algae-based system would produce a substantial excess of electricity. Greenhouse gas abatement from such CO2-HRP/digestion systems would stem mainly from energy conservation and the offset of fossil fuel electricity with biogas-derived electricity. Laboratory experiments showed nutrient removals of >98% for ammonium and >96% for phosphorus with mixed culture microalgae grown on CO 2 -supplemented primary wastewater effluent. An engineering numerical model for CO2-HRP/digestion facilities (based in part on large-scale algae production under southern California conditions) indicates a potential energy surplus of 330 kWh/ML (1,200 kWh/MG) from biogas-derived electricity, compared to the net energy consumption of about 760 kWh/ML (2,900 kWh/MG) at typical activated sludge facilities with nitrification/denitrification. Considering the net electricity production and energy savings of the CO 2 -HRP/digestion systems, a greenhouse gas abatement potential of 660 kg CO 2eq /ML (2,500 kg CO 2eq /MG) treated is expected for a 100-ha facility treating 20 MGD.
High rate algae ponds fed clarified domestic wastewater and CO2-rich flue gas are expected to remove nutrients to concentrations similar to those achieved in mechanical treatment technologies, such as activated sludge. However, the energy intensity of wastewater treatment with CO2-supplemented high rate ponds (HRPs) would be less than that of mechanical treatments. In conjunction with anaerobic digestion of algal biomass and co-substrates, the algae-based system would produce a substantial excess of electricity. Greenhouse gas abatement from such CO2-HRP/digestion systems would stem mainly from energy conservation and the offset of fossil fuel electricity with biogas-derived electricity. Laboratory experiments showed nutrient removals of >98% for ammonium and >96% for phosphorus with mixed culture microalgae grown on CO 2 -supplemented primary wastewater effluent. An engineering numerical model for CO2-HRP/digestion facilities (based in part on large-scale algae production under southern California conditions) indicates a potential energy surplus of 330 kWh/ML (1,200 kWh/MG) from biogas-derived electricity, compared to the net energy consumption of about 760 kWh/ML (2,900 kWh/MG) at typical activated sludge facilities with nitrification/denitrification. Considering the net electricity production and energy savings of the CO 2 -HRP/digestion systems, a greenhouse gas abatement potential of 660 kg CO 2eq /ML (2,500 kg CO 2eq /MG) treated is expected for a 100-ha facility treating 20 MGD.
scite is a Brooklyn-based organization that helps researchers better discover and understand research articles through Smart Citations–citations that display the context of the citation and describe whether the article provides supporting or contrasting evidence. scite is used by students and researchers from around the world and is funded in part by the National Science Foundation and the National Institute on Drug Abuse of the National Institutes of Health.
customersupport@researchsolutions.com
10624 S. Eastern Ave., Ste. A-614
Henderson, NV 89052, USA
Copyright © 2024 scite LLC. All rights reserved.
Made with 💙 for researchers
Part of the Research Solutions Family.