Although Saccharomyces cerevisiae is capable of fermenting galactose into ethanol, ethanol yield and productivity from galactose are significantly lower than those from glucose. An inverse metabolic engineering approach was undertaken to improve ethanol yield and productivity from galactose in S. cerevisiae. A genome-wide perturbation library was introduced into S. cerevisiae, and then fast galactose-fermenting transformants were screened using three different enrichment methods. The characterization of genetic perturbations in the isolated transformants revealed three target genes whose overexpression elicited enhanced galactose utilization. One confirmatory (SEC53 coding for phosphomannomutase) and two novel targets (SNR84 coding for a small nuclear RNA and a truncated form of TUP1 coding for a general repressor of transcription) were identified as overexpression targets that potentially improve galactose fermentation. Beneficial effects of overexpression of SEC53 may be similar to the mechanisms exerted by overexpression of PGM2 coding for phosphoglucomutase. While the mechanism is largely unknown, overexpression of SNR84, improved both growth and ethanol production from galactose. The most remarkable improvement of galactose fermentation was achieved by overexpression of the truncated TUP1 (tTUP1) gene, resulting in unrivalled galactose fermentation capability, that is 250% higher in both galactose consumption rate and ethanol productivity compared to the control strain. Moreover, the overexpression of tTUP1 significantly shortened lag periods that occurs when substrate is changed from glucose to galactose. Based on these results we proposed a hypothesis that the mutant Tup1 without C-terminal repression domain might bring in earlier and higher expression of GAL genes through partial alleviation of glucose repression. mRNA levels of GAL genes (GAL1, GAL4, and GAL80) indeed increased upon overexpression of tTUP. The results presented in this study illustrate that alteration of global regulatory networks through overexpression of the identified targets (SNR84 and tTUP1) is as effective as overexpression of a rate limiting metabolic gene (PGM2) in the galactose assimilation pathway for efficient galactose fermentation in S. cerevisiae. In addition, these results will be industrially useful in the biofuels area as galactose is one of the abundant sugars in marine plant biomass such as red seaweed as well as cheese whey and molasses.

No abstract

No abstract

Kluyveromyces marxianus is now considered one of the best choices of option for industrial applications of yeast because the strain is able to grow at high temperature, utilizes various carbon sources, and grows fast. However, the use of K. marxianus as a host for industrial applications is still limited. This limitation is largely due to a lack of knowledge on the characteristics of the promoters since the time and amount of protein expression is strongly dependent on the promoter employed. In this study, four well-known constitutive promoters (P(CYC), P(TEF), P(GPD), and P(ADH)) of Saccharomyces cerevisiae were characterized in K. marxianus in terms of protein expression level and their stochastic behavior. After constructing five URA3-auxotrophic K. marxianus strains and a plasmid vector, four cassettes each comprising one of the promoters--the gene for the green fluorescence protein (GFP)--CYC1 terminator (T(CYC)) were inserted into the vector. GFP expression under the control of each one of the promoters was analyzed by reverse transcription PCR, fluorescence microscopy, and flow cytometer. Using these combined methods, the promoter strength was determined to be in the order of P(GPD) > P(ADH) ∼ P(TEF) >> P(CYC). All promoters except for the P(CYC) exhibited three distinctive populations, including non-expressing cells, weakly expressing cells, and strongly expressing cells. The relative ratios between populations were strongly dependent on the promoter and culture time. Forward scattering was independent of GFP fluorescence intensity, indicating that the different fluorescence intensities were not just due to different cell sizes derived from budding. It also excluded the possibility that the non-expressing cells resulted from plasmid loss because plasmid stability was maintained at almost 100 % over the culture time. The same cassettes, cloned into a single copy plasmid pRS416 and transformed into S. cerevisiae, showed only one population. When the cassettes were integrated into the chromosome, the stochastic behavior was markedly reduced. These combined results imply that the gene expression stochasticity should be overcome in order to use this strain for delicate metabolic engineering, which would require the co-expression of several genes.

No abstract

A point mutation (E115K) resulting in slower growth of Escherichia coli DH5␣ and XL1-Blue in minimal media was identified in the purB gene, coding for adenylosuccinate lyase (ASL), through complementation with an E. coli K-12 genomic library and serial subcultures. Chromosomal modification reversing the mutation to the wild type restored growth phenotypes in minimal media.The Escherichia coli DH5␣ strain possesses many beneficial genotypes (recA, deoR, gyrA, and endA1) and has been widely used for many purposes, such as gene cloning and protein production (5). However, E. coli DH5␣ also exhibits inferior growth phenotypes, especially in minimal media, compared to other E. coli strains. As such, the utilization of this bacterium has been limited to the laboratory despite its numerous advantages. We can assume that these inferior growth phenotypes have resulted from unknown accumulated mutations during the strain development process (5). Some of those mutations, which might impact growth in minimal media, have been characterized, including the phenotypes for thiamine requirement and relaxed amino acid synthesis (5). Still, there may be other uncharacterized mutations whose interactions hamper the growth of E. coli DH5␣ in minimal media.Based on successful identifications (6, 7) of gene targets for metabolic engineering (3), we performed serial subcultures of E. coli DH5␣ transformants with an E. coli K-12 genomic library based on a multicopy plasmid (9) to isolate genes that improve growth phenotypes in minimal media. The M9 minimal medium and R medium (11) were chosen for enrichment experiments because of their popular use in metabolic engineering (1, 2, 7) and in high-cell-density fermentation (8, 10, 11). After 11 serial transfers of the transformants in the M9 medium, and 27 transfers in the R medium, cultured cells were diluted and plated onto LB agar for single-colony isolation. Although more than 10 colonies were picked, only three distinctive plasmids, containing different inserts, were isolated from the transformants enriched in M9 medium. In the case of R medium enrichment, all isolated plasmids were identical. Sequencing of the isolated plasmids revealed the exact genome coordinates of each insert. A diagram of the inserts in the context of the E. coli genome sequence is shown in Fig. 1. Interestingly, all of the isolated plasmids contained similar regions of genomic DNA. mnmA (tRNA 5-methylaminomethyl-2-thiouridylate-methyltransferase), purB (adenylosuccinate lyase), and hflD (lysogenization regulator) were the annotated genes in the overlapping region among distinctive isolated fragments. However, since the N-terminal portions of mnmA and hflD were truncated in some of the inserts, we selected only the M3 and R1 plasmids for further experimentation. These two plasmids were retransformed into E. coli DH5␣ for confirmation of their beneficial effects on growth of E. coli in minimal media. The newly transformed strains showed growth phenotypes almost identical to those of the previously isolated transfor...

No abstract