No abstract

No abstract

Nano-TiO(2) has the highest production of all nanomaterials, and pigment-TiO(2) is a commodity used on the million tons/year scale. Information on the release of TiO(2) from consumer products is therefore an important part of analyzing the potential environmental exposure to TiO(2). For this study, we investigated the release of TiO(2) from six different functional textiles during washing. TiO(2) is used in textiles because of its UV-absorbing properties and as pigment. Analysis of fiber cross sections showed that the TiO(2) was contained in the fiber matrix. The sun-protection textiles had Ultraviolet Protection Factors that were between 58 and 6100 after washing and therefore above the labeled factor of 50+. Five of the textiles (sun-protection clothes) released low amounts of Ti (0.01 to 0.06 wt % of total Ti) in one wash cycle. One textile (with antimicrobial functionality) released much higher amounts of Ti (5 mg/L, corresponding to 3.4 wt % of total Ti in one wash cycle). Size fractionation showed that about equal amounts were released as particles below and above 0.45 μm. After 10 washings, only in two textiles significantly lower Ti contents were measured. Electron microscopy showed that the TiO(2) particles released into washing solution had a roundish appearance with primary particle sizes between 60 and 350 nm that formed small aggregates with up to 20 particles. The results indicate that functional textiles release some TiO(2) particles, but that the amounts are relatively low and mostly not in the nanoparticulate range.

Engineered nanoparticles (ENP) are increasingly used to functionalize textiles taking advantage, e.g., of the antimicrobial activity of silver (Ag)-ENP or the UV-absorption of titania (TiO2)-ENP. Mobilization and migration of ENPs from the textile into human sweat can result in dermal exposure to these nanoobjects and their aggregates and agglomerates (NOAA). In this study we assessed exposure to NOAA migrating from commercially available textiles to artificial sweat by an experimental setup that simulates wear-and-tear during physical activity. By combining physical stress with incubation in alkaline and acidic artificial sweat solutions we experimentally realized a worst case scenario for wearing functionalized textiles during sports activities. This experimental approach is not limited to NOAA, but can be used for any other textile additive. Out of four investigated textiles, one T-shirt and one pair of trousers with claimed antimicrobial properties were found to release Ag <450 nm in detectable amounts (23-74 μg/g/L). Textiles containing TiO2 for UV protection did not release significant amounts of TiO2 <450 nm, but the antimicrobial T-shirt released both TiO2 and Ag <450 nm. The silver was present in dissolved and particulate form, whereas TiO2 was mainly found as particulate. On the basis of our experimental results we calculated external dermal exposure to Ag and TiO2 for male and female adults per use. For silver, maximal amounts of 17.1 and 8.2 μg/kg body weight were calculated for total and particulate Ag <450 nm, respectively. For TiO2, the exposure levels amount to maximal 11.6 μg/kg body weight for total (mainly particulate) TiO2. In comparison with other human exposure pathways, dermal exposure to NOAA from textiles can be considered comparably minor for TiO2-NOAA, but not for Ag-NOAA.